2008 MERCEDES-BENZ CLK63AMG fuel cap

408 Practical hints
What to do if …?
Display symbolDisplay messagePossible cause/consequencePossible solution
AGas Cap
Is OpenA loss of pressure has been detected in
the fuel system. The fuel cap may not be
closed properly or the fuel system may be
leaky.Check the fuel cap (page 320).
If it is not closed properly:
Close the fuel cap.
If it is closed properly:
Have the fuel system checked at an
authorized Mercedes-Benz Center.
Reserve FuelThe fuel level has dropped below the
reserve mark.Refuel at the next gas station
(
page 320).
± Display Malfunction
Service RequiredCertain electronic systems are unable to
relay information to the control system.
The following systems may have failed:

Coolant temperature display

Tachometer

Cruise control display
Have the electronic systems checked
at an authorized Mercedes-Benz Cen-
ter.

457 Practical hints
Flat tire
Version 2
aDeflate button
bPressure gauge
If the tire inflation pressure is at least
20 psi (1.3 bar), inflate or deflate the
tire to correct tire inflation pressure
(see Tire and Loading Information plac-
ard on the driver’s door B-pillar):
To increase tire inflation pressure:
Switch on the electric air pump.
To decrease tire inflation pressure
(version 1): Open vent screwa
on pressure gaugeb
(
page 455).
To decrease tire inflation pressure
(version 2): Press yellow deflate
buttona located in air pump hous-
ing next to pressure gaugeb.
Warning!G
If tire inflation pressure has fallen below
20 psi (1.3 bar) do not continue to drive the
vehicle.
Park your vehicle safely away from the road-
way and contact the nearest authorized
Mercedes-Benz Center or Roadside
Assistance.
Have the damaged tire replaced.
Warning!G
Follow recommend inflation pressures.
Do not overinflate tires. Overinflating tires
can result in sudden deflation (blowout)
because they are more likely to become
punctured or damaged by road debris,
potholes, etc.
Do not underinflate tires. Underinflated tires
wear unevenly, adversely affect handling
and fuel economy, and are more likely to fail
from being overheated.
Do not overload the tires by exceeding the
specified vehicle capacity weight (as indicat-
ed by the label on the pillar in the driver’s
door opening). Overloading the tires can
overheat them, possibly causing a blowout.


489 Technical data
Fuels, coolants, lubricants, etc.
Fuels, coolants, lubricants, etc.
Capacities
Vehicle components and their respective
lubricants must match. Therefore only use
products tested and approved by
Mercedes-Benz.
Please refer to the Factory Approved
Service Products pamphlet (USA only), or
inquire at an authorized Mercedes-Benz
Center.
Warning!G
Comply with all valid regulations with
respect to handling, storing, and disposing
of service fluids. Otherwise you could
endanger persons or the environment.
Keep service fluids out of the reach of
children.
For health reasons, you should prevent
service fluids from coming into direct
contact with your skin and clothing.
If a service fluid is swallowed, contact a
physician immediately.
ModelCapacityFuels, coolants, lubricants, etc.
Engine with oil filterCLK 350
CLK 550
CLK 63 AMG8.5 US qt (8.0 l)
9.0 US qt (8.5 l)
9.3 US qt (8.8 l)Approved engine oils
Automatic transmissionCLK 350
CLK 550
CLK 63 AMG9.0 US qt (8.5 l)
9.5 US qt (9.0 l)
9.2 US qt (8.7 l)MB Automatic Transmission Fluid
Rear axleCLK 350
CLK 550
CLK 63 AMG1.16 US qt (1.1 l)
1.27 US qt (1.2 l)
1.27 US qt (1.2 l)Hypoid gear oil SAE 85 W 90
Fuchs Titan EG 5010D

