2008 TOYOTA RAV4 service

’08 Rav4_U (L/O 0802)
404
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
Low level Full level
Add oil O.K. Too full
With the engine at operating tempera-
ture and turned off, check the oil level
on the dipstick. 1. To get a correct reading, the vehicle should be on level ground. After turning
off the engine, wait a few minutes for
the oil to drain back into the bottom of
the engine.
2. Pull the dipstick out, hold a rag under the end and wipe it clean.
3. Reinsert the dipstick—push it in as far as it will go, or the reading will not be
correct.
4. Pull the dipstick out and look at the oil level while holding a rag under the
end.
CAUTION
Be careful not to touch the hot ex-
haust manifold.
NOTICE
Be careful not to drop engine oil on
the vehicle components.
If the oil level is below or only slightly
above the low level, add engine oil of
the same type as already in the engine.
Remove the oil filler cap and add engine
oil in small quantities at a time, checking
the dipstick. We recommend that you use
a funnel when adding oil.
The approximate quantity of oil needed to
raise the level between low and full on the
dipstick is indicated as follows:2.4 L 4 −cylinder (2AZ −FE) engine
1.1L(1.2qt.,1.0lmp.qt.)
3.5 L V6 (2GR −FE) engine
1.5L(1.6qt.,1.3lmp.qt.)
For the engine oil capacity, see “Service
specifications” on page 429 in Section 8.
When the level reaches within the correct
range, install the filler cap hand− tight.
NOTICE
Be careful not to spill engine oil on
the vehicle components.
 Avoid overfilling, or the engine
could be damaged.
 Check the oil level on the dipstick
once again after adding the oil.
Checking the engine oil level

’08 Rav4_U (L/O 0802)
427
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
SPECIFICATIONS
Specifications
Dimensions and weights428
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Engine 429
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . .
Fuel 429
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . .
Service specifications 429
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . .
Tires 433
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . .
Fuses 434
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . .
SECTION 8

’08 Rav4_U (L/O 0802)
429
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
Model:2AZ− FE and 2GR −FE
Type: 2AZ− FE engine
4 cylinder in line, 4 cycle, gasoline
2GR −FE engine
6 cylinder V type, 4 cycle, gasoline
Bore and stroke, mm (in.): 2AZ− FE engine
88.5 96.0 (3.48 3.78)
2GR −FE engine
94.0 83.0 (3.70 3.27)
Displacement, cm
3 (cu. in.):
2AZ− FE engine 2362 (144.1)
2GR −FE engine 3456 (210.9)Fuel type:
Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher
Fuel tank capacity, L (gal., Imp. gal.): 60 (15.9, 13.2) ENGINE
Valve clearance (engine cold), mm (in.):
2.4 L 4 −cylinder (2AZ −FE) engine only
Intake 0.19—0.29 (0.007—0.011)
Exhaust 0.38—0.48 (0.015—0.019)
Spark plug type: 2.4 L 4 −cylinder (2AZ −FE) engine
DENSO SK20R11
NGK IFR6A11
3.5 L V6 (2GR −FE) engine
DENSO FK20HR11
Spark plug gap, mm (in.): 1.1 (0.043)
NOTICE
3.5 L V6 (2GRFE) engine—Use only
above spark plugs. Do not adjust
gaps for engine performance or
smooth driveab ility.
Engine FuelService specifications

’08 Rav4_U (L/O 0802)
445
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
Console boxRear 293 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls, Instrument panel 2,8 . . . . . . . . . . . .
Controls, overhead console 7 . . . . . . . . . . . . .
Controls, steering switches 7 . . . . . . . . . . . . . .
Cooling system
Coolant level 406 . . . . . . . . . . . . . . . . . . . . . .
Engine overheating 360 . . . . . . . . . . . . . . . . .
Radiator and reservoir 406 . . . . . . . . . . . . . .
Radiator cap 360 . . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 346 . . . . . . . . . . . . . . . . . .
