2008 TOYOTA YARIS SEDAN fuel pump

5
When trouble arises
289
5-1. Essential information
Fuel pump shut off system
Follow the procedure below to restart the engine after the system is
activated.Turn the engine switch to the ACC or LOCK position.
Restart the engine.
NOTICE
nBefore starting the engine
Inspect the ground under the vehicle.
If you find that fuel has leaked onto the ground, the fuel system has been
damaged and is in need of repair. Do not restart the engine.
To minimize the risk of fuel leakage when the engine stalls or an air-
bag inflates upon collision, the fu el pump shut off system stops sup-
plying fuel to the engine.

328 6-1. Specifications
Engine
Fuel
Model1NZ-FE
Type 4-cylinder in line, 4-cycle, gasoline
Bore and stroke 2.95 × 3.33 in. (75.0 × 84.7 mm)
Displacement 91.3 cu.in. (1497 cm3)
Drive belt tension 55 — 88 lbf (245 — 392 N, 25 — 40 kgf)
*
*: Drive belt tension measured with Boroughs drive belt ten- sion gauge No. BT-33-73F (used belt)
Fuel type Unleaded gasoline only
Octane rating 87 (Research octane number 91) or higher
Fuel tank capacity
(Reference) 11.1 gal. (42.0 L, 9.2 lmp.gal.)
Generator
Water pump Air
conditioning
compressor
Crankshaft

335
6-1. Specifications
6
Vehicle specifications
Fuel information
nFuel tank opening fo r unleaded gasoline
To help prevent incorrect fueling, your Toyota has a fuel tank opening that
only accommodates the special nozzle on unleaded fuel pumps.
n If your engine knocks
lConsult your Toyota dealer.
l You may occasionally notice light knocking for a short time while acceler-
ating or driving uphill. This is normal and there is no need for concern.
n Gasoline quality
In very few cases, driveability problems may be caused by the brand of gas-
oline you are using. If driveability problems persist, try changing the brand of
gasoline. If this does not correct the problem, consult your Toyota dealer.
n Gasoline quality standards
lAutomotive manufacturers in the US, Europe and Japan have developed
a specification for fuel quality called World-Wide Fuel Charter (WWFC)
that is expected to be applied worldwide.
l The WWFC consists of four categories that are based on required emis-
sion levels. In the US, category 4 has been adopted.
l The WWFC improves air quality by lowering emissions in vehicle fleets,
and customer satisfaction through better performance.
Your vehicle must use only unleaded gasoline.
Unleaded gasoline with an octane rating of 87 (Research Octane
Number 91) or higher.
At minimum, the gasoline you us e should meet the specifications
of ASTM D4814 in the U.S.A. and CGSB3.5-M93 in Canada.

363
Alphabetical index
If you lose your keys............. 316
If you think something is
wrong ................................. 288
If the vehicle becomes stuck................................... 323
If your vehicle needs to be towed ................................. 282
If your vehicle overheats ...... 320
Engine Compartment........................ 226
Engine switch ....................... 108
Hood ..................................... 223
How to start the engine ........ 108
Identification number ............ 327
If the engine will not start...... 313
Ignition switch ....................... 108
Immobilizer system................. 59
Overheating .......................... 320
Specifications ....................... 328
Warning light ........................ 293
Engine coolant Capacity ............................... 330
Checking .............................. 232
Indicator................................ 123
Preparing and checking before winter ...................... 141
Type ..................................... 330
Warning light ........................ 293
Engine immobilizer system ...... 59
Engine oil
Capacity ............................... 329
Checking .............................. 227
Grade ................................... 329
Initializing the maintenance data .................................... 230
Preparing and checking before winter ...................... 141
Warning light ................. 293,295
Engine switch .......................... 108
Engine oil maintenance data ........................................ 230 EPS
EPS .......................................135
Warning light .........................293
Event data recorder .................290
Floor mat...................................206
Fluid Automatic transmission .........331
Brake .....................................233
Clutch ....................................332
Warning light .................292, 295
Washer ..................................238
Fog lights
Indicator ................................129
Replacing light bulbs .............269
Switch....................................129
Wattage .................................334
Front fog lights Indicator ................................129
Replacing light bulbs .............269
Switch....................................129
Wattage .................................334
Front passenger's seat belt reminder light.........................295
Front seats
Adjustment ..............................35
Front side marker lights Replacing light bulbs .............269
Switch....................................127
Wattage .................................334
Front turn signal lights
Indicator ................................115
Lever .....................................115
Replacing light bulbs .............269
Switch....................................115
Wattage .................................334
Fuel
Capacity ................................328
Fuel pump shut off system ....289
Gas station information .........372
Gauge ...................................118
Information ............................335
Refueling .................................55
F