490 Technical data
Fuels, coolants, lubricants, etc.
ModelCapacityFuels, coolants, lubricants, etc.
Power steeringCLK 350
CLK 550
CLK 63 AMGapprox. 1.1 US qt (1.0 l)
approx. 1.1 US qt (1.0 l)
approx. 1.3 US qt (1.2 l)MB Power Steering Fluid
(Pentosin CHF 11S)
Front wheel hubsCLK 350
CLK 550
CLK 63 AMGapprox. 3.0 oz (85 g) each
approx. 3.0 oz (85 g) each
approx. 2.5 oz (70 g) eachHigh temperature roller bearing grease
Brake system0.64 US qt (0.6 l)MB Brake Fluid (DOT 4+)
Cooling systemCLK 350
CLK 550
CLK 63 AMGapprox. 7.8 US qt (7.4 l)
approx. 9.7 US qt (9.2 l)
approx. 11.5 US qt (10.9 l)MB 325.0 Anticorrosion/Antifreeze
Agent
Fuel tank
including a reserve of
CLK 350
CLK 550
CLK 63 AMG
16.35 US gal (62.0 l)
2.11 US gal (8.0 l)
2.11 US gal (8.0 l)
3.17 US gal (12.0 l)Premium unleaded gasoline:
Minimum Posted Octane 91
(Avg. of 96 RON / 86 MON)
Air conditioning systemR-134a refrigerant and special PAG lu-
bricant oil (never R-12)
Windshield washer system
Heated windshield washer system and
headlamp cleaning system*3.2 US qt (3.0 l)
6.4 US qt (6.0 l)MB Windshield Washer Concentrate1
1Use MB Windshield Washer Concentrate “MB SummerFit” and water for temperatures above freezing point or MB Windshield Washer Concentrate “MB SummerFit”
and commercially available premixed windshield washer solvent / antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 496).

494 Technical data
Fuels, coolants, lubricants, etc.
Coolants
The engine coolant is a mixture of water
and anticorrosion / antifreeze, which
provides:

Corrosion protection

Freeze protection

Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -35°F (-37°C) and
corrosion protection.
If the antifreeze mixture is effective
to -35°F (-37°C), the boiling point of the
coolant in the pressurized cooling system
is reached at
approximately 266°F (130°C).The coolant solution must be used year
round to provide the necessary corrosion
protection and increase boil-over protec-
tion. Refer to Maintenance Booklet for re-
placement interval.
Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 Anticorrosion/Antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification are used to
renew the coolant concentration or bring it
back up to the proper level.
For information on other Mercedes-Benz
approved products of equal specification,
refer to the Factory Approved Service
Products pamphlet (USA only) or contact
an authorized Mercedes-Benz Center.To provide important corrosion protection,
the solution must be at least 50% anticor-
rosion/antifreeze (equivalent to freeze
protection to approximately -35°F
[-37°C]). If you use a solution that is more
than 55% anticorrosion/antifreeze (freeze
protection to approximately -49°F
[-45°C]), the engine temperature will in-
crease due to the lower heat transfer capa-
bility of the solution. Therefore, do not use
more than this amount of anticorro-
sion/antifreeze.
If the coolant level is low, water and
MB 325.0 Anticorrosion /Antifreeze
should be used to bring it up to the proper
level (have cooling system checked for
signs of leakage). Please make sure the
mixture is in accordance with label instruc-
tions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality,
consult an authorized Mercedes-Benz
Center.
!Add premixed coolant solution only. Adding
water and MB 325.0 Anticorrosion/Antifreeze
separately from each other, could cause engine
damage not covered by the Mercedes-Benz
Limited Warranty

496 Technical data
Fuels, coolants, lubricants, etc.
Windshield washer system and
headlamp cleaning system*
Both the windshield washer system and
headlamp cleaning system are supplied
from the windshield washer reservoir.
The windshield washer reservoir has a
capacity of approximately:

3.2 US qt (3.0 l) in vehicles with wind-
shield washer system

6.4 US qt (6.0 l) in vehicles with heated
windshield washer system* and head-
lamp cleaning system*.
Refill the reservoir with MB Windshield
Washer Concentrate “MB SummerFit”
and water (or concentrate and com-
mercially available premixed wind-
shield washer solvent / antifreeze,
depending on ambient temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing point, use
MB Windshield Washer Concentrate
“MB SummerFit” and water:

1 part “MB SummerFit” to 100 parts
water
(1.34 fl oz [40 ml] “MB SummerFit” to
1gal [4.0l] water)
For temperatures below freezing point, use
MB Windshield Washer Concentrate
“MB SummerFit” and commercially avail-
able premixed windshield washer
solvent / antifreeze:

1 part “MB SummerFit” to 100 parts
solvent
(1.34 fl oz [40 ml] “MB SummerFit” to
1 gal [4.0 l] solvent)
Warning!G
Washer solvent/antifreeze is highly flam-
mable. Do not spill washer
solvent/antifreeze on hot engine parts, be-
cause it may ignite and burn. You could be
seriously burned.

