2009 CHRYSLER ASPEN HYBRID engine

JOBNAME: 146224AspenHEV 2009 PAGE: 1 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/ibc
INTRODUCTION
The oil change indicator system will remind you
that it is time to take your vehicle in for scheduled
maintenance. Based on engine operation condi-
tion the oil change indicator message will illumi-
nate, this means that service is required for your
vehicle. Have your vehicle serviced as soon as
possible, within the next 800 km. The oil change
indicator message will not monitor the time since
the last oil change. Change your vehicles oil if it
has been 6 months since your last oil change even
if the oil change indicator message is NOT illu-
minated. Change your engine oil more often if
you drive your vehicle off-road for an extendedperiod of time.Under no circumstances should
oil change intervals exceed 10,000 km or
6 months, whichever comes first.Your dealer
will reset the oil change indicator message after
completing the scheduled oil change. If this
scheduled oil change is performed by someone
other than your dealer the message can be reset by
referring to the steps described in the Owner's
Manual.
The performance of all scheduled service work is
required to maintain your vehicle in good operat-
ing condition. Chrysler Canada Inc. reserves the
right to deny warranty coverage if the vehicle has
not been properly maintained. While we do not
insist that such work be performed by factory
authorized retailers, we strongly recommend that
an authorized Chrysler, Jeeptor Dodge Retailer
perform this work.AT EACH STOP FOR FUEL
²Check the engine oil level about 5 minutes
after a fully warmed engine is shut off. Check-
ing the oil level while the vehicle is on level
ground will improve the accuracy of the oil
level reading. Add oil only when the level is at
or below the ADD or MIN mark.
²Check the windshield washer solvent and add
if required.
ONCE A MONTH
²Check tire pressure and look for unusual wear
or damage.
²Inspect the battery and clean and tighten the
terminals as required.
²Check the fluid levels of coolant reservoir,
brake master cylinder, power steering and
transmission and add as needed.
²Check all lights and other electrical items for
correct operation.
²Check and clean wiper blades. Replace if
required.
AT EACH OIL CHANGE
²Change the engine oil filter.
²Inspect the brake hoses and lines.
VISUAL INSPECTIONS Ð
INSPECT FOR SIGNS OF COMPONENT
DETERIORATION AND PHYSICAL DAMAGE.
MAINTENANCEScheduled maintenance must be completed to provide the best vehicle
performance and reliability. The limited warranties in the warranty booklet DO NOT COVER
repairs required due to improper maintenance. We strongly suggest you keep track of scheduled
maintenance and keep receipts or other documents. Use only recommended MopartLubricants
and genuine MopartParts. In the event that a condition arises between maintenance intervals,
please contact your retailer. AVOID PROLONGED PERIODS OF IDLING.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICATED, FOLLOW THE
INTERVAL THAT OCCURS FIRST.

JOBNAME: 146224AspenHEV 2009 PAGE: 1 SESS: 35 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
TO OUR CUSTOMERS:
This booklet explains the maintenance schedule, the limited warranties, and optional
service contracts that apply to your new vehicle. It explains exactly what's covered,
how long each warranty lasts, and what you must do to keep the warranties in force.
Please read the warranties and other information in this booklet carefully.
THIS BOOKLET SHOULD BE KEPT IN YOUR VEHICLE.
In this booklet,9Chrysler Retailer9means any authorized retailer who sells and services
Chrysler, Jeep
tor Dodge vehicles.
9Chrysler9and9Chrysler Canada9mean Chrysler Canada Inc.
9Chrysler parts9mean Mopar
tor AutoparŸ brand parts designed for Chrysler, Jeeptand Dodge
vehicles by Chrysler Motors LLC.
Chrysler and Dodge are registered trademarks of Chrysler Canada Inc., a wholly owned subsidiary of Chrysler LLC.
Jeep is a registered trademark of Chrysler LLC used under licence by Chrysler Canada Inc. Mopar is a registered
trademark of Chrysler LLC. Autopar is a registered trademark of Chrysler Canada Inc.
CONTENTS
Warranty Information...............4Your rights and responsibilities..........4
About your warranties...............6
3/60 Basic Warranty.................7
5/100 Powertrain Warranty.............8
5/100 Diesel Engine Warranty...........9
8/130 Hybrid System Warranty..........9
Corrosion Warranty.................9
Emission Warranties................10
What is not covered................12
How to get service.................15
Other things you should know..........16
Customer Assistance...............18Arbitration.....................19
5/100 Roadside Assistance Program.....20
Optional Service Contracts...........24
Maintenance Service Schedule Coupons
3

