2008 Seat Toledo wheel bolt torque

Wheels and tyres
236Wheel bolts
Wheel bolts must be tightened to the correct torque.The design of wheel bolts is matched to the rims. If different wheel rims are
fitted, the correct wheel bolts with the right length and correctly shaped bolt
heads must be used. This ensures that wheels are fitted securely and that the
brake system functions correctly.
In certain circumstances, you may not use wheel bolts from a different car -
even if it is the same model ⇒page 208.
After the wheels have been changed, the tightening torque of the wheel bolts
should be checked as soon as possible with a torque wrench ⇒. The tight-
ening torque for steel and alloy wheels is 120 Nm.
WARNING
If the wheel bolts are not tightened correctly, the wheel could become
loose while driving. Risk of accident.•
The wheel bolts must be clean and turn easily. Never apply grease or oil
to them.
•
Use only wheel bolts which belong to the wheel.
•
If the torque of the wheel bolts is to o low, they could loosen whilst the
vehicle is in motion. Risk of accident! If the tightening torque is too high,
the wheel bolts and threads can be damaged.Caution
The prescribed torque for wheel bolts for steel and alloy wheels is 120 Nm.
Winter tyres
Winter tyres will improve the vehicles handling on snow and
ice.In winter conditions winter tyres will considerably improve the vehicles
handling. The design of summer tyres (width, rubber compound, tread
pattern) gives less grip on ice and snow.
Winter tyres must be inflated to a pressure 0.2 bar higher than the pressures
specified for summer tyres (see sticker on tank flap).
Winter tyres must be fitted on all four wheels.
Information on permitted winter tyre sizes can be found in the vehicle's regis-
tration documents. Use only radial winter tyres. All tyre sizes listed in the
vehicle documentation also apply to winter tyres.
Winter tyres lose their effectiveness when the tread is worn down to a depth
of 4 mm.
The speed rating code ⇒page 235, “New tyres and wheels” determines the
following speed limits for winter tyres: ⇒
Q max. 160 km/h
S max. 180 km/h
T max. 190 km/h
H max. 210 km/h
In some countries, vehicles which can exceed the speed rating of the fitted
tyre must have an appropriate sticker in the driver's field of view. These
stickers are available from your Authorised Service Centre. The legal require-
ments of each country must be followed.
Do not have winter tyres fitted for unnecessarily long periods. Vehicles with
summer tyres handle better when the roads are free of snow and ice.
If you have a flat tyre, please refer to the notes on the spare wheel
⇒ page 235, “New tyres and wheels”.
Toledo_EN.book Seite 236 Dienstag, 20. Januar 2009 12:58 12

If and when
238If and whenTools, tyre repair kit and spare wheelVehicle To ols
The vehicle onboard tools are located under the floor panel in
the luggage compartment.– Lift the cover of the luggage compartment, by pulling it up with a
finger in the fitting.
– Take the onboard tools out of the vehicle.The tool kit includes:•
Jack*
•
Hook for removing wheel covers* or hub caps*
•
Box spanner for wheel bolts*
•
Reversible screwdriver with handle (including hexagonal interior) for the
wheel bolts. The screwdriver is a combination tool.
•
To wi ng e ye
•
Adapter for the anti-theft wheel bolts*
Some of the items listed are only prov ided in certain models / model years,
or are optional extras.
WARNING
•
Do not use the hexagonal socket in the screwdriver handle to tighten
the wheel bolts as with this it is not possible to tighten the bolts to the
required torque. Risk of accident.
•
The jack* supplied by the factory is only designed for changing wheels
on this model. On no account attempt to use it for lifting heavier vehicles
or other loads. Risk of injury.
•
Use the jack* only on firm, level ground.
•
Never start the engine when the vehicle is on the jack. Risk of accident.
•
I f wo r k is t o b e ca r r i e d o u t un d e r n ea th the vehicle, this must be secured
by suitable stands. Otherwise, there is a risk of injury.WARNING (continued)
Toledo_EN.book Seite 238 Dienstag, 20. Januar 2009 12:58 12

If and when241
Safety First
Operating instructions
Practical tips
Te c h n i c a l D a t a
After changing a wheel
After changing the wheel there are still tasks to complete.– Put the tools and jack back in the luggage compartment.
– Place the wheel with the defective tyre in the luggage compart-
ment and secure it.
– Check the tyre pressure of the newly fitted tyre as soon as
possible.
– Have the tightening torque of the wheel bolts checked as soon as possible with a torque wrench. The prescribed torque must be
120 Nm.
Note•
If you notice that the wheel bolts are corroded and difficult to turn when
changing a wheel, they must be replaced before having the wheel bolt torque
checked.
•
For your safety, drive at moderate speeds until the wheel bolt torque has
been checked.
Wheel trims
The wheel trims must be removed to gain access to the wheel
bolts.Removing
–Insert the extraction hook from the tools into the designated ring, located in one of the bolt hole covers of the wheel cover
⇒fig. 168.
–Pull off the hub cap .
Fig. 168 Changing the
wheel: Removing a hub
cap
Toledo_EN.book Seite 241 Dienstag, 20. Januar 2009 12:58 12

