2009 Citroen BERLINGO FIRST DAG RHD fuel
[x] Cancel search: fuelPage 13 of 123
FAMILIARISATION16 - This operation must be carried out
with t h e e n g i n e s w i t c h e d o f f .
Insert the key then turn it to the
left.
Remove the cap.
A label indicates which type of fuel to
use.
W h e n y o u fi l l y o u r t a n k , d o n o t c o n t i n u e
after the third cut-off of the pump. This
could cause engine malfunctions.
The capacity of the tank is approx-
imately 55 litres for petrol engines
and 60 litres for Diesel engines. From the time this light comes on,
you have enough fuel left to cover
approximately 30 miles (50 km) .
Note: the right-hand sliding side door
cannot be opened while the fuel tank
cap is removed.
Outside the vehicle: Lift the control,
raise the bonnet and secure the strut
to keep the bonnet open.
OPENING THE BONNET
Inside the vehicle: Pull the control
on the left-hand side, under the fascia
panel.
L o w f u e l l e v e l
w a r n i n g l i g h t
61
61
FILLING WITH FUEL
Page 58 of 123
57ACCESS and STARTING-
FRONT DOORS AND SLIDING SIDE DOORS
Front doors
Side doors Front doors
The driver's door opening control
permits complete unlocking of the
v e h i c l e .
Side doors
Opening the doors from inside
Opening the doors from outside
Sliding side doors
If the fuel tank cap is removed,
the right-hand side door can-
n o t b e o p e n e d .
Locking Unlocking from the
inside
Front doors
To lock, lower button
A .
The closing control of one of the front
doors permits complete locking of
t h e v e h i c l e .
To unlock and open, lift button A and
p u l l t h e h a n d l e t o w a r d s y o u .
The driver's door opening control
permits complete unlocking of the
v e h i c l e . From the inside, the sliding
side door is opened and
c l o s e d u s i n g t h e h a n d l e .
A point of resistance at the
end of the opening travel
secures the door in the
o p e n p o s i t i o n . The side door opening/closing
control only controls the door
c o n c e r n e d .
To close, push the control
B forwards
a n d s l i d e t h e d o o r .
To open, pull the control B rearwards
a n d s l i d e t h e d o o r .
Page 63 of 123
61ACCESS and STARTING-
OPENING THE BONNET
Inside the vehicle: pull the handle on
t h e l e f t - h a n d s i d e , u n d e r t h e f a s c i a .
Outside the vehicle: lift the catch
a n d r a i s e t h e b o n n e t .
BONNET STRUT
Secure the strut to hold the bonnet
o p e n .
Before closing the bonnet, replace
t h e s t r u t i n i t s h o u s i n g .
FILLING WITH FUEL
W h e n t h e m i n i m u m
fuel level in the tank is
reached, this warning
l i g h t c o m e s o n . W h e n t h e c a p i s r e m o v e d ,
the right-hand sliding side
d o o r c a n n o t b e o p e n e d .
The key cannot be removed
from the lock until the cap
has been replaced on the
f u e l t a n k .
A label reminds you which type of
f u e l t o u s e .
W h e n y o u fi l l y o u r t a n k , d o n o t c o n -
tinue after the third cut-off of the
p u m p . T h i s c o u l d c a u s e y o u r v e h i c l e
t o m a l f u n c t i o n .
To close
Lower the bonnet and release it at
t h e e n d o f i t s t r a v e l .
C h e c k t h a t t h e b o n n e t i s l o c k e d .
Low fuel level
You have enough fuel remaining
to drive for approximately 30 miles
(50 km).
The engine must be switched off
w h e n fi l l i n g w i t h f u e l .
I n s e r t t h e k e y t h e n t u r n i t t o t h e l e f t .
R e m o v e t h e c a p .
The capacity of the tank is approxi-
mately 55 litres for petrol engines
and 60 litres for Diesel engines.
A f t e r fi l l i n g t h e t a n k , l o c k t h e c a p .
