2008 MERCEDES-BENZ G500 oil additives

Contents
Technical data.................................. 407
Parts service ...................................... 408
Warranty coverage ............................. 409 Loss of Service and Warranty
Information Booklet...................... 409
Identification labels............................ 410
Layout of poly-V-belt drive ................. 412
G 500 ........................................... 412
G 55 AMG..................................... 412
Engine ................................................ 413
Rims and tires .................................... 414 Same size tires ............................. 415
Spare wheel ................................. 416
Electrical system.......... ...................... 417
Main dimensions, vehicle weights
and ratings ......................................... 418 Main dimensions .......................... 418
Vehicle weights and ratings ......... 419 Fuels, coolants, lubricants, etc. ......... 420
Capacities .................................... 420
Engine oils.................................... 423
Engine oil additives ...................... 423
Air conditioning refr igerant .......... 423
Brake fluid .................................... 423
Premium unleaded gasoline ......... 424
Fuel requirements ........................ 424
Gasoline additives ........................ 425
Coolants....................................... 425
Windshield/rear window washer
system and headlamp
cleaning system ........................... 428Index ................................................. 429
W463.boo Seite 8 Montag, 19. November 2007 8:41 08

269
Operation
Engine compartment
ClosingLower hood and let it drop into lock
from a height of approximately 0.7 ft
(20 cm).
The hood will lock audibly.
Check to make sure the hood is fully
closed.
If you can raise the hood at a point
above the turn signals to the left and
right of the hood, then it is not properly
closed. Open it again and let it drop
with somewhat greater force.
Engine oil
The amount of oil your engine needs will
depend on a number of factors, including
driving style. Higher
oil consumption can
occur when

the vehicle is new

the vehicle is driven frequently at
higher engine speeds
Engine oil consumption checks should only
be made after the vehicle break-in period.
Warning!G
When closing the hood, use extreme caution
not to catch hands or fi ngers. Be careful that
you do not close the hood on anyone.
Make sure that the hood is securely
engaged before driving off. Do not continue
driving if the hood can no longer engage
after an accident, for example. The hood
could otherwise come loose while the
vehicle is in motion and endanger you and
others.
!Do not push the hood closed manually, as
this could damage it. !Do not use any special lubricant additives,
as these may damage the drive assemblies.
Using special additives not approved by
Mercedes-Benz may cause damage not covered
by the Mercedes-Benz Limited Warranty.
More information on this subject is available at
any Mercedes-Benz Light Truck Center.
W463.boo Seite 269 Montag, 19 . November 2007 8:41 08

423
Technical data
Fuels, coolants, lubricants, etc.
Engine oils
Engine oils are specifically tested for their
suitability in our engines and durability for
our service intervals. Therefore, only use
approved engine oils and oil filters
required for vehicles with Maintenance
System (U.S. vehicles) or FSS (Canada
vehicles). For a listing of approved engine
oils and oil filters, refer to the Factory
Approved Service Pr
oducts pamphlet
(USA only), or contact an authorized
Mercedes-Benz Light Truck Center.
Engine oil additives
Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil are used in the air condition-
ing system.
Brake fluid
Only brake fluid approved by
Mercedes-Benz is recommended. Any
authorized Mercedes-Benz Light Truck
Center will provide you with additional
information.
!Using engine oils and oil filters of specifi-
cation other than those expressly required for
the Maintenance System (U.S. vehicles) or FSS
(Canada vehicles), or changing of oil and oil filter
at change intervals longer than those called for
by the Maintenance System (U.S. vehicles) or
FSS (Canada vehicles) will result in engine
damage not covered by the Mercedes-Benz
Limited Warranty. Please follow Maintenance System
(U.S. vehicles) or FSS (Canada vehicles)
recommendations for scheduled oil changes.
Failure to do so will result in engine damage not
covered by the Mercedes-Benz Limited
Warranty.
!Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from blending
oil additives are not covered by the
Mercedes-Benz Limited Warranty.
!Never use R-12 (CFC) or mineral-based
lubricating oil. Otherwise damage to the system
will occur.
Warning!G
During vehicle operation, the boiling point of
the brake fluid is continuously reduced
through the absorption of moisture from the
atmosphere. Under extremely strenuous
operating conditions, this moisture content
can lead to the formation of bubbles in the
system, thus reducing the system’s
efficiency.
Therefore, the brake fluid must be replaced
regularly. Refer to your vehicle’s
Maintenance Booklet for replacement
interval.
W463.boo Seite 423 Montag, 19 . November 2007 8:41 08

425
Technical data
Fuels, coolants, lubricants, etc.
Gasoline additives
A major concern among engine
manufacturers is ca
rbon build-up caused
by gasoline. Mercedes-Benz recommends
only the use of quality gasoline containing
additives that prevent the build-up of car-
bon deposits.
After an extended period of using fuels
without such additives, carbon deposits
can build up, especially on the intake
valves and in the combustion area, leading
to engine performance problems such as:

