2009 DODGE JOURNEY fuel cap

off the message. If the problem persists, the message will
appear the next time the vehicle is started.
A loose, improperly installed, or damaged fuel filler cap
may also turn on the MIL.
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of this vehicle’s emissions control system.
Failure to pass could prevent vehicle registration.For states that require an Inspection and Mainte-
nance (I/M), this check verifies the Malfunction
Indicator Light (MIL) is functioning and is not on
when the engine is running, and that the OBD II system
is ready for testing.
Normally, the OBD II system will be ready. The OBD II
system may notbe ready if the vehicle was recently serviced, recently had a dead battery, or a battery replace-
ment. If the OBD II system should be determined not
ready for the I/M test, the vehicle may fail the test.
This vehicle has a simple ignition key-actuated test,
which you can use prior to going to the test station. To
check if this vehicle’s OBD II system is ready, you must
do the following:
1. Insert the ignition key into the ignition switch.
2. Turn the ignition to the ON position, but do not crank
or start the engine.
3. If you crank or start the engine, you will have to start
this test over.
4. As soon as you turn the ignition key to the ON
position, you will see the MIL symbol come on as part of
a normal bulb check.
422 MAINTAINING YOUR VEHICLE

Engine Oil Viscosity (SAE Grade) — 2.4L and 2.7L
Engines
SAE 5W-20 engine oil is recommended for all operating
temperatures. This engine oil improves low temperature
starting and vehicle fuel economy.
The engine oil filler cap also shows the recommended
engine oil viscosity for your engine. For information on
engine oil filler cap location, refer to the “Engine Com-
partment” illustration in this section.
Lubricants that do not have both, the engine oil certifi-
cation mark and the correct SAE viscosity grade number
should not be used.
Engine Oil Viscosity (SAE Grade) — 3.5L Engine
SAE 10W-30 engine oil is preferred for use in 3.5L
Engines for all operating temperatures.The engine oil filler cap also shows the recommended
engine oil viscosity for your engine. For information on
engine oil filler cap location, refer to the “Engine Com-
partment” illustration in this section.
Lubricants that do not have both, the engine oil certifi-
cation mark and the correct SAE viscosity grade number
should not be used.
Synthetic Engine Oils
You may use synthetic engine oils provided the recom-
mended oil quality requirements are met, and the recom-
mended maintenance intervals for oil and filter changes
are followed.
Materials Added to Engine Oil
The manufacturer strongly recommends against the ad-
dition of any additives (other than leak detection dyes) to
the engine oil. Engine oil is an engineered product and its
performance may be impaired by supplemental addi-
tives.
MAINTAINING YOUR VEHICLE 427
7

Fuel System
The Electronic Fuel Injection high-pressure fuel system’s
hoses and fittings have unique material characteristics
that provide adequate sealing and resist attack by dete-
riorated gasoline.
You are urged to use only the manufacturer’s specified
hoses and fittings, or their equivalent in material and
specification, in any fuel system servicing. It is manda-
tory to replace any damaged hoses or fittings that have
been removed during service. Care should be taken with
installing fittings to ensure they are properly installed
and fully connected. See your authorized dealer for
service.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in the “Mainte-
nance Schedule” in Section 8.
WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn’t have your full
braking capacity in an emergency.
Brake and Power Steering Hoses
When servicing the vehicle for scheduled maintenance,
inspect the surface of the hoses and nylon tubing for
evidence of heat and mechanical damage. Hard and
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling suggest deterioration of the rubber. Particu-
lar attention should be made to examining those hose
surfaces nearest to high heat sources, such as the exhaust
manifold.
446 MAINTAINING YOUR VEHICLE

FLUIDS AND CAPACITIES
ComponentU.S.Metric
Fuel (approximate)
Front Wheel Drive (FWD) Models with 2.4 Liter PZEV Engine 18.5 gal70 l
FWD Models without 2.4 Liter PZEV Engine 20.5 gal77.6 l
All-Wheel Drive Models 21.1 gal79.8 l
Engine Oil with Filter
2.4 Liter Engine (SAE 5W-20, API Certified) 4.5 qts4.26 l
2.7 Liter Engine (SAE 5W-20, API Certified) 5.5 qts5.2 l
3.5 Liter Engine (SAE 10W-30, API Certified) 5.5 qts5.2 l
Cooling System *
2.4 Liter Engine and Single- or Dual-Zone Climate Control System
(Mopar Antifreeze/Coolant 5 Year/100,000 Mile Formula) or equiva-
lent 7.9 qts
7.5 l
2.4 Liter Engine and Three-Zone Climate Control System (Mopar
Antifreeze/Coolant 5 Year/100,000 Mile Formula) or equivalent 9.8 qts
9.3 l
472 MAINTAINING YOUR VEHICLE

