2009 DODGE VIPER steering

Chassis
Component Fluid, Lubricant, or Genuine Part
Transmission MOPARATF+4 Automatic Transmission Fluid
Rear Axle MOPARSynthetic Gear and Axle Lubricant SAE 75W-140 or equivalent,
with Limited Slip Additive Friction Modifier
Brake Master Cylinder MOPARBrake and Clutch Fluid DOT 4 Motor Vehicle or equivalent
Power Steering Reservoir MOPARPower Steering Fluid + 4, MOPARATF+4 Automatic Transmission
Fluid
248 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery, and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering, and transmission,
and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
NOTE:Also, inspect the exhaust system if you notice a
change in the sound of the exhaust system, or if the
exhaust fumes can be detected inside the vehicle.
•Inspect the brake hoses.
•Inspect the suspension components.
•Lubricate door hinges and check springs.
•Check the engine coolant level, hoses, and clamps.
•Check power steering fluid level.
252 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Location..........................192,207
Saving Feature (Protection)............... 210
Storing Vehicle........................ 210
Belts, Seat............................33,34
Body Mechanism Lubrication............... 212
Boot, Convertible Top...................69,74
B-Pillar Location........................ 156
Brake, Parking.......................... 145
Brake System........................147,222
Anti-Lock (ABS)....................147,148
Fluid Check.......................222,248
Master Cylinder....................... 222
Warning Light........................ 104
Break-In Recommendations, New Vehicle.....59,147
Bulb Replacement....................... 237
Bulbs, Light............................ 236
Capacities, Antifreeze (Engine Coolant)........ 246
Capacities, Fluid........................ 246Caps, Filler
Fuel................................ 175
Oil (Engine).......................... 205
Power Steering........................ 144
Radiator (Coolant Pressure)............... 219
Car Washes............................ 227
Carbon Monoxide Warning...............60,174
CD (Compact Disc) Changer................ 116
CD (Compact Disc) Player............... 111,115
Cellular Phone.......................... 125
Chains, Tire............................ 167
Charging System Light.................... 109
Chart, Tire Sizing........................ 153
Check Engine Light
(Malfunction Indicator Light)............... 201
Checks, Safety........................... 60
Child Restraint....................53,54,55,58
Child Restraint Tether Anchors............... 56
Circuit Breakers......................... 230
INDEX 281
10

Clean Air Gasoline....................... 171
Climate Control......................... 125
Clock................................ 110
Clutch Fluid........................... 224
Compact Disc (CD) Maintenance............. 124
Console............................... 94
Console, Floor........................... 94
Contract, Service........................ 273
Convertible............................. 65
Convertible Boot.......................69,74
Convertible Top.......................65,228
Convertible Top Maintenance............... 228
Coolant Pressure Cap (Radiator Cap).......... 219
Cooling System......................... 216
Adding Coolant (Antifreeze).............. 218
Coolant Capacity...................... 246
Coolant Level......................217,220
Disposal of Used Coolant................ 220
Drain, Flush, and Refill.................. 217Inspection........................... 220
Points to Remember.................... 221
Pressure Cap......................... 219
Radiator Cap......................... 219
Selection of Coolant (Antifreeze)......217,246,247
Customer Assistance..................... 271
