2009 Alfa Romeo MiTo heater

GETTING TO KNOW YOUR CAR19
1
Glow plug preheating
(Diesel versions) (amber)
When the key is turned to MAR the warning light comes
on and it will go out when glow plugs reach the preset
temperature. The engine may be started immediately after the
warning light goes out.
IMPORTANT In mild or high temperature conditions, the warning
light comes on for a very short time only.
Glowheater plugs preheating failure warning
light
(Diesel versions)
If this warning light flashes (on some versions together with a mes-
sage in the display), this indicates a failure in the glowheater plugs
preheating system. Contact an Alfa Romeo Authorised Service
Provider as soon as possible to eliminate the fault.
m
Water in diesel fuel filter
(Diesel versions) (amber)
This warning light remains on constantly when driving
(together with a message in the display), to indicate the
presence of water in the diesel fuel filter.c
The presence of water in the fuel system circuit may
cause severe damage to the injection system and
irregular engine operation. If the
cwarning light
comes on in the instrument panel (together with a mes-
sage in the display) contact an Alfa Romeo Authorised Ser-
vice as soon as possible to bleed the system. Water may
have been introduced into the tank if this indication ap-
pears immediately after refuelling: in this case switch off
the engine immediately and contact an Alfa Romeo Au-
thorised Service.
001-126 Alfa MiTo GB 13-11-2008 10:08 Pagina 19

GETTING TO KNOW YOUR CAR75
1
ADDITIONAL HEATER
(only for diesel versions) (where provided)
This device speeds up passenger compartment warming when it is
very cold. The additional heater turns off automatically after reach-
ing the required comfort conditions.
Automatic two-zone climate control system
The additional heater is turned on automatically by turning the ig-
nition to MAR
Manual heater and manual climate
control system
The additional heater is activated automatically by turning knob
A to the end of the red section and setting the fan (knob B) to at
least the 1
stspeed.
IMPORTANT NOTES
The heater only works if the outside temperature and engine coolant
temperature are low.
The heater will not activate if the battery voltage is too low.
SWITCHING OFF THE CLIMATE
CONTROL SYSTEM
Press the OFF button. With the climate control system switched off:
❍air recirculation is on, thus isolating the passenger compartment
from the outside;
❍the compressor is off;
❍the fan is off.
❍the heated rear windscreen can be switched on or off.
IMPORTANT The climate control system control unit will store the
temperatures set before turning off and will restore them when any
button is pressed (except button G); if the function corresponding
to the button pressed is off it will be turned on; if on, it will be kept
active.
To restart the climate control system in fully automatic mode press
AUTO.
001-126 Alfa MiTo GB 13-11-2008 10:08 Pagina 75

STARTING UP AND DRIVING155
3
Electric devices
Use electric devices only for the amount of time needed. The heat-
ed rear windscreen, additional headlights, windscreen wipers and
heater fan require a considerable amount of energy; increasing the
current uptake increases fuel consumption (by up to +25% in an
urban cycle).
Climate control
Using the climate control system increases fuel consumption: use
the air vents when outdoor temperature permits.
Spoilers
The use of non-certified spoilers may adversely affect air drag and
fuel consumption.
DRIVING STYLE
Starting
Do not warm the engine up with the car at a standstill and do not
use excessive engine speeds: the engine warms up very slowly in
these conditions, increasing fuel consumption and emissions. It is
advisable to start off immediately and slowly, keeping the engine
speed down: the engine will warm up much faster this way.
Unnecessar y actions
Avoid revving up when starting at traffic lights or before stopping
the engine. The latter action, like double-declutching, is unneces-
sary and causes increased fuel consumption and pollution.
Gear selection
When traffic and road conditions allow, use a high gear. Using a
low gear for faster acceleration will increase fuel consumption. In
the same way improper use of a high gear increases consump-
tion, emissions and engine wear.
Top speed
Fuel consumption considerably increases as speed increases. Keep
your speed as even as possible, avoiding unnecessary braking
and acceleration which cause excessive fuel consumption and in-
creased emissions.
Acceleration
Sudden acceleration has a very negative effect on fuel consump-
tion and emissions: accelerate gradually and do not go over the
maximum torque ratio.
149-158 Alfa MiTo GB 12-11-2008 15:41 Pagina 155

41
41
41
41
43
41
41
41
41
41
41
41
41
4115
20
15
10
7.5
30
5
10
5
7.5
30
15
15
20F08
F09
F10
F11
F13
F15
F16
F17
F18
F19
F20
F21
F22
F22
IN AN EMERGENCY189
4
CONSUMERS FUSE AMPERE FIGURE
Heated windscreen
Headlight washer pump
Two-tone horn
Waste gate solenoid, Shut off solenoid, Canister solenoid,
Lambda Sensor Heater, VGT solenoid,
EGR cooling bypass solenoid, Swirl solenoid,
Throttle solenoid, Glow plug preheating control unit
Headlight alignment adjustment system
Additional heater (PTC 1)
Engine management control unit
Engine management control unit (power supply)
Control system relay coil,
Engine management control unit (1.4 versions),
Engine cooling system remote control switch coil
(300W+300W)
Air conditioning compressor
Heated rear windscreen, demisting system
Fuel pump on tank
Engine management system main loads (1.4 versions)
Engine management system main loads
(1.6 JTDMversions)
159-196 Alfa MiTo GB 12-11-2008 15:46 Pagina 189

