2009 DODGE VIPER fuel

Exhaust System
The best protection against carbon monoxide entry into
the vehicle body is a properly maintained engine exhaust
system.
If you notice a change in the sound of the exhaust system;
or if exhaust fumes can be detected inside the vehicle; or
when the underside or side of the vehicle is damaged;
have a competent technician inspect the complete ex-
haust system and adjacent body areas for broken, dam-
aged, deteriorated, or mispositioned parts. Open seams
or loose connections could permit exhaust fumes to seep
into the passenger compartment. In addition, inspect the
exhaust system each time the vehicle is raised for lubri-
cation or oil change. Replace as required.WARNING!
Exhaust gases can injure or kill. They contain carbon
monoxide (CO) which is colorless and odorless.
Breathing it can make you unconscious and can
eventually poison you. To avoid breathing CO, refer
to “Exhaust Gas” in the “Safety Tips” section of this
manual.
The catalytic converter requires the use of unleaded fuel
only. Leaded gasoline will destroy the effectiveness of the
catalyst as an emission control device.
Under normal operating conditions, the catalytic con-
verter will not require maintenance. However, it is im-
portant to keep the engine properly tuned to assure
proper catalyst operation and prevent possible catalyst
damage.
214 MAINTAINING YOUR VEHICLE

Cavity Car-
tridge
FuseMini-
FuseDescription
9 40 Amp
Green— Headlights
10 30 Amp
Pink— Ignition Switch Run Feed
11 — 20 Amp
YellowAuto Shutdown Relay
(ASD)
12 — 20 Amp
YellowCigar Lighter
13 — 15 Amp
BlueHazard Flasher
14 — 20 Amp
YellowAuto Shutdown Relay
(ASD)
15 — 20 Amp
YellowRear Window Defogger
(EBL)
16, 17 — 20 Amp
YellowSelectable Power OutletCavity Car-
tridge
FuseMini-
FuseDescription
18 — 15 Amp
BlueIgnition Off Draw (IOD)
19 — 15 Amp
BlueHorn
20 — 15 Amp
BlueAir Conditioning (A/C)
Clutch Relay
21 — 15 Amp
BlueSTOP LIGHT Switch
22 — 25 Amp
ClearFuel Pump/Powertrain
Control Module (PCM)
23, 24 — 10 Amp
RedAirbag
60, 61 — 15 Amp
BlueIgnition Run/Start Relay
Feed
62, 63 — 15 Amp
BlueGauges
MAINTAINING YOUR VEHICLE 231
7

VEHICLE STORAGE
We recommend that you follow these guidelines for
storing your vehicle for extended periods.
•Fill the fuel tank. This will prevent water condensation
inside the tank. If you plan to store your vehicle more
than two months, add an anti-oxidant fuel stabilizer to
the fuel tank.
•Change the oil to remove any corrosive combustion
related acids in the crankcase.
•Check that the radiator coolant level of protection is to
at least -20°F (-29°C).
•Make sure that all tires are inflated to the optimum
pressure.
•Wash and wax the vehicle to protect the finish.
•Store the vehicle in a dry, well-ventilated location.
•Move the wiper blades away from the windshield.
•Block the wheels. Do not apply the parking brake.
•Cut blocks of plywood about the same size of the tires.
Cover each block with indoor/outdoor carpeting and
place them between the tires and concrete. This will
prevent tire flat spotting.
•For long-term storage, remove the tires and put the
vehicle up on blocks. Stack the tires on plywood and
cover with a tarp to prevent flat spotting.
•If the vehicle will be subjected to freezing tempera-
tures, either remove the battery and store it in a dry,
well ventilated area or connect a trickle charger
(1.5 Amp) with automatic shutdown / overcharge
protection to the battery. However, do not leave the
trickle charger hooked up to the battery without being
plugged in to a 110 Volt AC outlet, as this will result in
further drain on the vehicle’s battery. If the vehicle is
not going to be driven in the next three weeks, perform
the battery recharge procedure in the Service Manual.
234 MAINTAINING YOUR VEHICLE