Daytime Running Lights................... 84
Dealer Service.......................... 203
Defroster, Rear Window.................... 95
Defroster, Windshield...................61,128
Delay (Intermittent) Wipers................. 90
Diagnostic System, Onboard................ 200
Dimmer Control......................... 88
Dimmer Switch, Headlight.................. 86
Dipsticks
Power Steering........................ 144
Disposal
Antifreeze (Engine Coolant)............... 220
282 INDEX

Engine Oil Viscosity Chart................. 205
Ethanol............................... 171
Exhaust Gas Caution..............31,60,174,214
Exhaust System.......................60,214
Exterior Finish Care...................... 227
Filters
Air Cleaner.......................... 206
Engine Oil........................206,247
Engine Oil Disposal.................... 206
Finish Care............................ 227
Flashers
Hazard Warning....................103,180
Turn Signal........................85,103
Flash-To-Pass........................... 86
Flooded Engine Starting................... 136
Floor Console........................... 94
Fluid Capacities......................... 246
Fluid Leaks............................. 62Fluid Level Checks
Brake............................222,248
Capacities........................... 246
Clutch Fluid.......................... 224
Cooling System....................... 217
Engine Oil........................... 203
Manual Transmission.................224,248
Power Steering.....................144,248
Fluids................................ 247
Fluids, Lubricants and Genuine Parts.......... 247
Fog Lights.........................83,84,101
Four-Way Hazard Flasher.................. 180
Freeing A Stuck Vehicle................... 195
Fuel................................. 170
Adding............................. 175
Clean Air............................ 171
Ethanol............................. 171
Filler Cap (Gas Cap).................... 175
Gasoline............................ 170
284 INDEX

Checking............................ 203
Dipstick............................. 203
Disposal............................ 206
Filter............................206,247
Filter Disposal........................ 206
Materials Added to..................... 206
Pressure Gauge....................... 108
Recommendation...................205,246
Viscosity..........................205,246
Oil Filter, Selection....................... 206
Onboard Diagnostic System..............200,201
Operator Manual (Owner’s Manual)............ 4
Outside Rearview Mirrors.................. 77
Overheating, Engine...................... 180
Owner’s Manual (Operator Manual).........4,275
Paint Care............................. 226
Paint Damage.......................... 226
Panic Alarm............................ 21Parking Brake.......................... 145
Parking On Hill......................... 145
Passing Light........................... 86
Pedals, Adjustable........................ 92
Pets.................................. 59
Pets, Transporting........................ 59
Placard, Tire and Loading Information......... 156
Polishing and Waxing..................... 227
Power
Accessory Delay......................13,28
Brakes.............................. 147
Distribution Center (Fuses)............... 230
Door Locks........................... 26
Mirrors.............................. 78
Steering............................. 144
Windows............................. 28
Pregnant Women and Seat Belts.............. 41
Programming Transmitters
(Remote Keyless Entry).................... 22
INDEX 289
10

Steering
Power.............................. 144
Tilt Column........................... 91
Storage............................... 234
Storage, Vehicle......................... 129