Page 89 of 123
PRACTICAL INFORMATION86 -
CHECKS O i l f i l t e r
C h a n g e t h e fi l t e r r e g u l a r l y , i n a c c o r d -
a n c e w i t h t h e s e r v i c i n g s c h e d u l e . O n l y u s e p r o d u c t s r e c o m -
mended by CITROËN or
p r o d u c t s o f e q u i v a l e n t q u a l i t y
a n d s p e c i fi c a t i o n s .
T o e n s u r e b e s t p e r f o r m a n c e f r o m
components as important as the
power steering and the braking sys-
tem, CITROËN selects and offers
q u i t e s p e c i fi c p r o d u c t s .
To prevent damage to the electrical
u n i t s , a v o i d w a s h i n g t h e e n g i n e . RUNNING OUT OF FUEL (DIESEL)
I f y o u s h o u l d r u n o u t o f f u e l , i t i s n e c -
e s s a r y t o r e - p r i m e t h e c i r c u i t :
- fi l l t h e f u e l t a n k w i t h a t l e a s t fi v e l i - tres of diesel,
- s q u e e z e a n d r e l e a s e t h e m a n u a l r e - p r i m i n g p u m p , u n d e r t h e b o n -
n e t u n d e r t h e p r o t e c t i v e c o v e r ,
u n t i l f u e l a p p e a r s i n t h e t r a n s p a r -
ent pipe,
- o p e r a t e t h e s t a r t e r u n t i l t h e e n - gine starts.
FUEL SUPPLY CUT-OFF (PETROL)
I n a s e r i o u s c o l l i s i o n , a m e c h a n i s m
p r e v e n t s f u e l f r o m r e a c h i n g t h e e n -
gine.
T o r e - e s t a b l i s h t h e f u e l s u p p l y , p r e s s
the switch on the corner of the front
r i g h t - h a n d s u s p e n s i o n a s s e m b l y , u n d e r
the bonnet.
A i r f i l t e r a n d p a s s e n g e r
c o m p a r t m e n t f i l t e r
H a v e t h e fi l t e r e l e m e n t s r e p l a c e d r e g -
u l a r l y .
I f y o u d r i v e i n d u s t y c o n d i -
t i o n s , c h a n g e t h e m t w i c e a s o f t e n .
Brake pads
Brake pad wear depends on the style
o f d r i v i n g , i n p a r t i c u l a r f o r v e h i c l e s
w h i c h a r e u s e d i n t o w n , o v e r s h o r t
distances.
It may be necessary to check the
thickness of the pads, even between
services.
D i s c a n d d r u m w e a r s t a t u s
For any information relating to check-
i n g t h e d i s c a n d d r u m w e a r s t a t u s ,
contact a CITROËN dealer. M a n u a l g e a r b o x
T h i s d o e s n o t r e q u i r e a n o i l c h a n g e .
Check the level in accordance with the
m a n u f a c t u r e r ' s s e r v i c i n g s c h e d u l e .
T o c h e c k t h e m a i n l e v e l s a n d c e r -
t a i n c o m p o n e n t s , i n a c c o r d a n c e
w i t h t h e m a n u f a c t u r e r ' s s e r v i c i n g
s c h e d u l e , r e f e r t o t h e p a g e s o f
t h e s e r v i c i n g b o o k l e t w h i c h c o r r e -
s p o n d t o y o u r v e h i c l e ' s e n g i n e .
H a n d b r a k e
Where the handbrake travel is too
g r e a t o r t h e r e i s a r e d u c t i o n i n t h e
performance of the system, the
h a n d b r a k e s h o u l d b e a d j u s t e d , e v e n
between services.
Have the system checked by a
CITROËN dealer.
Battery
A t t h e s t a r t o f w i n t e r , h a v e y o u r b a t -
tery checked by a CITROËN dealer.
Page 112 of 123
108 - PETROL ENGINES AND GEARBOXES
Model codes
GA/GB/GC/GD/GF/GG/GJ...
...KFWC
GA/GJ/GK/GN...