JOBNAME: 146224AspenHEV 2009 PAGE: 6 SESS: 29 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for5 years or 100,000
kilometres,whichever occurs first, measured from the vehicle's original
warranty start date.
Vehicles placed in taxi, limousine, postal or ambulance service and all SRT
vehicles are excluded from the5-year or 100,000-kilometrePowertrain
Warranty and are covered only under the3-year or 60,000-kilometreBasic
Warranty.
²Engine-
Cylinder block and all internal parts; cylinder head assemblies;
timing case, timing chain, timing belt, gears and sprockets; vibration damper;
oil pump; water pump and housing; intake and exhaust manifolds; flywheel
with starter ring gear; core plugs; valve covers; oil pan; turbocharger housing
and internal parts; turbocharger wastegate actuator; supercharger; serpentine
belt tensioner; seals and gaskets for listed components only.
²Front-Wheel Drive(If equipped) -Transaxle case and all internal parts;
axle shaft assemblies; constant velocity joints and boots; differential
cover; oil pan; transaxle speed sensors; transaxle solenoid assembly;
PRNDL position switch; transaxle electronic controller; torque con-
verter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.²Rear-Wheel Drive(If equipped)- Transmission case and all internal
parts; torque converter, drive/flex plate; transmission range switch;
transmission control module; bell housing; oil pan; seals and gaskets for
listed components only. Rear axle housing and all internal parts; axle
shafts; axle shaft bearings; driveshaft assemblies; driveshaft centre
bearings; universal joints and yokes; seals and gaskets for listed
components only.
²4-Wheel Drive (4x4)(If equipped)- Transfer case and all internal parts;
transfer case control module and shift mode motor assembly; axle
housing and all internal parts; axle shafts; axle shaft bearings; driveshaft
assemblies (front and rear); driveshaft centre bearings; universal joints
and yokes; disconnect housing assembly; seals and gaskets for listed
components only.
²All-Wheel Drive (AWD)(If equipped)- Power transfer unit and all
internal parts; driveshaft and axle shaft assemblies; constant velocity
joints and boots; axle housing and all internal parts; differential carrier
assembly and all internal parts; output ball bearing; output flange; end
cover; viscous converter clutch; overrunning clutch; vacuum motor;
torque tube; pinion spacer and shim; seals and gaskets for these parts
only.
8
5/100 POWERTRAIN WARRANTY

JOBNAME: 146224AspenHEV 2009 PAGE: 7 SESS: 36 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
5/100 DIESEL ENGINE WARRANTY(IF EQUIPPED)
The diesel engine parts are covered for5 years or 100,000 kilometres,
whichever occurs first.
²Diesel Engine-
Cylinder block and all internal parts; cylinder head
assemblies; core plugs; fuel injection pump and injectors; intake and exhaust
manifolds; oil pan; oil pump; timing gear drive belts and/or chains and cover;
turbocharger housing and internal parts; valve covers; water pump and
housing; seals and gaskets for listed components.
8/130 HYBRID SYSTEM WARRANTY(IF EQUIPPED)
These hybrid system parts are covered for8 years or 160,000 kilometres,
whichever occurs first.
²Transmission and all internal components
²TPIM Fan
²TPIM Pump
²TPIM Assembly
²APM Assembly
²HV AC Cables
²HV DC cables
²Hybrid Battery
CORROSION WARRANTY
For 3 years, regardless of distance driven,your Corrosion Warranty
covers any body sheet metal panel which develops a hole caused by
corrosion.
In addition, outer body panels are covered against holes caused by
corrosion up to5 years or 160,000 kilometres,whichever occurs first. An
outer body panel is a sheet metal panel which can be seen while walking
around the vehicle, and which is painted body colour.
This warranty applies only to holes caused by corrosion. Cosmetic or
surface corrosion (resulting from stone chips or scratches in the paint, for
example) will not be repaired under this warranty.
If corrosion damage is obviously neglected and allowed to worsen until a
hole develops, this warranty will not cover the repair.
9
5/100 DIESEL ENGINE / 8/130 HYBRID SYSTEM / CORROSION WARRANTIES