Brake Assist System...................... 330
Brake Assist Warning Light ................. 216
Brake Control System, Electronic ............. 328
Brake Fluid ............................ 476
Brake, Parking .......................... 323
Brake System ........................ 326,446
Anti-Lock (ABS) .................... 327,328
Fluid Check ....................... 447,476
Hoses .............................. 446
Master Cylinder ....................... 447
Parking ............................. 323
Warning Light ........................ 217
Brakes ............................. 326,446
Brake/Transaxle Interlock .................. 312
Break-In Recommendations, New Vehicle ........ 77
Brightness, Interior Lights .................. 152
Bulb Replacement ..................... 465,466
Bulbs, Light .......................... 81,465Calibration, Compass
.................. 219,228
Camera, Rear ........................... 92
Capacities, Fluid ........................ 472
Caps, Filler Fuel ................................ 372
Oil (Engine) .................. 418,419,420,427
Radiator (Coolant Pressure) ............... 442
Car Washes ............................ 452
Carbon Monoxide Warning ...............79,372
Cargo Area Cover ....................... 191
Cargo Area Features ...................... 188
Cargo Compartment ...................... 188
Light ............................ 151,188
Luggage Carrier ....................... 196
Cargo Light ............................ 151
Cargo Load Floor ........................ 188
Cargo Management System ................. 188
Rollaway Tonneau Cover ................. 191
Tri-Fold Load Floor ..................... 188
498 INDEX

Air Cleaner.......................... 429
Block Heater ......................... 311
Break-In Recommendations ................ 77
Checking Oil Level ..................... 424
Compartment ......................... 418
Coolant (Antifreeze) ................. 440,474
Cooling ............................. 440
Exhaust Gas Caution ................ 39,79,372
Fails to Start .......................... 310
Flooded, Starting ...................... 310
Fuel Requirements ..................... 368
Jump Starting ......................... 407
Oil ........................... 424,472,474
Oil Change Interval ...............210,225,426
Oil Filler Cap ................. 418,419,420,427
Oil Filter ............................ 428
Oil Filter Disposal ...................... 428
Oil Selection ....................... 426,472
Oil Synthetic ......................... 427 Operation
............................ 77
Overheating .......................... 394
Starting ............................. 307
Temperature Gauge ..................... 205
Engine Oil Viscosity ...................... 427
Enhanced Accident Response Feature .......... 61
Entry System, Illuminated .................. 20
Ethanol ............................... 369
Event Data Recorder ...................... 63
Exhaust Gas Caution ..............39,79,372,439
Exhaust System ....................... 79,439
Express Down Windows ................... 25
Exterior Folding Mirrors ................... 90
Exterior Light Service ..................... 466
Exterior Lights ........................ 81,466
Fabric Care ......................... 454,455
Filler Location Fuel ...................... 372
502 INDEX

FiltersAir Cleaner .......................... 429
Air Conditioning .................... 301,434
Automatic Transaxle .................... 451
Engine Oil ........................ 428,474
Engine Oil Disposal .................... 428
Flashers Hazard Warning ....................... 394
Turn Signal ...................... 81,149,207
Flash-To-Pass ........................... 150
Flexible Fuel Vehicles ..................... 364
Cruising Range ........................ 367
Engine Oil ........................... 366
Fuel Requirements .................. 364,365
Maintenance ....................... 364,367
Replacement Parts ..................... 367
Starting ............................. 367
Flooded Engine Starting ................... 310
Floor Console .......................... 183 Fluid, Brake
........................... 476
Fluid Capacities ......................... 472
Fluid Leaks ............................. 81
Fluid Level Checks Automatic Transaxle .................... 449
Brake ............................ 447,476
Cooling System ....................... 440
Engine Oil ........................... 424
Power Steering ..................... 436,476
Fluids ................................ 474
Fluids, Lubricants and Genuine Parts .......... 474
Fog Light Service ........................ 467
Fog Lights .................... 146,148,207,467
Folding Front Passenger Seat ............... 128
Folding Rear Seat ..................... 141,134
Freeing A Stuck Vehicle ................... 410
Front Wheel Bearings ..................... 451
Fuel ................................. 368
Adding ............................. 372
INDEX 503
10

Additives............................ 371
Clean Air ............................ 369
Conserving .......................... 226
Ethanol ............................. 369
Filler Cap (Gas Cap) .................... 372
Gasoline ............................ 368
Gauge .............................. 205
Hoses .............................. 446
Materials Added ....................... 371
Methanol ............................ 369
Octane Rating ...................... 368,474
Requirements ......................... 368
Saver Mode .......................... 226
Specifications ......................... 474
Tank Capacity ........................ 472
Fuel, Flexible ............. See Flexible Fuel Vehicles
Fuel System Caution ..................... 373
Fueling ............................... 372
Fuses ................................ 457 Garage Door Opener (HomeLink) ........... 163
Gas Cap (Fuel Filler Cap)
...............372,421
Gas Gauge (Fuel Gauge) ................... 205
Gasoline, Clean Air ...................... 369
Gasoline (Fuel) ......................... 368
Conserving .......................... 226
Gasoline, Reformulated ................... 369
Gauges Coolant Temperature .................... 205
Fuel ................................ 205
Odometer ........................... 209
Speedometer ......................... 207
Tachometer .......................... 208
Gear Ranges ........................... 314
Gearshift .............................. 314
General Information ............18,26,120,318,363
General Maintenance ..................... 424
Glass Cleaning .......................... 456
Gross Axle Weight Rating ...............375,378
504 INDEX