2008 MERCEDES-BENZ ML320 ABS

429 Practical hints
What to do if …
Display symbolDisplay messagePossible cause/consequencePossible solution
;(USA only)
!(Canada only)
Release
Parking BrakeYou are driving with the parking
brake set.Release the parking brake (page 57).
;(USA only)
3(Canada only)
EBV, ABS, ESP Inoperative
See Operator’s ManualThe EBP, the ABS, and the ESP®
have switched off due to a mal-
function. The BAS is also
switched off.
The brake system is still func-
tional but without the EBP, the
ABS, and the ESP
® available.
Continue driving with added caution.
Wheels may lock during hard braking,
reducing steering capability.
Have the system checked at an
authorized Mercedes-Benz Light Truck
Center as soon as possible.
Failure to follow these instructions increases
the risk of an accident.

452 Practical hints
Where will I find ...?
Setting up the collapsible wheel chock
The collapsible wheel chock serves to ad-
ditionally secure the vehicle, e.g. while
changing the wheel.
1Tilt the plate upward
2Fold the lower plate outward
3Insert the plateTilt both plates upward1.
Fold the lower plate outward2.
Guide the tabs of the lower plate all the
way into the openings of base plate3.
For information on where to place wheel
chocks when changing a wheel, see “Lift-
ing the vehicle” (
page 479).
Minispare wheel (except ML 63 AMG)
Warning!G
The dimensions of the Minispare wheel are
different from those of the road wheels. As
a result, the vehicle handling characteristics
change when driving with a Minispare wheel
mounted. Adapt your driving style accord-
ingly.
The Minispare wheel is for temporary use
only. When driving with a Minispare wheel
mounted, ensure proper tire inflation
pressure and do not exceed a vehicle speed
of 50 mph (80 km/h).
Drive to the nearest Mercedes-Benz Light
Truck Center as soon as possible to have the
Minispare wheel replaced with a regular
road wheel.
Never operate the vehicle with more than
one spare wheel mounted.
Do not switch off the ESP
® when a
Minispare wheel is mounted.

475 Practical hints
Replacing wiper blades
Replacing wiper blades
Front wiper blades
Removing
Remove the SmartKey from the starter
switch.
Vehicles with KEYLESS-GO*:
Make sure the vehicle’s on-board
electronics have status0
(
page 42).
Fold the wiper arms forward until they
engage.
1Wiper blade
2Cover
3Attachment
4Tab
5Removing
Press tabs4 together and tilt wiper
blade1 to detach tabs4 on both
recesses of attachment3.
Wiper blade1 is released on one end.
Maintaining its tilted position, slide
wiper blade1 out of attachment3 in
direction of arrow5.
Warning!G
For safety reasons, switch off wipers and
remove SmartKey from starter switch
(vehicles with KEYLESS-GO*: Make sure the
vehicle’s on-board electronics have
status
0) before replacing a wiper blade.
Otherwise the motor could suddenly turn on
and cause injury.
Warning!G
Wiper blades are components that are sub-
ject to wear and tear. Replace the wiper
blades twice a year, preferably in the spring
and fall. Otherwise the windows will not be
properly wiped. As a result, you may not be
able to observe surrounding traffic condi-
tions and could cause an accident.
!Never open the hood when the wiper arms
are folded forward.
Hold on to the wiper when folding the wiper arm
back. If released, the force of the impact from
the tensioning spring could crack the windshield.
Do not allow the wiper arms to contact the wind-
shield glass without a wiper blade inserted.
Make sure the wiper blades are properly
installed. Improperly installed wiper blades may
cause windshield damage.
For your convenience, we recommend that you
have this work carried out by an authorized
Mercedes-Benz Light Truck Center.
!Do not pull on the wiper blade inserts. They
could tear.

515 Technical data
Rims and tires
Rims and tires
!Only use tires which have been tested and
approved by Mercedes-Benz. Tires approved by
Mercedes-Benz are developed to provide best
possible performance in conjunction with the
driving safety systems on your vehicle such as
ABS or ESP
®. Tires specially developed for your
vehicle and tested and approved by
Mercedes-Benz can be identified by finding the
following on the tire’s sidewall:

