2008 SATURN ASTRA spare tire

9. Place the compact spare tire on
the wheel-mounting surface.
10. Reinstall the wheel bolts with
the rounded end of the bolts
toward the wheel. Tighten each
bolt by hand until the wheel
is held against the hub.
11. Lower the vehicle by turning the
jack handle counterclockwise.
Lower the jack completely.12. Tighten the wheel bolts rmly
in a crisscross sequence,
as shown.
{CAUTION
Incorrect or improperly
tightened wheel bolts can
cause the wheel to come loose
and even come off. This could
lead to a crash. If you have to
(Continued)
CAUTION (Continued)
replace them, be sure to get
new original equipment wheel
bolts. Stop somewhere as
soon as you can and have the
bolts tightened with a torque
wrench to the proper torque
specication. SeeCapacities
and Specifications on
page 10-2for wheel bolt
torque specication.
Notice:Improperly tightened
wheel bolts can lead to brake
pulsation and rotor damage.
To avoid expensive brake repairs,
evenly tighten the wheel bolts
in the proper sequence and to
the proper torque specication.
SeeCapacities and Specifications
on page 10-2for the wheel bolt
torque specication.
Vehicle Service and Care 9-65
ProCarManuals.com

Storing a Flat or Spare
Tire and Tools
{CAUTION
Storing a jack, a tire, or other
equipment in the passenger
compartment of the vehicle
could cause injury. In a
sudden stop or collision,
loose equipment could strike
someone. Store all these in
the proper place.To store a at or spare tire and
tools, do the following:
A. Jack
B. Wheel Wrench
C. Jack Handle
1. Replace the jack and tools
as shown.2. Place the at tire face down into
the spare tire hub.
3. Turn spare tire hold-down bolt by
turning clockwise. Return the
foam pad to its original position.
9-66 Vehicle Service and Care
ProCarManuals.com

4. Put the load oor back in place.
The compact spare tire is for
temporary use only. Replace the
compact spare with a full-size tire
as soon as possible.
Compact Spare Tire
Although the compact spare tire
was fully inated when the vehicle
was new, it can lose air after
a time. Check the ination
pressure regularly. It should be
60 psi (420 kPa).
After installing the compact spare
on the vehicle, stop as soon
as possible and make sure the
spare tire is correctly inated.
The compact spare is made to
perform well at speeds up to
50 mph (80 km/h) for distances
up to 3,000 miles (5 000 km), so you
can nish your trip and have the
full-size tire repaired or replaced at
your convenience. Of course, it
is best to replace the spare with a
full-size tire as soon as possible.
The spare tire will last longer and
be in good shape in case it is
needed again.Notice:When the compact
spare is installed, do not take
your vehicle through an
automatic car wash with guide
rails. The compact spare can get
caught on the rails. That can
damage the tire and wheel, and
maybe other parts of your vehicle.
Do not use the compact spare on
other vehicles.
And do not mix the compact spare
tire or wheel with other wheels
or tires. They will not t. Keep the
spare tire and its wheel together.
Notice:Tire chains will not
t your compact spare. Using
them can damage your vehicle
and can damage the chains
too. Do not use tire chains on
your compact spare.
Vehicle Service and Care 9-67
ProCarManuals.com

Who is Covered?
Roadside Assistance coverage is for
the vehicle operator, regardless of
ownership. In Canada, a person
driving this vehicle without the
consent of the owner is not eligible
for coverage.
Services Provided
The following services are provided
in the U.S. and Canada up to
5 years/100,000 miles (160 000 km),
whichever comes rst, and, in
Canada only, up to a maximum
of $100.
Fuel Delivery:Delivery of enough
fuel for the vehicle to get to
the nearest service station
(approximately $5 Canada).
In Canada, service to provide
diesel may be restricted. For
safety reasons, propane and
other alternative fuels are not
provided through this service.
Lock-Out Service:Lock-out
service is covered at no charge if
you are unable to gain entry into
your vehicle. A remote unlock
may be available if you have an
active OnStar
®subscription.
To ensure security, the driver
must present personal
identication before lock-out
service is provided. In Canada,
the vehicle registration is also
required.
Emergency Tow From a Public
Roadway or Highway:Tow to
the nearest Saturn retailer for
warranty service or in the event
of a vehicle-disabling crash.
Winch-out assistance is provided
when the vehicle is mired in sand,
mud, or snow.
Flat Tire Change:Installation of a
spare tire in good condition, when
equipped and properly inated,
is covered at no charge.The customer is responsible for
the repair or replacement of the
tire if not covered by a
warrantable failure.
Jump Start:A battery jump start
is covered at no charge if the
vehicle does not start.
Trip Routing Service (Canada
Only):Upon request, Roadside
Assistance will send you detailed,
computer personalized maps,
highlighting your choice of either
the most direct route or the most
scenic route to your destination,
anywhere in North America, along
with helpful travel information
pertaining to your trip.
Please allow three weeks before
your planned departure date.
Trip routing requests are limited
to six per calendar year.
11-6 Customer Information
ProCarManuals.com