JOBNAME: 146224AspenHEV 2009 PAGE: 10 SESS: 29 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
WHAT IS NOT COVERED
DAMAGE FROM MISUSE OR ACCIDENT
The warranties in this booklet do not cover repairs required due to fire,
accidents, abuse, negligence, objects striking your vehicle, carrying corro-
sive materials (such as chemicals, acids and fertilizers), misuse (such as
driving over curbs, overloading, spinning wheels, etc.), racing or partici-
pating in a racing event, improper disconnection of components, modifying
the exhaust system, tampering or making adjustments which do not comply
with Chrysler specifications.
Disconnecting, tampering with or changing the reading of the odometer
will void your warranties.
DAMAGE FROM THE ENVIRONMENT
The warranties in this booklet do not cover fading or deterioration caused
by exposure to the elements, or repairs required due to airborne fallout,
acid rain, chemicals, tree sap, insects, bird or insect droppings, salt, sand,
gravel, road hazards, hail, windstorms, lightning, floods or any other event
of nature.Road salt, car washes, scuffs and scratches, and everyday abrasion from
sand and dirt can affect the appearance of a vehicle's wheels (steel, chrome
and aluminum) and other undercarriage parts. Some surface corrosion with
use is normal; it is not a defect and is not covered by any warranty.
NORMAL MAINTENANCE AND WEAR
The warranties in this booklet do not cover normal maintenance services,
such as oil and filter changes, general lubrication, tire rotation, engine
tune-ups and replacing spark plugs. Required maintenance services are
described in detail in your Owner's Manual and herein. The warranties also
do not cover worn wiper blades, clutch discs, brake rotors, pads, linings or
drums, windshield and rear window, wheel alignment and wheel balancing
(unless they are defective, see page 7).
12
WHAT IS NOT COVERED

JOBNAME: 146224AspenHEV 2009 PAGE: 14 SESS: 30 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
OTHER THINGS YOU SHOULD KNOW
OPTIONAL SERVICE CONTRACT
Chrysler Canada has a service contract specially designed for most new
vehicles, to cover repair costs beyond your vehicle's warranty. Protection
is available for almost every operating part of your vehicle, and at
reasonable cost.
Chrysler Canada stands fully behind its service contracts. Be sure that the
contract you buy is a genuineChryslerService Contract. We arenot
responsible for other companies' contracts. See page 24 for details on
available service contracts.
APPEARANCE ITEMS
Defects or damage to sheet metal, paint, trim and other appearance items
are normally found and corrected during new vehicle inspection. For your
protection, if you find any such defect or damage, you should tell your
selling retailer immediately, because if the problem worsens due to use and
exposure, repairs will not be covered by any warranty.
PRODUCTION CHANGES
Chrysler Canada and its retailers reserve the right to make changes in
vehicles built and/or sold at any time without incurring any obligations to
make the same or similar changes on vehicles which were built and/or sold
previously.
EXCHANGE PARTS
To reduce the amount of time your vehicle is out of service due to repairs,
Chrysler may offer exchange service on some parts. Mopar
tor AutoparŸ
brand exchange parts may be new, remanufactured, reconditioned or
repaired, but all meet Chrysler standards and are warranted the same as
new parts. Examples of parts that may be serviced by exchange include
engines, transmissions, instrument clusters, radios, tape and CD players,
speedometers and various electronic modules.
16
OTHER THINGS YOU SHOULD KNOW

JOBNAME: 146224AspenHEV 2009 PAGE: 23 SESS: 30 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
1. POWERTRAIN PLANS*
Powertrain plans complement the factory powertrain warranty by provid-
ing enhanced roadside coverage and car rental allowance if your vehicle is
not drivable and must be kept overnight. Certain plans also provide
additional distance coverage.
Major components covered are:
²engine²transmission²front-wheel drive²rear-wheel drive
²4-wheel drive (4x4)²all-wheel drive vehicles
2.(GOLD(PLANS*
Each plan provides full mechanical repair protection to non-powertrain
(Gold) components. Certain plans also provide full mechanical protection
against powertrain component repairs beyond your vehicle's powertrain
warranty coverage. Contracts are available with or without a deductible.
Major components covered are:
²steering²air conditioning²engine cooling and fuel²front suspension
²rear suspension²electrical²hydraulic brake components²anti-lock
brakes
* Maximum terms available on new vehicles registered in Canada only.
3.(GOLDPLUS(PLANS*
The most complete protection available for your new vehicle is a9Gold
Plus9Service Contract which combines the benefits of Gold component
coverage (see9Gold9Plans), plus, the most important vehicle maintenance
functions:
²Engine oil and oil filter changes
²Tire rotation every other service
²9Peace-of-Mind9motoring with Tire Road Hazard Protection
which provides full, or pro-rata, replacement of the original four
tires, or their repair
²Rental car allowance for same-day warranty repairs - your vehicle
need not be kept overnight before eligibility for the rental allow-
ance is met
25
OPTIONAL CHRYSLER CANADA SERVICE CONTRACTS

JOBNAME: 146224AspenHEV 2009 PAGE: 1 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
Perform Maintenance At
10,000 km or 6 Months
oChange the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 10 000 km or 6 months whichever occurs first.*
oRotate tires.
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance
At
6 Months or
10,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................