364 Alphabetical index
Type ...................................... 328
Warning light ......................... 295
Fuel door.....................................55
Fuel filler door ............................55
Fuel gauge ................................ 118
Fuel pump shut off system ..... 289
Fuses......................................... 257
Gas station information........... 372
Gauges ...................................... 118
Glove box.................................. 193
Head restraints Adjusting ................................39
Headlights
Indicator ................................ 127
Replacing light bulbs ............. 269
Switch.................................... 127
Wattage ................................. 334
High mounted stoplight Replacing light bulbs ............. 269
Wattage ................................. 334
Hood .......................................... 223
I/M test....................................... 218
Identification Engine ................................... 327
Tire ........................................ 338
Vehicle .................................. 327
Ignition switch .......................... 108
Illuminated entry system ......... 191
Immobilizer system....................59
Indicator lights ......................... 123
Initialization Items to initialize.................... 353
Inside rear view mirror ..............49
Interior light Switch.................................... 192
Wattage ................................. 334
Jack Positioning a floor jack .......... 224 Replacing the flat tire ............ 302
Jack handle .............................. 302
Keys
Electronic key.......................... 22
Engine switch ........................ 108
If you lose your keys ............. 316
Ignition switch ....................... 108
Key battery ............................ 255
Key number plate .................... 22
Keys ........................................ 22
Mechanical key ....................... 22
Wireless remote control .......... 24
License plate lights Replacing light bulbs ............. 269
Switch ................................... 127
Wattage................................. 334
Light bulbs Replacing .............................. 269
Wattage................................. 334
Lights Fog lights switch ................... 129
Headlights switch .................. 127
Instrument panel lightsswitch.................................. 127
Interior light switch ................ 192
License plate lights switch .... 127
Parking lights switch ............. 127
Personal lights switch ........... 192
Replacing light bulbs ............. 269
Side marker lights switch ...... 127
Tail lights switch .................... 127
Turn signal lights switch ........ 115
Load capacity ........................... 140
Lock steering column.............. 110
Maintenance Do-it-yourself maintenance ... 219
Emission inspection and maintenance (I/M)
programs ............................ 218
G
H
I
J
K
L
M

TABLE OF CONTENTSIndex
4
4-2. Maintenance ..................... 213Maintenance requirements .................... 213
General maintenance ......... 215
Emission inspection and maintenance (I/M)
programs .......................... 218
4-3. Do-it-yourself maintenance ................... 219
Do-it-yourself service precautions ...................... 219
Hood................................... 223
Positioning a floor jack ....... 224
Engine compartment .......... 226
Tires ................................... 240
Tire inflation pressure......... 246
Wheels ............................... 250
Air conditioning filter ........... 252
Key battery ......................... 255
Checking and replacing fuses ................................ 257
Light bulbs .......................... 269
5-1. Essential information....... 282 If your vehicle needs to be towed ............................... 282
If you think something is wrong ............................... 288
Fuel pump shut off system .............................. 289
Event data recorder............ 290 5-2. Steps to take in an
emergency ...................... 292
If a warning light turns on or a warning buzzer
sounds... ........................... 292
If you have a flat tire ........... 302
If the engine will not start .... 313
If the shift lever cannot be shifted from P ................... 315
If you lose your keys ........... 316
If the vehicle battery is discharged ........................ 317
If your vehicle overheats..... 320
If the vehicle becomes stuck ................................. 323
6-1. Specifications ................... 326 Maintenance data (fuel, oil level, etc.) ........... 326
Fuel information .................. 335
Tire information................... 338
6-2. Customization ................... 351 Customizable features ........ 351
Items to initialize ................. 353
Reporting safety defects for U.S. owners ...................... 356
Seat belt instructions for Canadian owners
(in French) ......................... 357
5When trouble arises
6Vehicle specifications
7For owners