2008 HONDA PILOT transmission fluid

Put a new washer on the f iller bolt,
then reinstall the f iller bolt and
tighten it securely. Tightening
torque:
Check the f luid level with the
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer, and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add
VTM-4 Dif f erential Fluid until it
starts to run out of the hole. The rear dif f erential should be
drained and ref illed with new f luid
according to the maintenance
messages shown on the inf ormation
display. Have your dealer replace the
rear dif f erential f luid.
The transf er assembly should be
drained and ref illed with new f luid
when this service is indicated by a
maintenance message on the
inf ormation display.
Always use Hypoid gear oil GL4 or
GL5 with a viscosity of SAE 90 or
80W-90, and have your dealer
replace the transfer assembly fluid.
Insert the dipstick all the way back
into the transmission securely as
shown in the illustration.
6.
4WD models only
Dif f erential Oil
Transf er Assembly Fluid
Automatic Transmission Fluid, Dif f erential Oil, Transf er Assembly Fluid
Maint enance
251
FILLER BOLTCORRECT LEVEL
33 lbf·ft (45 N·m , 4.6 kgf·m)
Use only Honda Genuine ATF-Z1
(Automatic Transmission Fluid). Do
not mix with other transmission f luids.
Using transmission f luid other than
Honda Genuine ATF-Z1 may cause
deterioration in transmission operation
and durability, and could result in
damage to the transmission.
Damage resulting f rom the use of
transmission f luid other than Honda
Genuine ATF-Z1 is not covered by the
Honda new vehicle warranty.
\f—\f—\fy


y
(+\fy\fy
2008 Pilot

ÎÎ Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
µ
ÎÎ
Specif ications
294
Dimensions
Weights
Battery
Capacities
Seating Capacities 1.93 US gal (7.3
)
2.43 US gal (9.2)
4.5 US qt (4.3
)
4.2 US qt (4.0
)
5.3 US qt (5.0
)
20.34 US gal (77.0
)
188.0 in (4,775 mm)
76.5 in (1,943 mm)
Length
Width
Height
Wheelbase
Track 66.3 in (1,685 mm) 106.3 in (2,700 mm)
70.5 in (1,790 mm)
Gross vehicle weight rating
Gross combined weight
rating (GCWR) See the tire information label atta-
ched to the driver’s doorjamb.
9,700 lbs (4,400 kg)
77.5 in (1,968 mm)
71.7 in (1,821 mm)
70.1 in (1,780 mm)
71.3 in (1,811 mm)
66.5 in (1,690 mm)
66.5 in (1,690 mm)
66.7 in (1,694 mm)
12 V 20 AH/5 HR
Capacity Excluding the oil remaining in the engine
0.193 US gal (0.73
)
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity: 2.79 US qt (2.64
)
4.8 US qt (4.5
)
Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid
Rear
differential
fluid (4WD)
Windshield
washer
reservoir
8.3 US qt (7.9
)
3.5 US qt (3.3
)
8.9 US qt (8.4
)
4.0 US qt (3.8
)
Equipped with transmission fluid cooler and power steering
fluid cooler.
The GCWR must be reduced 2 percent for every 1,000 feet (305
meters) of elevation.
Total
Front
Rear 8
2
3
3 Approx.
1:
2:
1:
2: Front
Rear
4WD
2WD
Front
Rear
4WD
2WD Change
Total
Change
Including
filter
Without
filter
Total
Change
Total
Change 4WD
2WD
4WD
2WD
Second row
Third row
1 : LX and LX-VP models 2 : EX, EX-L, and EX-SE models
2
1 1
2
1
2
1
2
1
2
\f—\f—\fy



y
(+\fy\fy
2008 Pilot

CONT INUED
...
Accessories and Modif ications .196
ACCESSORY (Ignition Key
.......................................
Position) .81
............
Accessory Power Sockets .101
...........................
AC Power Outlet .102
....................
Additives, Engine Oil .245
...............
AdvancedAirbagSystem .30
.............................
Airbag (SRS) .11,25
..........
Airbag System Components .25
..............
Air Conditioning System .106
.....................
Rear A/C Control .113
.......................
Air Pressure, Tires .264
......................................
Antif reeze .248
...............
Anti-lock Brakes (ABS) .216
...............................
Indicator .63,217
...................................
Operation .216
..............
Anti-thef t, Audio System .141
.
Anti-thef t Steering Column Lock .81
................................
Audio System .115
...
Automatic Seat Belt Tensioners .23
...
Automatic Lighting Off Feature .76
.............
Automatic Speed Control .177
..............
Automatic Transmission .206
..........................
Capacity, Fluid .294 ...............
Checking Fluid Level .250
.......................................
Shif ting .206
.
Shif t Lever Position Indicator .206
................
Shif t Lever Positions .207
....................
Shif t Lock Release .209
Battery Charging System ...........................
Indicator .62,282
............................
Jump Starting .278
..............................
Maintenance .269
............................
Specif ications .294
..............................
Bef ore Driving .187
..................................
Belts, Seat .10,21
...........................
Beverage Holders .99
..................................
Booster Seats .54
Brakes
...........
Anti-lock System (ABS) .216
.............
Break-in, New Linings .188
....................
Bulb Replacement .258
...........................................
Fluid .252
.........................................
Parking .97
.................
System Indicator .63,284
........................
Wear Indicators .215 .............................
Braking System .215
.................
Break-in, New Vehicle .188
..
Brightness Control, Instruments .76
........................
Brights, Headlights .75
Bulb Replacement
..........................
Back-up Lights .258
.....................
Brake Lights .258,259
................
Front Parking Lights .255
........
Front Side Marker Lights .255
.................................
Headlights .254
........
High-mount Brake Lights .259
.................................
Rear Bulbs .258
............................
Specif ications .295
.............
Turn Signal Light .255,258
..............................
Bulbs, Halogen .254
............................
Capacities Chart .294
.............
Carbon Monoxide Hazard .57
.............................
Carrying Cargo .198
.............
CAUTION, Explanation of .iii
..........................
CD Changer .131,134
.......................................
CD Player .130
Index
A
B
C
INDEX
I
——y

