2008 MERCEDES-BENZ CLS500 octane

13 Introduction
Operator’s Manual
Operating your vehicle outside the USA
or Canada
If you plan to operate your vehicle in for-
eign countries, please be aware that:

service facilities or replacement parts
may not be readily available,

unleaded gasoline for vehicles with cat-
alytic converters may not be available;
the use of leaded fuels will damage the
catalysts,

gasoline may have a considerably low-
er octane rating, and improper fuel can
cause engine damage.Certain Mercedes-Benz models are avail-
able for delivery in Europe under our Euro-
pean Delivery Program. For details, consult
an authorized Mercedes-Benz Center or
write to:
In the USA:
Mercedes-Benz USA, LLC
European Delivery Department
One Mercedes Drive
Montvale, NJ 07645-0350
In Canada:
Mercedes-Benz Canada, Inc.
European Delivery Department
98 Vanderhoof Avenue
Toronto, Ontario M4G 4C9

284 Operation
At the gas station
Open fuel filler flap1 by pushing at
the point indicated by the arrow.
The fuel filler flap springs open.
Turn fuel cap2 counterclockwise and
hold on to it until possible pressure is
released.
Take off fuel cap2 and place it into
holder3 located on the inside of the
fuel filler flap.
To prevent fuel vapors from escaping
into open air, fully insert filler nozzle
unit.
Only fill your tank until the filler nozzle
unit cuts out – do not top off or over-
fill.
Replace fuel cap by turning it clockwise
until it audibly engages.
Close the fuel filler flap.
Warning!G
Overfilling of the fuel tank may create pres-
sure in the system which could cause a gas-
oline fuel discharge. This could cause the
gasoline fuel to spray back out when remov-
ing the fuel pump nozzle, which could cause
personal injury.
iMake sure to close the fuel filler flap before
locking your vehicle as the flap locking pin pre-
vents closing after you have locked the vehicle.
iLeaving the engine running and the fuel cap
open can cause the yellow fuel tank reserve
warning lamp to flash and the malfunction indi-
cator lampú(USA only) or the malfunction
indicator lamp±(Canada only) to illuminate.
See also “Practical hints” section (
page 348).
iOnly use premium unleaded gasoline with a
minimum Posted Octane Rating of 91 (average of
96 RON/86 MON). Information on gasoline
quality can normally be found on the fuel pump.
Please contact gas station personnel in case
labels on the pump cannot be found.
For more information on gasoline, see “Premium
unleaded gasoline” (
page 451), see “Fuel re-
quirements” (
page 451), and the Factory Ap-
proved Service Products pamphlet (USA only) or
contact an authorized Mercedes-Benz Center.


437 Technical data
Engine
Engine
ModelCLS 550 (219.372)1
1The quoted data apply only to the standard vehicle. Contact an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equip-
ment.
CLS 63 AMG (219.377)1
Engine273156
Mode of operation4-stroke engine, gasoline injection4-stroke engine, gasoline injection
No. of cylinders88
Bore3.86 in (98.00 mm)4.02 in (102.20 mm)
Stroke3.56 in (90.50 mm)3.72 in (94.60 mm)
Total piston displacement333.3 cu in (5461 cm3)378.8 cu in (6 208 cm3)
Compression ratio10.7:111.3:1
Output acc. to SAE J 1349382 hp/6 000 rpm2
(285 kW/6 000 rpm)
507 hp/6 800 rpm2
(378 kW/6 800 rpm)
2Premium fuel required. Performance may vary with fuel octane rating.
Maximum torque acc. to SAE J 1349391lb-ft/2800rpm - 4800rpm
(530 Nm/2 800 rpm - 4 800 rpm)465 lb-ft/5 200 rpm
(630 Nm/5 200 rpm)
Maximum engine speed6 500 rpm7 200 rpm
Firing order1-5-4-2-6-3-7-81-5-4-2-6-3-7-8
Poly-V-belt2 404 mm2360 mm

