Downloaded from www.Manualslib.com manuals search engine EMISSION CONTROL SYSTEM *4-1 . Crankcase ventiiation -system .. *4'-2.-Fuel evaporatlve-em'issiOn control system -
BRAKE *5'-1. Brake discs and pads (front, rear) - . Brakedrunls and shoes -(if equippedf -*i)-2:Brake hoses arid pipes . --. -5:3. Brake-flu-iCl ---------------
i):4:-l3-rake lever and cable CHASSIS AND BODY '-S:1:Clutch ---~----
6-2. Tires *6:3. ",ii,rheels-*6-4. Drive shafts/Propeller shafts 'i3Tsuspensionsysiem --~6-if Steering-system ---.
*6-7. Manual transmission oil
*6-S. -Transfer- oil --. *6-9. Differentiai oil -6~ 6.~ Automatic transmission' -~
Check, -*Replacement
Check, -Adjustment -
(I:
1stJ"§.OQ9=k...m:~njYf
(R: 1st 15000 km-only)
'Fluid-Ievel -------
*
Fluidc::hange' * Fll.Jid hOse . ,----
km (x1000) 15
miles (x1000)l 9
months I 12
-(Class 1] ---~--I--[Class 1] ..
INSPECTION AND MAINTENANCE
--I
30 18
24
. -_" . ----. -
I I
1-
I 45 60 75 I 90 I 27 36 I 45 I 54
36 48 I 60 I 72
~I---~ --l-':--I: '-~ --1--T . ,--~--------~ I - - -
I
------------.-----------'If------------1'1'----. -------,-R-'(1sffS066 km only) ------. -, 1--1--.---------._---
-------~..:----------~ ---T
.--, -Ft'or I
'-"T --1---
i
._-
.-. ---T
I -1-
I--T I - I
I
I
T I -----I -1---r
I '---R---
-----------_________ ~4_._
--, -Replace every 165000 km (99000 miles). -.. ----- . --.---------------. --'I' -,--.-. .. .. , .. -.. '--' "-1 -f 6-1 i. 'AII'hitches, hinges and locks . *6-f2~Power steerTng (if equipped) --_., _._._-"- ----,--------.---~---'--"----------.-----,--.--------.. --T ----.. -· .. -------1----'-"1
*6-13. Air conditioner filter element (if equipped) R I R
A WARNING
The shock absorbers are filled with high pressure gas. Never attempt to disassemble it or throw it into a fire. Avoid storing. it
near a heater or heating device'. When scrapping the absorber, the gas must be released from the absorber safely. Ask your dealer for assistance.
7-4
Downloaded from www.Manualslib.com manuals search engine A WARNING
Brake fluid is harmful or fatal if swallowed, and harmful if it comes in contact with skin or eyes. If swallowed,
do not induce vomiting. Immediately contact a poison control center or a
physician. If brake fluid gets in eyes
flush eyes with water and seek medi~ cal a~ention. ~ash thoroughly after
handling. Solution can be poisonous to animals. Keep out of the reach of
children and animals.
NOTE: With disc brakes, the fluid level can be
expected to gradually fall as the brake
pads wear.
Brake Pedal Check. if the ~rake pedal·stops at the regular height without "spongy" feeling when you depress it. If not, have the brake system inspected by your SUZUKI dealer. If you doubt the brake pedal for the regular
height, check it as follows:
. .
54G108
Pedal to wall minimum distance "a": 70 mm (2.8 in.)
With the engine running, measure the distance between the brake pedal and floor
wall when the pedal is depressed with
approximate~y. 300 ~ (30 kg, 66 Ibs) of force: .The ~Inlmum distance required is as spec!fled. SIn?e vour vehicle's brake system IS self-adJusting, there is no need for
pedal adjustment.
If the pedal to floor wall distance as measured above is less than the minimum dis~ance required, have your vehicle Inspected by your SUZUKI dealer.
NOTE: When measuring the distance between the i?rake pedal and floor wall, be sure not to mclude the floor mat or rubber on the floor
wall in your measurement.
INSPECTION AND MAINTENANCE
60G104S
A WARNING
If you experience any of the following
problems with your vehicle's brake
system, have the vehicle inspected
immediately
by your SUZUKI dealer. • Poor braking performance • Uneven braking (Brakes not work-
ing uniformly on all wheels.) • Excessive pedal travel • Brake dragging • Excessive noise • Pedal pulsation (Pedal pulsates
when depressed.) .
7-24