499 Index
C
California retail buyers and
lessees, Important notice for 11
Call priority (Tele Aid) 300
Can holder see Cup holder
Capacities and
recommended fuels/lubricants 489
Cargo area see Trunk
Cargo tie-down rings 284
Carpets, cleaning 375
Catalytic converter 318
CD changer* 229
MP3 230
CD player 229
Control system 152
Center console 31
Lower part 32
Upper part 31
Central locking
Automatic 118, 166
Locking/unlocking from inside 119
Central locking switch 119
Certification label 478
Certification label, examples 478
Charcoal filter 209Checking tire pressure electronically
Tire Pressure Monitoring System
(TPMS), (USA only) 344
Children in the vehicle 83
Air bags 83
Blocking
rear side window operation 88
Front passenger front
air bag off indicator lamp 76
Infant and
child restraint systems 77, 83, 86
LATCH-type child seat anchors 87
Occupant Classification System
(OCS) 72
Cigarette lighter 290
Climate control
see Climate control system
Climate control system
Air conditioning refrigerant 491
Air conditioning, Cooling 198, 210
Air distribution 194, 205
Air recirculation mode 196, 207
Air vents 199, 212
Air volume 194, 195, 206
Charcoal filter 209Control panel,
Automatic climate control 201
Deactivating/Reactivating 193, 203
Defogging 206
Defrosting 206
Defrosting, rear window 189
Front defroster 195
MAXCOOL 207
Residual engine heat
and ventilation* (REST*) 211
Temperature 194, 204
Clock 29, 140, 160
Setting time 160
Cockpit 26
Cold tire inflation pressure 358
Collapsible wheel chock 422, 424
COMAND* see separate
COMAND operating instructions
Combination switch 55, 133
Control system 141
Functions 143, 145
Multifunction display 141
Multifunction steering wheel 142
Resetting to factory default 155

503 Index
F
Filler cap, Engine oil 327
Filler neck, Engine oil 327
First aid kit 421
Flat tire 452
Jacking up the vehicle 459
Lowering the vehicle 462
Minispare wheel 425
Mounting the spare wheel 458
Preparing the vehicle 452
TIREFIT (CLK 63 AMG only) 422
TIREFIT kit* 452
Floormats* 291
Fluids
Brake fluid 322, 491
Engine coolant 322, 494
Engine oil 322, 491
Windshield washer and headlamp
cleaning* system 322, 496
Fog lamps 132, 444
Messages in display 412
Replacing bulbs 444, 445, 448
Front air bags 70
Front lamps see Headlamps
Front passenger front air bag 65, 70
Messages in display 396–399Front passenger front air bag
off indicator lamp 31, 76, 390
Front seat head restraints
see Head restraints
Fuel 321, 489
Additives 493
Automatic transmission fluid 489
Brake fluid 490
Capacities 489
Capacities, Fuel tank 490
Engine coolant 490
Engine oil 489
Filling the tank 320
Fuel display 29
Fuel filler flap and cap 320
Fuel filler flap and cap, Multifunction
display messages 408
Fuel reserve warning lamp 385
Power steering fluid 490
Premium
unleaded gasoline 321, 490, 492
Requirements, Octane rating 492
Technical data 489
Fuel cap
Message in display 382Fuel consumption statistics
After start 167
Resetting 168
Since last reset 168
Fuel filler flap 320
Locking/unlocking 320
Opening 320
Fuel reserve warning lamp 29
Fuel tank
Capacity 490
Filler flap 320
Fuel, Premium
unleaded gasoline 321, 492
Fuels, coolants, lubricants etc.
Capacities 489
Fuses 472
Fuse box (main)
in passenger compartment 472
Fuse box
in engine compartment 473
Fuse box
in trunk 474
Replacing 472