Booklet 3.1 Controls and Equipment
Ap plies to ve hicles : with a di esel engine
Starting the diesel engine
The engine can only be started a genuine Volkswagen key the correct
code.
- Move the se lector lever to P (Park) or N
(Ne utral )
98.
- Dep ress the foot brake. In vehicles with
manual transm iss ion d epress th e clutch
pedal.
- Turn the igni tion key to position
93, 76 The g low plug
warni ng light light s up while the glow
plug s are warm ing up.
- When the warning light goes out, turn
the key to pos ition
93, fig. 76
sta rt the engine. Do not press the acc eler
ator.
- Release the ign itio n key as soon as the
e ngin e starts to avoid damaging the
start er.
When start ing a cold eng ine, it may be a litt le
nois y for the fir st few se conds until oil pre ssur e
h as bui lt up in the hydrauli c
valve lift ers . This is
normal and no cause for conce rn.
When staring a warm engine, the pre -glow
warning light will no t li ght up. You can sta rt the
e n gi ne immed iate ly
If yo u ha ve problems sta rtin g
3.2 "Tip s
and Advice", chapt er "J ump startin g."
Di ese l e ngin e pre-glow system
Wh ile pre- glow is acti ve , n o major elec trical
lo ad s s hou ld be switched on -oth erwise unnec
ess ary load is pla ce d on the vehicle battery.
You should start the engine immediate ly after
th e pr e-g low indica tor lig ht has gone out.
96 Driving
To start the diesel engine after the fuel tank has
been run dry
If the fuel tank was run comp lete ly dr y, the
s tartin g proc ess after refueling with die sel fuel
can take long er th an usual -up t o one minute.
Th is is be cause th e fu el sys tem fir st ha s to be
vented of a ir wh ile starting.
WARNING
H edu ce the risk of ser ious per sonal injur y
when startin g and running the vehicl e's en
g in e.
• Never start or le t the engine run in a con
fined or enclosed are a. Exha ust from the en
gi ne contain s carbon mono xide , a poisonous,
co lor less and odo rless gas. Carbo n monoxide
ca n cause unconsci ousness and death .
• Neve r leave the vehicle unatt ended with
the eng ine runnin g. The vehicle could mo ve
s udd enly or an unusual operating condition
co uld occur res ultin g in prop erty damage or
personal injury.
• Neve r use "sta rting ass is t fluid s." They arc
po tentia lly exp los ive and can ca use a " run
away" vehicl e co ndition .
Note
You can
the eng ine if you drive hi gh en
g ine speeds, at full th rottle or by overloading the
en gin e whe n it i s cold.
For the sake of environment
Do not warm up the engine by running it with
th e ve hicl cstandin gstill. Drive off as soo n as yo u
s tart the e ngin e. T hi s help s th e e ngin e
o p
e ra tin g temperature fa ster and r edu ces
emissions .
--4