C
California Fuel.....................8-35
California Perchlorate
Materials Requirements....... 9-3
California Proposition 65
Warning............................ 9-3
Canadian Owners..................... ii
Capacities and
Specications...................10-2
Carbon Monoxide.........8-14, 8-27
Care, Safety Belts................1-22
Cargo Cover......................... 3-1
Cargo Tie Downs................... 3-1
Cautions and Notices............... iii
Chains, Tire........................9-59
Charging System Light..........4-17
Check
Engine Light....................4-20
Chemical Paint Spotting........9-79
Child Restraints
Child Restraint Systems.....1-41
Infants and Young
Children.......................1-38
Lower Anchors and
Tethers for Children.......1-45Child Restraints (cont.)
Older Children..................1-37
Securing..................1-50, 1-53
Where to Put the
Restraint......................1-43
Cleaning
Exterior...........................9-75
Interior............................9-72
Underbody Maintenance....9-79
Climate Control System.......... 7-1
Outlet Adjustment............... 7-4
Clutch, Hydraulic..................9-12
Collision Damage Repair.....11-10
Compact Spare Tire.............9-67
Content Theft-Deterrent.......... 2-9
Control of a Vehicle..............8-17
Coolant
Engine............................9-12
Engine Temperature
Warning Light...............4-19
Cooling System...................
9-16
Cruise Control....................... 4-5
Cruise Control Light..............4-24
Cupholders........................... 3-1Customer Assistance
Information
Courtesy
Transportation.......11-4, 11-8
Customer Assistance
Offices.........................11-5
Customer Satisfaction
Procedure....................11-1
GM Mobility
Reimbursement
Program.......................11-5
Reporting Safety
Defects to
Saturn........................11-14
Reporting Safety
Defects to the
Canadian
Government................11-14
Reporting Safety Defects
to the United States
Government................11-13
Roadside Assistance
Program.......................11-5
Service Publications
Ordering Information.....11-14
i-2 INDEX
ProCarManuals.com

Power (cont.)
Steering Fluid...................9-20
Windows.........................2-10
Pressure Cap......................9-15
Privacy.............................11-15
Event Data Recorders.....11-16
Navigation System..........11-17
OnStar ..........................11-17
Radio Frequency
Identication................11-17
R
Radio Frequency
Identication (RFID),
Privacy..........................11-17
Radio(s)............................... 6-2
Radios
Reception........................6-25
Theft-Deterrent.................6-24
Reading Lamps..................... 5-3
Rear Compartment Lamp........ 5-4
Rear Door Security Locks....... 2-6Rear Heated Seats................ 1-6
Rear Seat Operation.............. 1-7
Rear Windshield Washer/
Wiper..............................4-10
Rearview Mirrors..................2-12
Reclining Seatbacks............... 1-3
Recreational Vehicle
Towing ............................9-72
Remote Keyless Entry
(RKE) System.................... 2-3
Remote Keyless Entry
(RKE) System,
Operation.......................... 2-4
Removing the Flat Tire
and Installing the
Spare Tire.......................9-62
Removing the Spare Tire
and Tools........................9-61
Replacement Bulbs..............9-33
Replacing LATCH
System Parts After
a Crash...........................1-50Reporting Safety Defects
Canadian Government.....11-14
Saturn...........................11-14
United States
Government................11-13
Restraint System Check
Replacing Airbag System
Parts After a Crash........1-36
Replacing Safety Belt
System Parts After
a Crash.......................1-23
Retained Accessory
Power (RAP) ..................... 8-3
Roadside
Assistance Program..........11-5
Rocking Your Vehicle
to Get it Out ....................8-30
Running the Vehicle
While Parked...................8-14
INDEX i-7
ProCarManuals.com

