2009 DODGE GRAND CARAVAN brake

coating, have your vehicle repaired as soon as pos-
sible. The cost of such repairs is considered the respon-
sibility of the owner.
If you carry special cargo such as chemicals, fertilizers,
de-icer salt, etc., be sure that such materials are well
packaged and sealed.
If a lot of driving is done on gravel roads, consider
mud or stone shields behind each wheel.
Use MOPARtTouch Up Paint on scratches as soon as
possible. Your authorized dealer has touch up paint to
match the color of your vehicle.
Wheel and Wheel Trim Care
All wheels and wheel trim, especially aluminum and
chrome-plated wheels, should be cleaned regularly with
a mild soap and water to prevent corrosion. To remove
heavy soil and/or excessive brake dust, use MOPARt
Wheel Cleaner or equivalent or select a nonabrasive, non-acidic cleaner. Do not use scouring pads, steel wool,
a bristle brush, or metal polishes. Only MOPARt
or
equivalent is recommended. Do not use oven cleaner.
Avoid automatic car washes that use acidic solutions or
harsh brushes that may damage the wheels protective
finish.
Stain Repel Fabric Cleaning Procedure — If
Equipped
Stain Repel seats may be cleaned in the following man-
ner:
Remove as much of the stain as possible by blotting
with a clean, dry towel.
Blot any remaining stain with a clean, damp towel.
For tough stains, apply MOPARt Total Clean or a mild
soap solution to a clean, damp cloth and remove the
stain. Use a fresh, damp towel to remove soap residue.
MAINTAINING YOUR VEHICLE 463 7

The numbers inside the TIPM cover correspond to the
following table.
FUSES/TIPM
Cavity Cartridge
Fuse Mini-
Fuse Description
J1 40 Amp Green — Power Folding Seat
J2 30 Amp Pink — Power Liftgate Mod-
ule
J3 30 Amp Pink — Rear Door Module
(RR Door Node)
J4 25 Amp Natural — Driver Door Node
J5 25 Amp Natural — Passenger Door Node
J6 40 Amp Green — Anti-Lock Brake Sys-
tem (ABS) Pump/ESP
FUSES/TIPM
Cavity Cartridge
Fuse Mini-
Fuse Description
J7 30 Amp Pink — Anti-Lock Brake Sys-
tem (ABS) Valve/ESP
J8 40 Amp Green — Power Memory Seat
(If Equipped)
J9 40 Amp Green — PZEV Motor/Flex
Fuel
J10 30 Amp Pink — Headlamp Wash
Relay/Manifold Tun-
ing Valve
J11 30 Amp Pink — Power Sliding Door
Module/Thatchum
Relay Lock Feed
J13 60 Amp Yellow — Ignition Off Draw
(IOD) — Main
J14 40 Amp Green — Rear Window Defog-
ger
468 MAINTAINING YOUR VEHICLE

FUSES/TIPM
Cavity Cartridge
Fuse Mini-
Fuse Description
J15 30 Amp Pink — Rear Blower
J17 40 Amp Green — Starter Solenoid
J18 20 Amp Blue — Powertrain Control
Module (PCM) Trans
Range
J19 60 Amp Yellow — Radiator Fan
J20 30 Amp Pink — Front Wiper LO/HI
J21 20 Amp Blue — Front/Rear Washer
J22 25 Amp Natural — Sunroof ModuleFUSES/TIPM
Cavity Cartridge
Fuse Mini-
Fuse Description
M1 — 15 Amp BlueCenter High Mounted
Stop Light (CHMSL)/
Brake Switch
M2 — — —
M3 — 20 Amp YellowSpare Fuse
M4 — 10 Amp RedTrailer Tow
M5 — 25 Amp NaturalInverter
M6 — 20 Amp YellowPower Outlet #1
(ACC), Rain Sensor
M7 — 20 Amp YellowPower Outlet #2
(BATT/ACC SELECT)
MAINTAINING YOUR VEHICLE 469 7

FUSES/TIPM
Cavity Cartridge
Fuse Mini-
Fuse Description
M34 — 10 Amp RedPark Assist (PRK
ASST), Heater Ventila-
tion, Air Conditioning
Module (HVAC
MOD), Headlamp
Wash (HDLP WASH),
Compass (COMPAS),
IR Sensor, Rear Cam-
era, Lamp Door FT
Drv/Pass, Lamp
Flashlight, AHLM,
Relay Diesel Cabin
Heater, Rad Fan Die-
sel
M35 — 10 Amp RedHeated MirrorsFUSES/TIPM
Cavity Cartridge
Fuse Mini-
Fuse Description
M36 — 20 Amp YellowPower Outlet #3
(BATT)
M37 — 10 Amp RedAnti-Lock Brake Sys-
tem (ABS), Electronic
Stability Program
(ESP), Stop Lamp
Switch (STP LP SW),
Fuel Pump Rly Hi
Control
M38 — 25 Amp NaturalDoor Lock/Unlock
Motors (LOCK/
UNLOCK MTRS),
Liftgate Lock/Unlock
Motors
474 MAINTAINING YOUR VEHICLE

ChassisComponent
Fluid, Lubricant, or Genuine Part
Automatic Transaxle MOPARtATF+4 Automatic Transmission Fluid
Brake Master Cylinder MOPARt
DOT 3 and SAE J1703 should be used or equivalent. If DOT
3 brake fluid is not available, then DOT 4 is acceptable. Use only rec-
ommended brake fluids.
Power Steering Reservoir MOPARt
Power Steering Fluid +4 or MOPARt ATF+4 Automatic
Transmission Fluid
482 MAINTAINING YOUR VEHICLE

Once A Month
Check tire pressure and look for unusual wear or
damage.
Inspect the battery and clean and tighten the terminals
as required.
Check the fluid levels of the coolant reservoir, the
brake master cylinder, the power steering and the
transaxle and add as needed.
Check all lights and other electrical items for correct
operation.At Each Oil Change
Change the engine oil filter.
Inspect the brake hoses and lines. CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
486 MAINTENANCE SCHEDULES
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

6,000 Miles (10,000 km) or
6 Months
Maintenance Service
Schedule
Change the engine oil and engine oil
filter.
Rotate tires. Odometer Reading
DateRepair Order #
Dealer CodeSignature Authorized Chrysler Dealer 12,000 Miles (20,000 km) or 12 Months Maintenance Service
Schedule

Change the
engine oil and engine oil filter.
Rotate tires.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary.
Replace the air conditioning filter.
Inspect the brake linings, replace if necessary.
Inspect the CV Joints. Perform the first inspection at 12,000 miles (20 000 km) or
12 months.
Inspect the exhaust system. Perform the first inspection at 12,000 miles (20 000 km) or
12 months. Odometer Reading
Date Repair Order #
Dealer Code Signature Authorized Chrysler Dealer MAINTENANCE SCHEDULES 487
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

18,000 Miles (30,000 km) or
18 Months
Maintenance
Service Schedule
Change the engine oil and engine oil
filter.
Rotate tires. Odometer Reading
DateRepair Order #
Dealer CodeSignature Authorized Chrysler Dealer 24,000 Miles (40,000 km) or 24 Months Maintenance Service
Schedule

Change the
engine oil and engine oil filter.
Rotate tires.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary.
Replace the air conditioning filter.
Inspect the brake linings, replace if necessary.
Inspect the CV Joints.
Inspect the exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary. Odometer Reading
Date Repair Order #
Dealer Code Signature Authorized Chrysler Dealer488 MAINTENANCE SCHEDULES
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S