Corrosion prevention 382 . . . . . . . . . . . . . . . . .
Cruise control 168 . . . . . . . . . . . . . . . . . . . . . . .
Cup holder
Front 294 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 294 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Outside rear view mirror 122 . . . . . . . . . . . .
Rear window 122
. . . . . . . . . . . . . . . . . . . . . . .
Dimmer switch, Headlight 114
. . . . . . . . . . . . .
Dinghy towing 347
. . . . . . . . . . . . . . . . . . . . . . .
Directional signals 114
. . . . . . . . . . . . . . . . . . .
Do −it−yourself maintenance
Parts and tools 400
. . . . . . . . . . . . . . . . . . . . .
Service precautions 399
. . . . . . . . . . . . . . . .
Does your vehicle need repairing? 393 . . . . .
Doors
Back door 26
. . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 22
. . . . . . . . . . . . . . . . . . . . . . . . .
Downhill assist control system 158
. . . . . . . . .
Driver ’s seat belt reminder buzzer 129 . . . . . .
Driver ’s seat belt reminder light 129 . . . . . . . . Driving
Automatic transmission 143,147
. . . . . . . . .
Driving tips 342
. . . . . . . . . . . . . . . . . . . . . . . .
Driving in the rain 344
. . . . . . . . . . . . . . . . . . . .
Driving tips
Driving in the rain 344
. . . . . . . . . . . . . . . . . .
Driving tips in various conditions 343 . . . . .
Driving with an automatic transmission 143,147
. . . . . . . . . . . . . . . . .
Economical driving 353
. . . . . . . . . . . . . . . . .
Good driving practice 143,147
. . . . . . . . . . .
Winter driving tips 346
. . . . . . . . . . . . . . . . . .
During
Break −in 309
. . . . . . . . . . . . . . . . . . . . . . . . . .
DVD player 194
. . . . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel and repairs 353 . . . . . . . . . . . . . . . . . .
Electric moon roof 30 . . . . . . . . . . . . . . . . . . . . .
Electric power steering system 320 . . . . . . . .
Electric power steering system warning light 129 . . . . . . . . . . . . . . . . . . . . . . .
Electrical system
Battery 418,420 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 398 . . . . . . . . . . . . . . . . . . . . .
Fuses 420 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 116 . . . . . . . . . . . . .
Emergency, In case of
Blown fuse 420 . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 116 . . . . . . . . . . .
Flat tire 361 . . . . . . . . . . . . . . . . . . . . . . . . . . . If you cannot increase
engine speed 359 . . . . . . . . . . . . . . . . . . . .
If you cannot shift automatic transmission selector lever 378 . . . . . . . .
If you lose your keys 379 . . . . . . . . . . . . . . . .
If your engine stalls while driving 359 . . . . .
If your vehicle becomes stuck 373 . . . . . . .
If your vehicle needs to be towed 373 . . . . .
If your vehicle will not start 356 . . . . . . . . . .
Jump starting 357 . . . . . . . . . . . . . . . . . . . . . .
Overheating 360 . . . . . . . . . . . . . . . . . . . . . . .
Towing 373 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and
Maintenance (I/M) programs 394 . . . . . . . . .
Engine
Before starting the engine 342 . . . . . . . . . . .
Checking the coolant level 406 . . . . . . . . . .
Emission control device 312 . . . . . . . . . . . . .
Engine compartment 396 . . . . . . . . . . . . . . .
Exhaust gas caution 313 . . . . . . . . . . . . . . . .
Hood release 27 . . . . . . . . . . . . . . . . . . . . . . .
Identification number 322 . . . . . . . . . . . . . . .
Oil consumption 314 . . . . . . . . . . . . . . . . . . . .
Oil level 404 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 360 . . . . . . . . . . . . . . . . . . . . . . .
Starting procedure 342 . . . . . . . . . . . . . . . . .
Three −way catalytic converters 312 . . . . . .
Engine coolant
Temperature gauge 126 . . . . . . . . . . . . . . . . .