Stuck, Freeing.......................... 195
Supplemental Restraint System - Airbag........ 42
Synthetic Engine Oil...................... 206
Tachometer............................ 107
Temperature Gauge, Engine Coolant.......... 108
Theft Alarm (Security Alarm)................ 13
Theft System (Security Alarm)............... 13
Tilt Steering Column...................... 91
Tire and Loading Information Placard......... 156
Tire Identification Number (TIN)............. 155
Tire Markings.......................... 151
Tire Safety Information.................... 151
TIREFIT.............................. 181Tires ............................62,160,276
Aging (Life of Tires).................... 165
Air Pressure.......................... 160
Chains.............................. 167
General Information.................... 160
High Speed.......................... 162
Inflation Pressures..................... 161
Life of Tires.......................... 165
Load Capacity........................ 156
Pressure Monitor System (TPMS)........... 169
Quality Grading....................... 276
Radial.............................. 163
Replacement......................... 166
Rotation............................. 167
Safety..........................62,151,160
Sizes............................... 153
Snow Tires........................... 167
Spinning............................ 164
Storage............................. 167
292 INDEX

INTRODUCTION INTRODUCTION HOW TO USE THIS MANUAL WARNINGS AND CAUTIONS VEHICLE IDENTIFICATION NUMBER VEHICLE MODIFICATIONS/ALTERATIONS THINGS TO KNOW BEFORE STARTING YOUR VEHICLE A WORD ABOUT YOUR KEYS
Ignition Key RemovalKey-In-Ignition ReminderVEHICLE SECURITY ALARM SYSTEM Rearming of the SystemTo Arm the SystemTo Disarm the SystemElectronicImmobilization System - Canada OnlyILLUMINATED ENTRY SYSTEM REMOTE KEYLESS ENTRY (RKE)
To Unlock the DoorsTo Lock the DoorsTo Unlatch the Trunk/LiftgateUsing The Panic AlarmProgramming Additional TransmittersBattery ReplacementGeneral InformationDOOR LOCKS Manual Door LockPower Door LocksWINDOWS Power WindowsAuto Down Feature
Wind BuffetingLIFTGATE - COUPE MODELS ONLY TRUNK LOCK AND RELEASE - CONVERTIBLE MODELS ONLY TRUNK SAFETY WARNING - CONVERTIBLE MODELS ONLY Trunk Emergency ReleaseOCCUPANT RESTRAINTS Lap/Shoulder BeltsLap/Shoulder
Belt Untwisting ProcedureEnhanced Seat Belt Reminder System (BeltAlert) Automatic Locking ModeSeat Belts and Pregnant WomenSeat Belt ExtenderDriver and Passenger Supplemental Restraint System (SRS) - AirbagChild RestraintBREAK-IN RECOMMENDATIONS
SAFETY TIPS Exhaust SystemSafety Checks You Should Make Inside the VehiclePeriodic Safety Checks You Should Make Outside The VehicleUNDERSTANDINGTHE FEATURES OF YOUR VEHICLE CONVERTIBLE TOP OPERATION - IF EQUIPPED To Lower the
TopTo Raise the TopConvertible Top Boot Cover Installation - If EquippedConvertible Top Boot Cover Removal and StorageMIRRORS Inside Day/Night MirrorOutside MirrorsPower MirrorsSEATS Manual Seat AdjustmentsTO OPEN AND CLOSE THE HOOD LIGHTS Exterior
and Interior Lighting ControlHeadlights and Parking LightsHeadlight Time DelayDaytime Running LightsLights-On ReminderBattery Saver Feature -Exterior LightsFog LightsTurn Signals High Beam/Low Beam Select SwitchFlash-to-PassInterior LightsWINDSHIELD WIPERS
AND WASHERS Intermittent Wiper SystemMist FeatureWindshield WashersTILT STEERING COLUMN ADJUSTABLE PEDALS Adjustable Foot RestCONSOLE FEATURES REAR WINDOW FEATURES Electric Rear Window DefrosterUNDERSTANDING YOUR
INSTRUMENT PANEL INSTRUMENT PANEL FEATURES INSTRUMENT CLUSTER DESCRIPTION SpeedometerMessage CenterGauges and Indicator LightsSETTING THE DIGITAL CLOCK Clock Setting ProcedureSALES CODE RAH - AM AND FM STEREO RADIO