Warm-up hesitation

Unstable idle

Knocking/pinging

Misfire

Power loss In areas where carbon deposits may be
encountered due to lack of availability of
gasolines which contain these additives,
Mercedes-Benz recommends the use of
additives approved by us for use on
Mercedes-Benz vehicles. Refer to the
Factory Approved Service Products
pamphlet (USA only) or
contact an autho-
rized Mercedes-Benz Light Truck Center
for a listing of approved product(s). Follow
directions on product label.
Do not blend other fuel additives with fuel.
This only results in unnecessary cost and
may be harmful to the engine operation.
Coolants
The engine coolant is a mixture of water
and anticorrosion/antifreeze, which
provides:

Corrosion protection

Freeze protection

Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -35°F (-37°C) and corro-
sion protection.
If the antifreeze mixture is effective to
-35°F (-37°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approxim ately 266°F (130°C).
!Damage or malfunction resulting from poor
fuel quality or from blending additional fuel
additives other than those tested and approved
by us for use on Mercedes-Benz vehicles are not
covered by the Mercedes-Benz Limited
Warranty.! Add premixed coolant solution only. Adding
water and MB 325.0 Anticorrosion/Antifreeze
separately from each other, could cause engine
damage not covered by the Mercedes-Benz
Limited Warranty.
W463.boo Seite 425 Montag, 19 . November 2007 8:41 08

435
Index
Driving on sand 259
Driving systems 197
Cruise control 197
Driving safety systems 87
Rear Parking Assist 200
Rear view camera 203
Rear view camera* 203
Driving through water 257
E
Easy-entry/exit feature Activating 156
EBB 87, 91
Electrical fuses 403
Electrical outlet 223 In cargo compartment 224
In front passenger footwell 223
In rear passenger footwell 224
Electrical system Technical data 417
Electronic Brake Booster (EBB) 91
Electronic Stability Program see ESP
®
Electronic systems Message in display 363
Electronic Traction System (ETS) 90
Emergency calls Tele Aid 230 Emergency, In case of
Roadside Assistance 232
Emergency operation Remote door unlock, Tele Aid 235
Emergency operation (Limp Home Mode) 169
Emergency operations Closing tilt/sliding sunroof 372
Locking the vehicle 369
Opening tilt/sliding sunroof 372
Unlocking the tailgate 369
Unlocking the vehicle 368
Emergency Tensioning Device see ETD
Emission control 263
Emission control information label 411
Ending A call (telephone) 160
Engine Compartment 267
Starting with SmartKey 54
Technical data 413
Turning off with SmartKey 64
Engine cleaning 316
Engine compartment 267 Hood 267 Engine malfunction indicator lamp 27,
328–329
Engine oil 269, 423 Adding 273
Additives 423
Checking level 269
Consumption 269
Messages in display 271, 349–350
Oil dipstick 272
Engine oil level see Oil level
ESP
®27, 87, 91
Messages in display 339
Switching off 93
Switching on 94
Warning lamp 330–331
ETD 68, 77 Safety guidelines 72
Expanding cargo compartment 206
Extending gear range 168
Exterior lamp switch 117
Exterior lamps Delayed shut-off 153
Exterior rear view mirrors Adjusting 46
Exterior view 22
W463.boo Seite 435 Montag, 19 . November 2007 8:41 08

448 Index
Switching onAutomatic central locking (control system) 155
Differential locks 175
ESP
®94
Front axle differential lock 176
Headlamps 56
Heated steering wheel 225
Rear axle differential lock 176
Transfer case differential lock 175
Windshield wipers 58
Symbol messages Multifunction display 342–363
T
Tachometer 27, 132 Overspeed range 132
Tail lamps 383 Cleaning 318
Messages in display 355
Replacing bulbs 376
Tailgate Closing 106
Message in display 362
Opening 105
Unlocking in an emergency 369
Tar stains 315 Technical data
Air conditioning refrigerant 423
Brake fluid 423
Coolant 420
Coolants 425
Electrical system 417
Engine 413
Engine oil 423
Engine oil additives 423
Fuel requirements 424
Fuels 420
Gasoline additives 425
Lubricants 420
Main dimensions 418
Premium unleaded gasoline 424
Rims and tires 414
Weights and ratings 419
Windshield and headlamp washer system 422, 428
Tele Aid 229 Initiating an emergency call manually 231
Message in display 362 Tele Aid*
Call priority 235
Emergency calls 230
Information 233
Remote door unlock 235
Roadside Assistance 232
SOS button 231
Stolen Vehicle Recovery services 236
System self-check 230
Telephone Answering a call 160
Dialing a number from the phone book 160
Ending a call 160
Loading phone book 160
Operating 159
Redialing 161
Telephone cradle Changing 228
W463.boo Seite 448 Montag, 19 . November 2007 8:41 08