Winter driving tips 346 . . . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 126 . . . . .
Engine immobilizer system 15 . . . . . . . . . . . . .
Engine oil
Winter driving tips 346 . . . . . . . . . . . . . . . . . .

’08 Rav4_U (L/O 0802)
447
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
J
JackLocation 362 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jack, Audio
AUX 191 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 357 . . . . . . . . . . . . . . . . . . . . . . . .
K
Key reminder buzzer 129
. . . . . . . . . . . . . . . . .
Keys 12,379
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs 422
. . . . . . . . . . . . . . . . . . . . . . . . . .
Light bulbs
Back −up light 425
. . . . . . . . . . . . . . . . . . . . . .
Front fog light 425
. . . . . . . . . . . . . . . . . . . . . .
Front side marker light 425
. . . . . . . . . . . . . .
Front turn signal light 425
. . . . . . . . . . . . . . .
Headlight 424
. . . . . . . . . . . . . . . . . . . . . . . . . .
License plate light 426
. . . . . . . . . . . . . . . . . .
Parking light 425
. . . . . . . . . . . . . . . . . . . . . . .
Rear side marker light 425
. . . . . . . . . . . . . .
Rear turn signal light 425
. . . . . . . . . . . . . . .
Light, Interior
Interior light 117
. . . . . . . . . . . . . . . . . . . . . . .
Personal light 118
. . . . . . . . . . . . . . . . . . . . . .
Light, Luggage compartment 118
. . . . . . . . . .
Load capacity 335
. . . . . . . . . . . . . . . . . . . . . . . . Lock
Back door 26
. . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 22
. . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 142
. . . . . . . . . . . . . . . . . . .
Low engine oil pressure warning light 129
. . . . . . . . . . . . . . . . . . . . . . .
Low fuel level warning light 129
. . . . . . . . . . . .
Low windshield washer fluid level
warning light 129
. . . . . . . . . . . . . . . . . . . . . . .
Luggage compartment light 118
. . . . . . . . . . . .
Luggage cover 296
. . . . . . . . . . . . . . . . . . . . . . .
Luggage storage box 292
. . . . . . . . . . . . . . . . .
M
Maintenance
Do −it−yourself maintenance 399 . . . . . . . . .
Does your vehicle need repairing? 393 . . . . . . . . . . . . . . . . . . . . . . .
General maintenance 391 . . . . . . . . . . . . . . .
Maintenance requirements 390 . . . . . . . . . .
Parts and tools 400 . . . . . . . . . . . . . . . . . . . . .
Where to go for service 390 . . . . . . . . . . . . .
Malfunction indicator lamp 394 . . . . . . . . . . . .
Malfunction indicator lamp
Emissions Inspection and Maintenance (I/M) programs 129 . . . . . . .
Service reminder indicator 129 . . . . . . . . . .
Manual air conditioning system 270 . . . . . . . .
Maximum allowable speed
Automatic transmission 143,147 . . . . . . . . .
Mirror
Anti −glare inside rear view 110 . . . . . . . . . . Mirrors
Folding rear view 110 . . . . . . . . . . . . . . . . . . .
Outside rear view 108 . . . . . . . . . . . . . . . . . .
Power rear view 109 . . . . . . . . . . . . . . . . . . . .
Vanity 111 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moon roof 30 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
N
New vehicle break −in 309 . . . . . . . . . . . . . . . . .
O
Odometer 127
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Off −road driving precautions 345
. . . . . . . . . .
Oil
Consumption 314
. . . . . . . . . . . . . . . . . . . . . .
Viscosity and grade 404
. . . . . . . . . . . . . . . .
Oil consumption 314
. . . . . . . . . . . . . . . . . . . . .
Open door warning light 129
. . . . . . . . . . . . . . .
Operation in foreign countries 311
. . . . . . . . .
Outside temperature display 128
. . . . . . . . . . .
Overhead console overview 7
. . . . . . . . . . . . .
Overheating, Engine 360
. . . . . . . . . . . . . . . . . .