...NFUC
ENGINES
1.4 litre 1.6 litre
Cubic capacity (cm 3
) 1 360 1 587
Bore x stroke (mm) 75 x 77 78.5 x 82
EU standard maximum power (kW) 55 80
Maximum power at engine speed (rpm) 5 500 5 800
EU standard maximum torque (Nm) 120 147
Maximum torque at engine speed (rpm) 3 400 4 000
Fuel Ron 95 - Ron 98 Ron 95 - Ron 98
Catalytic converter Yes Yes
Gearbox Manual (5 speed) Manual (5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3 (1) - 3.25 (2) 3.2 (1) - 3.4 (2)
Gearbox-Final drive 2 2
(1) Draining by gravity - (2) Draining by suction
Page 113 of 123
109TECHNICAL DATA-
Model codes
GA/GB/GC/GD/GF/
GG/GJ/GK/GN...
...9HWC
GA/GB/GC/GD/GF/
GG/GJ/GK/GN ...
... 9HXC
GA/GB/GC/GD/GF/
GG/GJ/GK/GN...
... WJYB
ENGINES 1.6 litre Turbo HDI 75 1.6 litre Turbo HDI 92 1.9 litre
Cubic capacity (cm 3
) 1 560 1 560 1 867
Bore x stroke (mm) 75 x 88.3 75 x 88.3 82.2 x 88
EU standard maximum power (kW) 55.2 66.2 51
Maximum power at engine speed (rpm) 4 000 4 000 4 60 0
EU standard maximum torque (Nm) 175 215 125
Maximum torque at engine speed (rpm) 1 750 1 750 2 5 00
Fuel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes
Gearbox Manual (5 speed) Manual (5 speed) Manual (5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3.75 3.8 4.8
Gearbox-Final drive 1.9 1.9 1.9
DIESEL ENGINES AND GEARBOXES
Page 116 of 123
112 -
Engine Gearbox
Model
codes
Length
Version
(kg)
Urban
driving
Inter-urban
Mixed
Emission
of CO
2 by
weight (g/km)
1.4 litre Manual
GG KFWC
L2
750 9.6 6.2 7.4 175
- 1 000 - - - -
1.6 litre Manual
GG NFUC 750 - - - -
- 1 000 - - - -
1.6 litre Turbo HDI 75 Manual
GG 9HWC 750 6.7 4.7 5.4 143
- 1 000 - - - -
1.6 litre Turbo HDI 92 Manual
GG 9HXC 750 6.8 4.6 5.4 143
- 1 000 - - - -
1.9 litre Manual
GG WJYB 750 - - - -
- 1 000 - - - -
CONSUMPTION IN LITRES/100 KM (IN ACCORDANCE WITH DIRECTIVE 8 0/1268/CEE) LUDOSPACE 7 SEAT VERSION
The consumption values presented here correspond to the values communicated at the time of printing. These consumption
v a l u e s w e r e e s t a b l i s h e d i n a c c o r d a n c e w i t h d i r e c t i v e 8 0 / 1 2 6 8 / C E E . T h e y m a y v a r y d e p e n d i n g o n t h e s t y l e o f d r i v i n g , t r a f fi c
conditions, weather conditions, the load in the vehicle, t he maintenance of the vehicle and the use of the equipme nt.
Quality of the fuel used for petrol engines
The petrol engines are perfectly compatible with E5 type pet rol biofuels (containing 5 % ethanol), conforming to Europea n
standard EN 228.
E85 type fuels (containing up to 85 % ethanol) are reserved e xclusively for vehicles marketed for the use of this type of fuel
(BioFlex vehicles). The quality of the ethanol must comply with European standard EN 15376.
For Brazil only, special vehicles are marketed to run on fuels co ntaining up to 100 % ethanol (type E100).
Quality of the fuel used for Diesel engines
The Diesel engines are perfectly compatible with biofuels w hich conform to current and future European standards
(diesel fuel which complies with standard EN 590 mixed with a biofuel which complies with standard EN 14214) which can
be distributed at the pumps (possible incorporation of 0 to 7 % Fatty Acid Methyl Ester).
The use of any other type of (bio)fuel (vegetable or animal oils, domestic fuel...) is strictly prohibited (risk of damage to the
engine and fuel circuit).