5
7.5
5
5
15
10
15
20
IN AN EMERGENCY191
4
43
43
43
43
45
45
45
45F49
F50
F51
F53
F4
F5
F6
F1
CONSUMERS FUSE AMPERE FIGURE
Parking sensors control unit, Tyre pressure
detection control unit, Rain/dusk sensor
on rear-view mirror, Electro-chrome sensor
on rear-view mirror, Seat belts fastened
warning light display on rear-view mirror,
Control panel illumination (Central control
panel, Driver-side control panel, Steering wheel
control panel, Blue&Me
TMcontrol panel),
Front seat heating pad activation switch,
Alarm system volume-sensing sensors control unit,
Electric sunroof control unit,
PND socket on dashboard
Air Bag system control unit
Clutch switch, Brake light
switch, relay coils on
engine fuse box, Control system on
internal heater/air conditioning unit,
Blue&Me
TMcontrol unit,
Radio wiring, Air flow meter,
Water in diesel fuel sensor
Instrument panel
Bose HI-FI system amplifier control unit
Bassbox subwoofer in spare wheel compartment
Left and right front seat heater
Electric sunroof opening system
159-196 Alfa MiTo GB 12-11-2008 15:46 Pagina 191

CARE AND MAINTENANCE199
5
SCHEDULED SERVICING PLAN
PETROL VERSIONS
Thousands of kilometres
Check tyre condition/wear and adjust pressure if required
Check lighting system operation (headlights, direction indicators, hazard lights, passenger
compartment lights, boot lights, instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check the position/wear of the windscreen/rearscreen wiper blades
Check condition and wear of front disc brake pads and
brake pad wear indication
Check rear disc brake pad condition and wear
Visually inspect the condition of: bodywork, underbody
protection, pipes and hoses (exhaust - fuel - brakes),
rubber parts (gaiters, sleeves, bushes, etc.)
Check cleanliness of locks, bonnet and boot, and
cleanliness and lubrication of linkages
Check and top up, if required, fluid levels
(engine coolant, brake/hydraulic clutch fluid, windscreen washer fluid, battery fluid, etc)
Check the handbrake lever travel and adjust it, if necessary
Check timing belt condition
Visually inspect condition of auxiliary drive belt/s
Check tension and adjust auxiliary drive belt (versions with heater system)30 60 90 120 150 180
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●
●●
●●
197-220 Alfa MiTo GB 12-11-2008 15:42 Pagina 199

242INDEX
Headlights.................................... 105
Heating/climate control system ....... 64
Hill Holder system .......................... 108
Identification data ......................... 222
In an emergency ............................ 159
Installing a navigation system (wiring) 116
Instrument panel and instruments .....8-244
Interior equipment .......................... 89
Interiors (cleaning) ......................... 219
Isofix (standard seat)...................... 141
Jacking the car.............................. 193
Keys ........................................... 47
Knowing your car............................ 5
Load limiters ................................ 131
Main beam headlights
– activation ................................ 77
– bulb replacement ...................... 176
Menu ........................................... 32
Menu options ................................ 32
MSR (system) ............................... 110
Number plate lights
– bulb replacement ...................... 179
Oddment compartment .................. 89
Oil engine ..................................... 209
Paint .......................................... 217
Parking........................................ 152
Performance ................................. 234
Power windows ............................. 96
Pretensioners................................ 130
Protecting the environment .............. 126
Puddle lights
– bulb replacement ...................... 183
Radio transmitters and cellular phones .. 117
Radio wiring system ....................... 115
Rear fog lights
– activation ................................ 87
– bulb replacement ...................... 179
Rear screen wiper
– activation ................................ 79
– brushes ................................... 213
– sprays..................................... 213
Rear view mirrors ........................... 61
Reversing light
– bulb replacement ...................... 179
Roof rack/ski rack ......................... 104
S.B.R. system............................... 129
Safe lock (device)........................... 51
Safety.......................................... 127
Seat belts ..................................... 128
Seats ........................................... 56
Sensors
– automatic headlights ................. 76
– rain ........................................ 80
– parking ................................... 117
Service Plan .................................. 199
– regular checks .......................... 203
Setting off and driving ....................149
Sidebags...................................... 145
Sidelights/daytime lights
– activation ................................ 76
– bulb replacement .................176-178
Snow chains ................................. 158
Starting the engine ....................150-160
Start-up device .............................. 55
Steering....................................... 228
Steering lock ................................. 56
Steering wheel (adjustment) ........... 60Storing the car ............................... 158
Sun visors ..................................... 91
Supplementary heater..................... 75
Suspension................................... 228
Symbols....................................... 46
T.P.M.S. (system) ......................... 120
Technical data ............................... 221
Third brake light ............................. 179
Top speeds .................................... 234
Towing the car ............................... 194
Towing trailers ............................... 156
TPMS system ................................ 120
Transmission ................................. 227
Trip Computer ................................ 42
Tyre marking ................................. 229
– inflation pressures .................... 232
Tyres
– standard ................................. 231
– snow tyres .............................. 157
– correct reading of ...................... 229
VDC (system) .............................. 108
Warning lights on panel ................ 12
Weights ........................................ 235
Wheel replacement ........................ 161
Wheel rims
– correct reading ......................... 230
Wheels
– bulb replacement ...................... 161
– technical specifications .............. 229
Wheels and tyres ........................... 213
Window cleaning............................ 79
Windows (cleaning) ....................... 218
Windscreen wiper
– activation ................................ 79
– brushes ................................... 214
241-248 Alfa MiTo GB 12-11-2008 15:44 Pagina 242