MO = Mercedes-Benz Original equipment
tires
AMG vehicles:
Does not apply to all approved tires on AMG
vehicles. For information on tested and
approved tires for AMG vehicles, contact an
authorized Mercedes-Benz Light Truck
Center.
Using tires other than those approved by
Mercedes-Benz may result in damage that is not
covered by the Mercedes-Benz Limited
Warranty.
!Using tires other than those approved by
Mercedes-Benz can have detrimental effects,
such as

poor handling characteristics

increased noise

increased fuel consumption
Moreover, tires and rims not approved by
Mercedes-Benz may, under load, exhibit dimen-
sional variations and different tire deformation
characteristics that could cause them to come
into contact with the vehicle body or axle parts.
Damage to the tires or the vehicle may be the
result.
iFurther information on tires and rims is
available at any authorized Mercedes-Benz Light
Truck Center. A placard with the recommended
tire inflation pressure is located on the driver’s
door B-pillar (
page 510). Some vehicles may
have supplemental tire inflation pressure infor-
mation for driving at high speeds (
page 358)
or for vehicle loads less than the maximum
loaded vehicle condition (
page 358). If such
information is provided, it can be found on the
placard located on the inside of the fuel filler
flap.The tire inflation pressure should be checked
regularly and should only be adjusted on cold
tires. Follow tire manufacturer’s maintenance
recommendation included with vehicle.
iThe following pages also list the approved
wheel rim and tire sizes for equipping your
vehicles with winter tires. Winter tires are not
available as standard or optional factory equip-
ment, but can be purchased from an authorized
Mercedes-Benz Light Truck Center.
Depending on vehicle model and the standard or
optional factory-equipped wheel rim/tire
configuration on your vehicle (Appearance
Package, Sport Package etc.), equipping your
vehicle with winter tires approved for your
vehicle model may also require the purchase of
two or four wheel rims of the recommended size
for use with these winter tires. See an authorized
Mercedes-Benz Light Truck Center for more
information.

525 Technical data
Fuels, coolants, lubricants
Engine oils
Engine oils are specifically tested for their
suitability in our engines and durability for
our service intervals. Therefore, only use
approved engine oils and oil filters
required for vehicles with Maintenance
System. For a listing of approved engine
oils and oil filters, refer to the Factory
Approved Service Products pamphlet
(USA only), or contact an authorized
Mercedes-Benz Light Truck Center.Engine oil additives
Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil are used in the air condition-
ing system.
Brake fluid
Only brake fluid approved by
Mercedes-Benz is recommended. Any
authorized Mercedes-Benz Light Truck
Center will provide you with additional
information.
!Using engine oils and oil filters of
specification other than those expressly
required for the Maintenance System, or chang-
ing of oil and oil filter at change intervals longer
than those called for by the Maintenance System
will result in engine or emission control system
damage not covered by the Mercedes-Benz
Limited Warranty.
Please follow Maintenance System recommen-
dations for scheduled oil changes. Failure to do
so will result in engine or emission control
system damage not covered by the
Mercedes-Benz Limited Warranty.
!Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from blending
oil additives are not covered by the
Mercedes-Benz Limited Warranty.
!Never use R-12 (CFC) or mineral-based
lubricating oil. Otherwise damage to the system
will occur.
Warning!G
During vehicle operation, the boiling point of
the brake fluid is continuously reduced
through the absorption of moisture from the
atmosphere. Under extremely strenuous
operating conditions, this moisture content
can lead to the formation of bubbles in the
system, thus reducing the system’s
efficiency.
Therefore, the brake fluid must be replaced
regularly. Refer to your vehicle’s
Maintenance Booklet for replacement inter-
val.

531 Index
A
ABS 98
Indicator lamp 400
Messages in the multifunction
display 415
Off-road - ABS 99
Accelerator position, automatic
transmission 190
Accessory weight 379
Accident 64
Active head restraint 88, 127, 458
Adaptive Damping System (ADS)* 255
Air bags 74
Children 75, 89
Front passenger front air bag off
indicator lamp 31, 83
Front, Driver 77
Front, Passenger 77
Occupant Classification System
(OCS) 79
Safety guidelines 76
Side impact (front and rear*) 78
Window curtain 78Air conditioning refrigerant 525
Air conditioning system see
Climate control or
Automatic climate control (3-zone)*
Air conditioning, Cooling 214, 229
Air distribution, Front 209, 224
Air distribution, Rear 217, 233
Air pressure see Tire inflation pressure
Air pump, electric (ML 63 AMG) 485
Air recirculation mode 212, 227
Air suspension program* 254
Adaptive Damping System
(ADS)* 255
Messages in the multifunction
display 447
Vehicle level control* 255
Air vents 217
Air vents, Front 210, 224
Air vents, Rear 234
Air volume 210, 225
Alarm system see Anti-theft systems
Alignment bolt (vehicle tool kit) 450, 483Anticorrosion/antifreeze 529
Antiglare, Interior rear view mirror 199
Antiglare, Rear view mirrors* 199
Antilock Brake System see ABS
Anti-theft systems 107
Anti-theft alarm system 106, 107
Immobilizer 106
Aquaplaning see Hydroplaning
Armrest storage/telephone* compart-
ment
Front 281
Ashtrays (Depending on vehicle
configuration) 285
Aspect ratio 379
ATF 345
Attaching a trailer 330
AUDIO menu 160
Audio menu
CD operation 161
Radio operation 160
Satellite radio* operation 160
Auto-dimming*, Rear view mirrors 199
Automatic central locking, Control
system 175