Overheating, Engine coolant 126
. . . . . . . . . .
Overview
Engine compartment 396
. . . . . . . . . . . . . . .

’08 Rav4_U (L/O 0802)
448
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
P
Parking brakeOperation 167 . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 167 . . . . . . . . . . . . . . . . . . . . .
Polishing 383 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Positioning a floor jack 401 . . . . . . . . . . . . . . . .
Power outlet 288,289 . . . . . . . . . . . . . . . . . . . . .
Power rear view mirror control 109 . . . . . . . . .
Power steering 320 . . . . . . . . . . . . . . . . . . . . . . .
Power window switches 24 . . . . . . . . . . . . . . . .
Preloaders (seat belt pretensioners) 62 . . . . .
Pretensioners
(seat belt pretensioners) 62 . . . . . . . . . . . . .
Protecting your Toyota from
corrosion 382 . . . . . . . . . . . . . . . . . . . . . . . . . .
R
Radiator
Checking the radiator 407 . . . . . . . . . . . . . . .
Coolant, Engine 406 . . . . . . . . . . . . . . . . . . . .
Radio 172 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear audio/video system 194 . . . . . . . . . . . . . .
Rear seat entertainment system 194 . . . . .
Rear cargo net 300 . . . . . . . . . . . . . . . . . . . . . . .
Rear console box 293 . . . . . . . . . . . . . . . . . . . .
Rear cup holder 294 . . . . . . . . . . . . . . . . . . . . . .
Rear seat
Third seat entry 43 . . . . . . . . . . . . . . . . . . . . .
Rear seat precautions 41 . . . . . . . . . . . . . . . . .
Rear step bumper 321 . . . . . . . . . . . . . . . . . . . .
Rear view mirror
Anti −glare inside 110 . . . . . . . . . . . . . . . . . . . Rear view mirrors
Folding 110 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside 108 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power 109 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear window and outside rear view mirror defogger switch 122 . . . . . . . . .
Rear window wiper and washer switch 121 . . . . . . . . . . . . . . . . . . . . .
Rear/second seat 41 . . . . . . . . . . . . . . . . . . . . .
Remote controls 191 . . . . . . . . . . . . . . . . . . . . .
Reporting safety defects for U.S. owners 440 . . . . . . . . . . . . . . . . . . . . . . .
Roof luggage carrier 303 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 35 . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 60 . . . . . . . . . . . . . . . . . . . . .
Seat belts
Cleaning 386 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastening 53 . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt precautions 53 . . . . . . . . . . . . . . . .
Seat belt pretensioners 62 . . . . . . . . . . . . . .
Seat heater switch 52 . . . . . . . . . . . . . . . . . . . .
Seating capacity 335 . . . . . . . . . . . . . . . . . . . . .
Seats 34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Second seat 43 . . . . . . . . . . . . . . . . . . . . . . . . . .
Service and maintenance 390 . . . . . . . . . . . . .
Service reminder indicator 129 . . . . . . . . . . . .
Side door locks 22 . . . . . . . . . . . . . . . . . . . . . . .
Side doors 22 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Side vents 283 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare fuse 420 . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare tire 362 . . . . . . . . . . . . . . . . . . . . . . . . . . . Spark plugs
Iridium −tipped spark plugs 315 . . . . . . . . . .
Specifications 428 . . . . . . . . . . . . . . . . . . . . . . .
SRS driver airbag and front passenger airbag 64 . . . . . . . . . . . . . . .
SRS side airbags and curtain shield airbags 71 . . . . . . . . . . . . . . . .
SRS warning light 129 . . . . . . . . . . . . . . . . . . . .
Starting
Cold weather 342 . . . . . . . . . . . . . . . . . . . . . .
Engine 342 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 357 . . . . . . . . . . . . . . . . . . . . . .
Steering
Adjusting steering wheel 108 . . . . . . . . . . . .
Electric power steering system 320 . . . . . .
Steering switches overview 7 . . . . . . . . . . . . .