General notes on the technical data
272To w i n g a t r a i l e rTrailer weightsTrailer weights
The trailer weights and drawbar loads approved are selected in intensive
trials according to precisely defined criteria. The approved trailer weights are
valid for vehicles in the EU for maximum speeds of 80 km/h (in certain
circumstances up to 100 km/h). The figu res may be different in other coun-
tries. All data in the official vehicl e documents take precedence over these
data ⇒ .
Drawbar load
The maximum permitted weight exerted by the trailer drawbar on the ball joint
of the towing bracket must not exceed 75 kg.
In the interest of road safety, we recommend that you always tow
approaching the maximum drawbar load. The response of the trailer on the
road will be poor if the drawbar load is too small.
If the maximum permissible drawbar loa d cannot be met (e.g. with small,
empty and light-weight single axle trailers or tandem axle trailers with an axle
base of less than 1 metre), at least 4% of the actual trailer weight is a legal
stipulation for a drawbar load.
WARNING
•
For safety reasons, do not exceed the 80 km/h limit. This is also valid in
countries where higher speeds are permitted.
•
Never exceed the maximum trailer weights or the draw bar loading. If
the permissible axle load or the permissible total weight is exceeded, the
driving characteristics of the vehicle may change, leading to accidents,
injuries and damage to the vehicle.
WheelsTyre pressure, snow chains, wheel boltsTyre pressures
The sticker with the tyre pressure values can be found on the inside of the
tank flap. The tyre pressure values given there are for cold tyres. The slightly
raised pressures of warm tyres must not be reduced ⇒.
Snow chains
Snow chains may be fitted only to the front wheels.
Consult the chapter “wheels” of this manual.
Wheel bolts
After the wheels have been changed, the tightening torque of the wheel bolts
should be checked as soon as possible with a torque wrench ⇒. The tight-
ening torque for steel and alloy wheels is 120 Nm.
WARNING
•
Check the tyre pressure at least once per month. Checking tyre pressure
value is very important. If the tyre pressure is too high or too low, there is
an increased danger of accidents, particularly at high speeds.
•
If the torque of the wheel bolts is too low, they could loosen while the
vehicle is in motion. Risk of accident! If the tightening torque is too high,
the wheel bolts and threads can be damaged.Note
We recommend that you ask your Authorised Service Centre for information
about appropriate wheel, tyre and snow chain size.
Toledo_EN.book Seite 272 Dienstag, 20. Januar 2009 12:58 12

Index
286Towing bracket, fitting . . . . . . . . . . . . . . . . . . . 197
Towing eye . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 265
Tow-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 265
Traction control system
warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 82
Trailer Trailer towing . . . . . . . . . . . . . . . . . . . . . . . . 195
Trailer eyes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 266
Trailer turn signals Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 116
Trailer weights . . . . . . . . . . . . . . . . . . . . . . . . . . 272
Trips, checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116 Warning lamp . . . . . . . . . . . . . . . . . . . . 76, 116
Turning light . . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Type plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Tyre Mobility-System (Tyre repair kit) . . . 239, 246
Tyre monitor indicator . . . . . . . . . . . . . . . . . . . . . 78
Tyre pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . 230 Loss . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 232
Tyre pressure monitoring . . . . . . . . . . . . . . . . . 231
Tyre pressures . . . . . . . . . . . . . . . . . . . . . . . . . . 272
Tyre repair kit . . . . . . . . . . . . . . . . . . . . . . . 239, 246
Tyres and wheels Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . 235
Tyres service life . . . . . . . . . . . . . . . . . . . . . . . . 232
Tyres tread depth . . . . . . . . . . . . . . . . . . . . . . . 233
Tyres with directional tread pattern . . . . . . . . . 230
UUnderbody maintenance . . . . . . . . . . . . . . . . . 205
Unlocking and locking Personalisation . . . . . . . . . . . . . . . . . . . . . . . 94
Using the Tiptronic gear syst em . . . . . . . . . . . 173VVehicle battery . . . . . . . . . . . . . . . . . . . . . . . . . 227
Vehicle data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Vehicle identification data . . . . . . . . . . . . . . . . 270
Vehicle identification number . . . . . . . . . . . . . 270
Vehicle Maintenance
Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 200
Vehicle modifications . . . . . . . . . . . . . . . . . . . . 208
Vehicle paintwork Products for vehicle maintenance . . . . . . . 199
Waxing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 201
Vehicle tools Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
Vehicle wallet storage . . . . . . . . . . . . . . . . . . . 135
Vehicle washing . . . . . . . . . . . . . . . . . . . . . . . . 200
Ventilation slits . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Volumetric sensor* Activation . . . . . . . . . . . . . . . . . . . . . . . . . . . 100
Deactivation . . . . . . . . . . . . . . . . . . . . . . . . 100WWarning lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 30 Warning lamps . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Warning reports
Red . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Yellow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Warning texts in the display . . . . . . . . . . . . . . . . 62
Warning triangle . . . . . . . . . . . . . . . . . . . . . . . . 147
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . 222
Washing by hand . . . . . . . . . . . . . . . . . . . . . . . 200
Washing with high pressure cleaners . . . . . . . 201
Water warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Water in the windscreen washer tank . . . . . . . 222
Wear indicators . . . . . . . . . . . . . . . . . . . . . . . . . 233
Wheel bolts . . . . . . . . . . . . . . . . . . . . . . . . 242, 272 Torque . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 236
Wheel change . . . . . . . . . . . . . . . . . . . . . . . . . . 240
Wheel trims . . . . . . . . . . . . . . . . . . . . . . . . . . . . 241
Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230, 272
Why assume the correct sitting position? . . . . . 29
Why should head restraints be correctly adjusted? 13
Why to wear seat belts? . . . . . . . . . . . . . . . . . . . 19
Why wear seat belts? . . . . . . . . . . . . . . . . . . 20, 29
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104
Windscreen washer fluid Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 78
Windscreen wiper blades Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . 203
Toledo_EN.book Seite 286 Dienstag, 20. Januar 2009 12:58 12