S
Safety Belts.......................... 1-8
Care of ...........................1-22
Check.............................1-22
How to Wear Safety
Belts Properly...............1-12
Lap-Shoulder Belt.............1-17
Reminder Light.................4-14
Replacing Parts After
a Crash.......................1-23
Safety Belt Extender.........1-22
Safety Belt Use During
Pregnancy....................1-21
Seats
Head Restraints................. 1-5
Heated Seats - Rear........... 1-6
Height Adjuster.................. 1-2
Lumbar Adjustment............. 1-3
Rear Seat Operation........... 1-7
Reclining Seatbacks............ 1-3
Securing Child
Restraints................1-50, 1-53Service................................ 9-2
Accessories and
Modications.................. 9-3
Adding Equipment to the
Outside of the Vehicle..... 9-4
California Perchlorate
Materials Requirements.... 9-3
California Proposition 65
Warning......................... 9-3
Doing Your Own Work........ 9-4
Engine Soon Light............4-20
Owner Checks................... 9-5
Publications Ordering
Information.................11-14
Vehicle Soon Light............4-24
Service, Scheduling
Appointments...................12-8
Servicing Your
Airbag-Equipped Vehicle....1-34
Sheet Metal Damage............9-78
Shifting Into Park.................8-11
Shifting Out of Park..............8-13
Signals, Turn and
Lane-Change..................... 4-8Spare Tire
Compact.........................9-67
Installing..........................9-62
Removing
........................9-61
Storing............................9-66
Specications, Capacities......10-2
Speedometer.......................4-13
StabiliTrak
®Indicator Light.....4-19
Stabilitrak®System...............8-19
Starting the Engine................ 8-3
Steering..............................8-20
Steering Wheel Controls,
Audio..............................6-24
Steering Wheel, Tilt Wheel...... 4-4
Storage Areas
Cupholders........................ 3-1
Glove Box......................... 3-1
Stuck in Sand, Mud, Ice,
or Snow..........................8-29
Sun Visors..........................2-11
Sunroof..............................2-13
i-8 INDEX
ProCarManuals.com

T
Tachometer.........................4-13
Taillamps....................9-29, 9-30
Theft-Deterrent, Radio...........6-24
Theft-Deterrent Systems......... 2-7
Content Theft-Deterrent....... 2-9
Immobilizer........................ 2-7
Immobilizer Operation......... 2-8
Tilt Wheel............................. 4-4
Tire
Pressure Light..................4-19
Tires..................................9-38
Buying New Tires.............9-54
Chains............................9-59
Changing a Flat Tire.........9-60
Compact Spare Tire..........9-67
Different Size...................9-55
High-Speed Operation.......9-47
If a Tire Goes Flat............9-60
Ination - Tire Pressure.....9-46Tires (cont.)
Inspection and Rotation.....9-51
Installing the Spare Tire.....9-62
Pressure Monitor
Operation.....................9-50
Pressure Monitor
System........................9-48
Removing the Flat Tire......9-62
Removing the Spare
Tire and Tools...............9-61
Storing a Flat or Spare
Tire and Tools...............9-66
Tire Sidewall Labeling.......9-40
Tire Terminology and
Denitions....................9-43
Uniform Tire Quality
Grading.......................9-56
Wheel Alignment and
Tire Balance.................9-58
Wheel Replacement..........9-58Tires (cont.)
When It Is Time for
New Tires....................9-53
Winter Tires.....................
9-39
Towing
Recreational Vehicle..........9-72
Towing a Trailer................9-72
Your Vehicle.....................9-72
Traction
Stabilitrak
®System...........8-19
Transmission
Fluid, Automatic................9-12
Fluid, Manual...................9-12
Transmission Operation,
Automatic.......................... 8-5
Transmission Operation,
Manual............................. 8-9
Trip Odometers....................4-13
Turn and Lane-Change
Signals............................. 4-8
Turn Signal/Multifunction
Lever................................ 4-4
INDEX i-9
ProCarManuals.com