FLUIDS AND CAPACITIES
U.S. Metric
Fuel (Approximate)16 Gallons 60.6 Liters
Engine Oil with Filter
8.4 Liter Engine (SAE 0W-40, API Certified) 11 Quarts 10.4 Liters
Cooling System *
8.4 Liter Engine (MOPAREngine Coolant/Antifreeze 5
Year/100,000 Mile Formula)16 Quarts 15 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
246 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
Component Fluid, Lubricant, or Genuine Part
Engine Coolant MOPARAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid
Organic Additive Technology) or equivalent
Engine Oil For best performance and maximum protection under all types of operating
conditions, the manufacturer only recommends full synthetic engine oils that
meet the American Petroleum Institute (API) categories of SM or SM/CF, and
meet the requirements of Chrysler Material Standard MS-10725. The manufac-
turer recommends the use of a full synthetic engine oil, such as Mobil 1SAE
0W-40 or equivalent. For additional information, refer to the “Engine Oil Se-
lection” and “Engine Oil Viscosity (SAE Grade)” in the “Maintenance Proce-
dures” section of this manual.
Engine Oil Filter MOPARSRT Engine Oil Filter (P/N 05037836AA) or equivalent.
Spark Plugs RE10PMC5 (Gap 0.050 in [1.27 mm])
Fuel Selection Premium Unleaded 91 Octane Only or Higher
MAINTAINING YOUR VEHICLE 247
7

At Each Stop for Fuel
•Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery, and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering, and transmission,
and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
NOTE:Also, inspect the exhaust system if you notice a
change in the sound of the exhaust system, or if the
exhaust fumes can be detected inside the vehicle.
•Inspect the brake hoses.
•Inspect the suspension components.
•Lubricate door hinges and check springs.
•Check the engine coolant level, hoses, and clamps.
•Check power steering fluid level.
252 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

About Your Brakes....................... 147
ABS (Anti-Lock Brake System)............101,148
Accessory Delay, Power..................13,28
Adding Engine Coolant (Antifreeze).......... 218
Adding Fuel........................... 175
Adding Washer Fluid..................... 213
Adjustable Pedals........................ 92
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 206
Air Conditioner Maintenance............... 211
Air Conditioning................125,126,128,211
Air Conditioning Controls................. 126
Air Conditioning, Operating Tips............ 130
Air Conditioning Refrigerant............. 211,212
Air Conditioning System.............126,128,211
Air Pressure, Tires....................105,161
Airbag................................ 42
Airbag Deployment.....................46,51
Airbag Light...................46,47,53,61,103
Airbag Maintenance....................... 52Airbag On/Off Switch..................... 54
Alarm System (Security Alarm)............... 13
Alterations/Modifications, Vehicle............. 7
Antenna.............................. 124
Antenna, Satellite Radio................... 124
Antifreeze (Engine Coolant)...........217,218,246
Capacities........................... 246
Disposal............................ 220
Anti-Lock Brake System (ABS).............. 148
Anti-Lock Warning Light...............101,151
Anti-Theft Security Alarm (Theft Alarm)........ 13
Appearance Care........................ 226
Auto Down Power Windows................ 30
Automatic Door Locks..................... 27
Battery............................109,207
Emergency Starting..................... 192
Jump Starting......................... 192
Keyless Transmitter Replacement (RKE)....... 23
280 INDEX

Location..........................192,207
Saving Feature (Protection)............... 210
Storing Vehicle........................ 210
Belts, Seat............................33,34
Body Mechanism Lubrication............... 212
Boot, Convertible Top...................69,74
B-Pillar Location........................ 156
Brake, Parking.......................... 145
Brake System........................147,222
Anti-Lock (ABS)....................147,148
Fluid Check.......................222,248
Master Cylinder....................... 222
Warning Light........................ 104
Break-In Recommendations, New Vehicle.....59,147
Bulb Replacement....................... 237
Bulbs, Light............................ 236
Capacities, Antifreeze (Engine Coolant)........ 246
Capacities, Fluid........................ 246Caps, Filler
Fuel................................ 175
Oil (Engine).......................... 205
Power Steering........................ 144
Radiator (Coolant Pressure)............... 219
Car Washes............................ 227
Carbon Monoxide Warning...............60,174
CD (Compact Disc) Changer................ 116
CD (Compact Disc) Player............... 111,115
Cellular Phone.......................... 125
Chains, Tire............................ 167
Charging System Light.................... 109
Chart, Tire Sizing........................ 153
Check Engine Light
(Malfunction Indicator Light)............... 201
Checks, Safety........................... 60
Child Restraint....................53,54,55,58
Child Restraint Tether Anchors............... 56
Circuit Breakers......................... 230
INDEX 281
10