2008 PEUGEOT 107 fuel

5
FAMILIARISATION
When this block fl ashes,
accompanied by an audible
signal, you have enough
fuel left to drive approxi-
mately 30 miles (50 km).
1. Internal control.

2. External control.

3. Bonnet strut.

 64

 51
Low fuel level
Remove the key and unscrew the
cap.
After fi lling the fuel tank, screw the
cap back on fully to the right until it
clicks and close the fl ap.
Fuel tank capacity: approximately
35 litres.
After opening the fl ap, insert the key,
turn it slightly to the left then return to
the right. The key returns to its initial
position and the cap is unlocked. OPEN
Fuel tank Bonnet

14
FAMILIARISATION
When the ignition is on, the orange
and red warning lights come on.
When the engine is running, these
warning lights should switch off.
If warning lights remain on, refer to
the page concerned.

 18

A. Rev counter

B. Display

C. Fuel gauge

 17 The dynamic stability control system
(ASR/ESP) optimises the vehicle’s
road holding.
For correct operation of the system,
refer to the page concerned.

 56
MONITOR THOROUGHLY
Instrument panel Warning lights ASR/ESP option

1
17
INSTRUMENTS and CONTROLS
INSTRUMENT PANEL

1. Total/trip distance recorder zero
reset button

2. Warning lights and indicators
display

3. Direction indicators

4. Speedometer

5. Fuel gauge
6. Total/trip distance recorder

7. Rear fog lamp indicator light

8. Main beam headlamps indicator
light

9. Dipped headlamps indicator light
REV COUNTER
When approaching the maximum
engine speed, when the rev counter
needle crosses into the red zone, you
must engage the next gear up.

10. "2 Tronic" gearbox gear and gear
lever positions indicator

1
21
INSTRUMENTS and CONTROLS
Operating mode:

1st gear

2nd gear

3rd gear

4th gear

5th gear
If this warning light comes
on, with the engine running,
this indicates a malfunction
of the "2 Tronic" gearbox. Fuel gauge
This indicates the quantity of fuel
available:
-
1/1 and six blocks, the fuel tank
is full.
- R and one block fl ashing, the
fuel tank is on the reserve.
Low fuel level
When the minimum level in the fuel
tank is reached, the last block fl ashes
accompanied by an audible signal.
In certain driving conditions and depending
on the engine, the distance which can be
travelled with the fuel remaining may be
less than 30 miles (50 km).

You have approximately 5 litres remaining. When the frequency of the fl ashing increases,

you have approximately 3 litres remaining .
At least 5 litres must be added
after running out of fuel. Running out of diesel fuel
After running out of fuel, you
can travel a short distance
after 10 pump repriming ope-
rations (see corresponding
section).
After fi lling the fuel tank (mi-
nimum 5 litres), operate the repriming
pump at least 10 times (see corres-
ponding section).

"!" warning light
Consult a PEUGEOT dealer.

4
51
ACCESS
FILLING THE FUEL TANK

 Open the fuel fi ller fl ap.

 Insert the key, turn it slightly to
the left then return to the right.
The key returns to its initial posi-
tion and the cap is unlocked.
Low fuel level
When the fuel tank minimum
level is reached, the last
block fl ashes, accompanied
by an audible signal.

You have approximately
5 litres remaining.
In certain driving conditions and de-
pending on the engine, the distance
which can be travelled with the fuel
remaining may be less than 30 miles
(50 km).
When the frequency of the fl ashing
increases, you have approximately
3 litres remaining .
 Unscrew the cap and hook it onto
the clip located on the inside of
the fl ap.
A label affi xed on the inside of the
fl ap reminds you which type of fuel
to use.
When you fi ll the fuel tank, do not
continue after the 3rd cut-off of the
pump. This could cause malfunc-
tions.

 Remove the key.

Note: if you run out of fuel,
the emission control system
warning light may come on
on the instrument panel. It will
switch off automatically after the en-
gine has been started a few times.
The fuel tank must be fi lled

with the engine switched
off .
The capacity of the fuel tank is ap-
proximately 35 litres.

 After fi lling the fuel tank, screw
the cap back on fully to the right
until it clicks and close the fl ap.

8
68
CHECKS
CHECKS Oil filter
Change the fi lter regularly, in
accordance with the servicing
schedule. Only use products recom-
mended by PEUGEOT or
products of equivalent qual-
ity and characteristics.
In order to optimise the operation
of units as important as the braking
circuit, PEUGEOT selects and offers
specifi c products.
In order to avoid damaging the
electrical units, high pressure washing
to clean the engine compartment is
strictly prohibited.
To check the main levels and certain
components, in accordance with the
manufacturer’s servicing schedule,
refer to the pages of the servicing
booklet which correspond to your
vehicle’s engine.
Battery
At the start of winter, have your
battery checked by a PEUGEOT
dealer.
Air filter and passenger
compartment filter
Have the fi lter elements replaced reg-
ularly.
If you drive in dusty condi-
tions, change them twice as often.
Brake pads
Brake pad wear depends on the style
of driving, in particular for vehicles
which are used in town, over short
distances.
Disc and drum wear status
For any information relating to disc
and drum surface wear, contact a
PEUGEOT dealer. Manual gearbox
Have the level checked in accordance
with the manufacturer’s servicing
schedule.
RUNNING OUT OF FUEL
(DIESEL)
It may be necessary to check
the thickness of the pads,
even between services.
If the engine stops, it is
possible to restart it to drive
a short distance by operating
the pump at least 10 times.
If you run out of fuel, the circuit must
be reprimed:
- fi ll the fuel tank with at least fi ve litres of diesel,
-
squeeze and release the manual
repriming pump at least 10 times.
This is located under the protective
cover which must fi rst be unclipped
and then removed,
- operate the starter until the engine starts.

Notes: if the engine does
not start after approximately
15 seconds of attempts,
operate the repriming pump
again approximately fi fteen
times before trying again.
If the emission control warning light
has come on, it will only switch off
after your vehicle has been used
several times.
Handbrake
Where the handbrake travel is too
great or there is a reduction in the
performance of the system, the
handbrake should be adjusted, even
between services.
Have the system checked by a
PEUGEOT dealer.

10
83
TECHNICAL DATA
PETROL ENGINES AND GEARBOXES

Model codes PM, PN CFAC CFAC/P

Engines
1.0 litre (≈ 68 bhp)

Cubic capacity (cm 3
) 998

Bore x stroke (mm)
71 x 84

EU standard maximum power (kW) 50

Max power engine speed (rpm) 6 000

EU standard max torque (Nm) 93

Max torque engine speed (rpm) 3 600
Fuel Unleaded

Catalytic converter Yes

Gearbox Manual (5-speed) "2 Tronic" (5-speed)

Oil capacity (in litres)

Engine (with cartridge replacement) 3.2
Gearbox-Final drive 2

10
85
TECHNICAL DATA
DIESEL ENGINES AND GEARBOXES

Model codes PM, PN
8HTC

Engines
1.4 litre Turbo HDI (≈ 54 bhp)
Cubic capacity (cm 3
) 1 398
Bore x stroke (mm) 73.7 x 82
EU standard maximum power (kW) 40
Max power engine speed (rpm) 4 000
EU standard max torque (Nm) 130
Max torque engine speed (rpm) 1 750
Fuel Diesel
Catalytic converter Yes
Particle emission fi lter No

Gearbox
Manual (5-speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3.8
Gearbox-Final drive 1.9
4.1 4.6
4.1 4.6
4.1 4.6