Sun visors 111 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension and chassis 323 . . . . . . . . . . . . . .
Switch
Emergency flasher 116 . . . . . . . . . . . . . . . . .
Engine 142 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Headlight, dimmer and turn signal 114 . . . .
Ignition 142 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside rear view mirror defogger 122 . . . .
Rear window defogger 122 . . . . . . . . . . . . . .
Rear window wiper and washer 121 . . . . . .
Windshield wiper and washer 120 . . . . . . . .
T
Tachometer 127
. . . . . . . . . . . . . . . . . . . . . . . . .
Telescopic steering column 108
. . . . . . . . . . . .
Theft prevention labels 323
. . . . . . . . . . . . . . .
Three −way catalytic converters 312 . . . . . . . .
Tie −down hooks 295
. . . . . . . . . . . . . . . . . . . . .

’08 Rav4_U (L/O 0802)
i
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
Foreword
Welcome to the growing group of value−conscious people who drive Toyotas. We are proud of the advanced engineering and
quality construction of each vehicle we build.
This Owner ’s Manual explains the operation of your new Toyota. Please read it thoroughly and have all the occupants
follow the instructions carefully. Doing so will help you enjoy many years of safe and troublefree motoring. For
important information about this manual and your Toyota, read the following pages carefully.
When it comes to service, remember that your Toyota dealer knows your vehicle very well and is interested in your complete
satisfaction. Your Toyota dealer will provide quality maintenance and any other assistance you may require.
If there is not a Toyota dealer near you, please call the following number:
U.S. OWNERS:
When traveling in the U.S. mainland or Canada: Toyota Customer Experience Center Tollfree:18003314331
Hawaii:
Servco Automotive Customer Services Tollfree:18882725515
CANADIAN OWNERS:
When traveling in Canada or the U.S. mainland: Toyota Canada Customer Interaction Centre Tollfree:1888TOYOTA8 or 18888696828
Please leave this Owner ’s Manual in this vehicle at the time of resale. The next owner will need this information also.
All information and specifications in this manual are current at the time of printing. However, because of Toyota’s policy of
continual product improvement, we reserve the right to make changes at any time without notice.
Please note that this manual applies to all models and explains all equipment, including options. Therefore, you may
find some explanations for equipment not installed on your vehicle.
Please access our websites for further information.
The U.S. mainland www.toyota.com
Hawaiiwww.toyotahawaii.com
Canadawww.toyota.ca
©2008 TOYOTA MOTOR CORPORATION
All rights reserved. This material may not be reproduced or copied, in whole or in part, without the written permission of Toyo ta
Motor Corporation.

’08 Rav4_U (L/O 0802)
ix
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
Scrapping of your Toyota
The SRS airbag and seat belt pretensioner devices in your
Toyota contain explosive chemicals. If the vehicle is
scrapped with the airbags and pretensioners left as they
are, this may cause an accident such as fire. Be sure to
have the systems of the SRS airbag and seat belt preten-
sioner removed and disposed of by the qualified service
shop or by your Toyota dealer before you dispose of your
vehicle.
Leak detection pump
This pump performs fuel evaporation leakage check. This
check is done approximately five hours after the engine is
turned off. So you may hear sound coming from under the
floor around the driver ’s seat for several minutes. It does
not indicate a malfunction.
Onpavement and offroaddriving tips
This vehicle belongs to the utility vehicle class. Utility
vehicles have a significantly higher rollover rate than other
types of vehicles. This vehicle will handle and maneuver
differently from an ordinary passenger car because it is
designed for off −road use also. In addition, this vehicle
has a higher ground clearance and center of gravity than
that of an ordinary passenger car. This vehicle design
feature causes this type of vehicle to be more likely to
rollover. Failure to operate this vehicle correctly may result
in loss of control, accidents or vehicle rollover causing
death or serious injury. Be sure to read “Utility vehicle
precautions” on page 308 in Section 2 and “Off −road
driving precautions” on page 345 in Section 3.