536 Index
Driving 51, 311
Abroad 334
Hydroplaning 316
In winter 318, 384
Instructions 51, 311
Problems 63
Safety systems 98
Systems 244
Through standing water 319
Through water 324
Driving off 58
Driving safety systems
4-ETS 104
ABS 98
BAS 100
EBP 104
ESP
®100
Driving systems 244
Adaptive Damping System
(ADS)* 255
Air suspension program* 254
Cruise control 244
Downhill Speed Regulation
(DSR) 249
Off-road driving program 253
Parktronic system* 259Rear view camera* 264
Vehicle level control* 255
Driving tips 190
Accelerator position 190
Kickdown 190
E
Easy-entry/exit feature
Activating (driver’s seat)* 176
Easy-entry/exit feature* 46
EBP 104
Indicator and warning lamps 402,
429
Electrical connections
Trailer 329
Electrical fuses see Fuses
Electrical system, Technical data 519
Electronic Brake Proportioning see EBP
Electronic Stability Program see ESP
®
Electronic Traction System see 4-ETS
Emergency calls
Tele Aid 296
Emergency operation
Fuel filler flap 457
Locking/unlocking the vehicle 455,
456Emergency operation
(Limp-Home Mode) 197
Emergency operations
Remote door unlock, Tele Aid 301
Unlocking/opening the tailgate 456
Emergency Tensioning Device see ETD
Emergency, In case of
Battery, Jump starting 497
Engine shut-down 506
First aid kit 448
Flat tire 478
Fuses 504
Hazard warning flasher 141
Instrument cluster, Indicator
lamps 400, 401, 402, 403, 404,
405, 406, 407, 408, 410
Roadside Assistance 12, 298
Towing the vehicle 499
Emission control 335
Information label 511
System warranties 10

542 Index
Lamps, indicator and warning
ABS 27, 400
Adaptive Damping System
(ADS)* 255
Alarm system 107
Battery (SmartKey with
KEYLESS-GO*) 117
Battery (SmartKey) 112
Brakes 27, 401, 402
Center console 31, 411
CHECK ENGINE 29, 403, 404
Downhill Speed Regulation 250
Engine diagnostics 29, 403, 404
ESP
®27, 405
Fog lamps, Front/rear 135
Front passenger front air bag off 31,
78
Fuel reserve 29, 410
High beam headlamps 29
Instrument cluster 26, 28, 400, 401,
402, 403, 404, 405, 406, 407, 408,
410
Off-road driving program 253
Parktronic* 262Preglow indicator, Diesel engine 29
Seat belt telltale 29, 87, 406
Seat belts 407
Seat heating* 130
Seat ventilation* 131
SRS 29, 72, 87, 410
Turn signals 27
Vehicle level control* 257
Language, Setting 167
LATCH-type child seat anchors see
Children in the vehicle
Layout of poly-V-belt drive
(ML 320 CDI) 512
Layout of poly-V-belt drive
(ML 350, ML 550) 512
Layout of poly-V-belt drive
(ML 63 AMG) 512
Leather upholstery*, Cleaning and care
of 398
Lever for cruise control 244
License plate lamps 473
Messages in the multifunction
display 440
Replacing bulbs 464, 473
Light alloy wheels, Cleaning 396Light sensor
Messages in the multifunction
display 438
Lighter see Cigarette lighter (Depending
on vehicle configuration)
Lighting, Exterior and interior 135
Limp-Home Mode 197, 403, 404
Loading see Vehicle loading
Locator lighting 138, 171
Lock buttons, KEYLESS-GO*
Outside door handle 69
Locking the vehicle see Key
Loss of keys, Mechanical key 118
Loss of keys, SmartKey 118
Loss of keys, SmartKey with
KEYLESS-GO* 118
Loss of Service and Warranty Information
Booklet 509
Low beam headlamps
Messages in the multifunction
display 440
Replacing bulbs 464
Switching on 59, 135
Lubricants 522
Lumbar support 129