449 Technical data
Fuels, coolants, lubricants etc.
ModelCapacityFuels, coolants, lubricants etc.
Power steeringCLS 550approx. 1.0 US qt (0.9 l)MB Power Steering Fluid (Chevron
Texaco PSF 9109)1
1For detailed information, please refer to the Factory Approved Service Products pamphlet (USA only) or contact an authorized Mercedes-Benz Center.
CLS 63 AMGapprox. 1.3 US qt (1.2 l)
Front wheel hubsCLS 550approx. 3.0 oz (85 g) eachHigh temperature roller bearing grease
CLS 63 AMGapprox. 3.2 oz (90 g) each
Brake systemAll models0.63 US qt (0.6 l)MB Brake Fluid (DOT 4+)
Cooling systemCLS 55011.9 US qt (11.3 l)MB 325.0 Anticorrosion/Antifreeze
CLS 63 AMG12.5 US qt (11.8 l)
Fuel tankAll models21.12 US gal (80.0 l)Premium unleaded gasoline:
Minimum Posted Octane 91
(Avg. of 96 RON/86 MON)
including a reserve ofCLS 5502.38 US gal (9.0 l)
CLS 63 AMG3.7 US gal (14.0 l)
Air conditioning systemAll modelsR-134a refrigerant and special PAG lubricant
oil (never R-12)
Washer system All models4.8 US qt (4.5 l)MB Windshield Washer Concentrate2
2Use MB Windshield Washer Concentrate “MB SummerFit” and water for temperatures above freezing or MB Windshield Washer Concentrate “MB SummerFit” and
commercially available premixed washer solvent/antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 455).
Washer and headlamp cleaning*
systemAll models6.9 US qt (6.5 l)

451 Technical data
Fuels, coolants, lubricants etc.
Premium unleaded gasolineFuel requirements
Only use premium unleaded fuel:

The octane number (posted at the
pump) must be 91 min. It is an average
of both the Research Octane Number
(RON) and the Motor Octane Number
(MON): (RON+MON)/2. This is also
known as the ANTI-KNOCK INDEX.
Unleaded gasoline containing oxygenates
such as ethanol, IPA, IBA and TBA can be
used provided the ratio of any one of these
oxygenates to gasoline does not
exceed 10%; MTBE must not exceed 15%.
The ratio of methanol to gasoline must not
exceed 3% plus additional cosolvents.
Using mixtures of ethanol and methanol is
not allowed. Gasohol, which contains 10%
ethanol and 90% unleaded gasoline, can be
used.
These blends must also meet all other fuel
requirements, such as resistance to spark
knock, boiling range, vapor pressure, etc.Warning!G
Gasoline is highly flammable and poisonous.
It burns violently and can cause serious per-
sonal injury.
Never allow sparks, flame or smoking mate-
rials near gasoline!
Turn off the engine before refueling.
Whenever you are around gasoline, avoid in-
haling fumes and skin or clothing contact,
extinguish all smoking materials.
Direct skin contact with fuels and the inha-
lation of fuel vapors can damage your
health.
!To maintain the engine’s durability and per-
formance, premium unleaded gasoline must be
used. If premium unleaded gasoline is not avail-
able and low octane fuel is used, follow these
precautions:

Have the fuel tank only partially filled with
unleaded regular gasoline and fill up with
premium unleaded gasoline as soon as pos-
sible.

Avoid full throttle driving and abrupt acceler-
ation.

Do not exceed an engine speed of 3000 rpm
if the vehicle is loaded with a light load such
as two persons and no luggage.

Do not exceed 2/3 of maximum accelerator
pedal position if the vehicle is fully loaded or
operating in mountainous terrain.

470 Index
Recommended tire inflation
pressure 325
Recovery services, Stolen vehicle (Tele
Aid) 262
Refrigerant, Air conditioning 450
Refueling 283
Regular checks 285
Reminder, seat belts see Seat belts, Tell-
tale
Remote control see Key, SmartKey
Remote door unlock (Tele Aid) 261
Replacing bulbs
Additional turn signals 407
Brake lamps 407
Front lamps 407
Headlamps 405
High beam headlamps 408
High mounted brake lamp 407
License plate lamps 409
Low beam headlamps 408
Parking lamps 409
Side marker lamps 407
Tail lamps 409
Turn signal lamps 408
Reporting safety defects 18
Research octane number see RONReserve fuel
Message in display 380
Reset button in the instrument
cluster 136, 153
Reset tool (Active head restraints) 401
Restraint system see Children in the vehi-
cle
Retaining hook 242
Reverse gear position, Automatic
transmission 169, 171
Rims 325, 438
Roadside assistance 12
Button 259
RON 284
Roof rack* 238
Rotating tires 326
Rubber parts, cleaning 339
Run Flat Indicator* 304
S
Safety
Driving safety systems 89
Occupant 64
Reporting defects 18
Safety belts see Seat belts
Satellite radio* 149
Seat belt force limiter 79Seat belts 76
Children in the vehicle 82
Cleaning 340
Fastening 48
Height adjustment 50
Proper use of 50, 78
Safety guidelines 68
Telltale 27, 351, 352
Warning lamp 351, 352
Seating capacity 297
Seats 41, 118
Adjusting 41
Easy entry/exit feature* 45
Heater* 121
Memory function 123
Multicontour seat* 120
Ventilation* 122
Securing cargo
Cargo tie-down hooks 242
Selecting display 156
Selective setting see Key, SmartKey or
Key, SmartKey with KEYLESS-GO*
Selector lever see Gear selector lever
Self-test
OCS 76
Tele Aid 257