WITH CD PLAYER AND CD/DVD CHANGER CONTROLS Radio OperationCD Player OperationCD/DVD Changer OperationNotes On Playing MP3 FilesOperation Instructions - (CD Mode For MP3 Audio Play)SATELLITE RADIO - IF EQUIPPED System ActivationElectronic
Serial Number/Sirius Identification Number (ENS/SID)Selecting Satellite Mode in RBB, RAH, REV and RBK RadiosSelecting Satellite Mode in RBP, RBU,RAZ, RB1 and RBQ RadiosSelecting a ChannelStoring and Selecting Pre-Set ChannelsUsing the PTY (Program Type)
Button (If Equipped)PTY (SCAN) ButtonPTY (SEEK) ButtonSatellite AntennaReception QualityRADIO ANTENNA CD/DVD MAINTENANCE RADIO OPERATION AND CELLULAR PHONES CLIMATE CONTROLS Air Conditioning and Heating System Operating Tips
STARTING AND OPERATING STARTING PROCEDURES Normal StartingIf Engine Fails to StartAfter StartingMANUAL TRANSMISSION Recommended Shift SpeedsSkip Shift Indicator LightDRIVING ON SLIPPERY SURFACES AccelerationTraction DRIVING THROUGH
WATER Flowing/Rising WaterShallow Standing WaterPOWER STEERING Power Steering Fluid CheckPARKING BRAKE BRAKE SYSTEM Brake Pad Break-InAnti-Lock Brake SystemTIRE SAFETY INFORMATION Tire Markings Tire Identification Number (TIN)Tire Loading
and Tire PressureTIRES - GENERAL INFORMATION Tire PressureTire Inflation PressuresTire Pressures for High Speed OperationRadial Ply TiresTire SpinningTread Wear IndicatorsLife of TireReplacement TiresTire StorageTIRE CHAINS SNOW TIRES TIRE ROTATION
RECOMMENDATIONS TIRE PRESSURE MONITOR SYSTEM (TPMS) Low Tire IndicatorFUEL REQUIREMENTS 8.4L EngineReformulated GasolineGasoline/Oxygenate BlendsE-85 Usage In Non-Flex Fuel VehiclesMMT In GasolineMaterials Added to FuelFuel System
CautionsCarbon Monoxide WarningsADDING FUEL Fuel Filler Cap (Gas Cap)TRAILER TOWING RECREATIONAL TOWING (BEHIND MOTORHOME, ETC.) Towing This Vehicle Behind Another Vehicle (Flat towing with all four wheels on the ground)GROUND CLEARANCE
WHAT TO DO IN EMERGENCIES HAZARD WARNING FLASHER IF YOUR ENGINE OVERHEATS TIREFIT KIT TIREFIT StorageTIREFIT Usage PrecautionsTIREFIT Kit Components and Operation Sealing a Tire with TIREFITJUMP-STARTING PROCEDURES FREEING
A STUCK VEHICLE TOWING A DISABLED VEHICLE MAINTAINING YOUR VEHICLE ENGINE COMPARTMENT - 8.4L ONBOARD DIAGNOSTIC SYSTEM (OBD II) EMISSIONS INSPECTION AND MAINTENANCE PROGRAMS REPLACEMENT PARTS DEALER
SERVICE MAINTENANCE PROCEDURES Engine OilEngine Oil FilterEngine Air Cleaner FilterMaintenance-Free BatteryBattery Save FeatureAir Conditioner MaintenanceBody LubricationWindshield Wiper BladesAdding Washer FluidExhaust SystemCooling SystemBrake
SystemManual TransmissionHydraulic ClutchRear AxleAppearance Care And Protection From CorrosionFUSES Power Distribution CenterMini-Power Distribution CenterVEHICLE STORAGE REPLACEMENT BULBS BULB REPLACEMENT Auxiliary High Beam Headlight,
Front Park/Turn Signal Light, Front Side Marker LightHigh Intensity Discharge Headlights (HID)Front Fog LightTaillight, Tail/Stop Light, Rear Marker LightTaillight, Tail/Stop Light, Rear Marker Light (Coupe Models)Backup Light, Rear Turn Signal LightLicense LightFLUIDS
AND CAPACITIES FLUIDS, LUBRICANTS, AND GENUINE PARTS EngineChassisMAINTENANCE SCHEDULES EMISSIONS CONTROL SYSTEM MAINTENANCE MAINTENANCE SCHEDULES MAINTENANCE SCHEDULE BMAINTENANCE SCHEDULE AIF YOU
NEED CONSUMER ASSISTANCE SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE Prepare For The AppointmentPrepare A ListBe Reasonable With RequestsIF YOU NEED ASSISTANCE Chrysler LLC Customer CenterChrysler Canada Inc. Customer
CenterIn Mexico contactCustomer Assistance For The Hearing Or Speech Impaired (TDD/TTY)Service ContractWARRANTY INFORMATION (U.S. Vehicles Only) MOPAR PARTS REPORTING SAFETY DEFECTS In The 50 United States And Washington, D.CIn Canada
PUBLICATION ORDER FORMS DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY GRADES TreadwearTraction GradesTemperature GradesINDEX