y
(+y
y
2008 Pilot

CONT INUED
...................................
Fan, Interior .106
.........................................
Features .105
....................
Filling the Fuel Tank .189
Filters
...............................................
Oil .246
.............
Flashers, Hazard Warning .77
...................
Flat Tire, Changing a .273 Fluids
..........
Automatic Transmission .250
..........................................
Brake .252
..........................
Power Steering .253
................
Windshield Washers .249
...................
Folding the Third Seat .90
..........................
Four-way Flashers .77
.................................................
Fuel .188
...............................
Cap Message .72
......................
Fill Door and Cap .189
...........................................
Gauge .70
................
Octane Requirement .188
........................
Reserve Indicator .67
........................
Tank, Filling the .189
.....................
Fuses, Checking the .285
...............
Gas Mileage, Improving .194
.........................................
Gasoline .188
...............
Fuel Reserve Indicator .67
...........................................
Gauge .70
................
Octane Requirement .188
........................
Tank, Filling the .189
................
Gas Station Procedures .189 Gauges
...
Engine Coolant Temperature .71
...............................................
Fuel .70
GAWR (Gross Axle Weight .......................................
Rating) .221
GCWR (Gross Combined Weight .......................................
Rating) .221
............
Gearshif t Lever Positions .206
........................................
Glove Box .99
GVWR (Gross Vehicle Weight
.......................................
Rating) .221
.............
Halogen Headlight Bulbs .254
.................
Hazard Warning Button .77
Engine
....
Coolant Temperature Gauge .71
Malf unction Indicator
................................
Lamp .62,283
........
Oil Pressure Indicator .62,282
..............
Oil, What Kind to Use .245
...............................
Overheating .280
............................
Specif ications .295
............................
Speed Limiter .208
.......................................
Starting .205
.
Evaporative Emissions Controls .302
...............................
Exhaust Fumes .57
Exhaust Gas Recirculation
........................................
System .303
Expectant Mothers, Use of Seat ........................................
Belts by .19
Index
F GH
INDEX
III
\f—\f—\fy

y
(+\fy\f\fy
2008 Pilot

Unexpected, Taking Care..........................................
of the .271
....
Unif orm Tire Quality Grading .296
........................
Unleaded Gasoline .188
.......
Used Oil, How to Dispose of .247
................................
Vanity Mirror .101
.................
Vehicle Capacity Load .199
......................
Vehicle Dimensions .294
....
Vehicle Identif ication Number .292
Vehicle Stability Assist (VSA)
....................................
System .218
.........................
VSA Of f Switch .219
.............................
Vehicle Storage .270
.................................................
VIN .292
..................................
Viscosity, Oil .245
..................................
VTM-4 Lock .210 ............
WARNING, Explanation of .iii
.........
Warning Labels, Location of .58
....................
Warranty Coverages .309
Washer, Windshield
........
Checking the Fluid Level .249
............................
Level Indicator .67
.....................................
Operation .74
Wheels ...............
Adjusting the Steering .78
............
Alignment and Balance .266
..........................
Compact Spare .272
...............................
Nut Wrench .275
Windows ..................
Operating the Power .94
...........................
Rear, Def ogger .77
Windshield ...........................
Def roster .108,110
.......................................
Washers .74
Wipers, Windshield .......................
Changing Blades .261
.....................................
Operation .74
Rear Window Wiper and
.....................................
Washer .74
..................
Wireless Headphones .174
...............................................
Tires .263
..............................
Air Pressure .264
.........................
Checking Wear .265
..........................
Compact Spare .272
......
DOT Tire Quality Grading .296
......................................
Inf lation .263
..................................
Inspection .265
..............................
Maintenance .266
...................................
Replacing .266
......................................
Rotating .266
................................
Service Lif e .265
...........................................
Snow .268
............................
Specif ications .295
...................
Tools, Tire Changing .273
Towing
.....................................
A Trailer .220
................
Emergency Wrecker .285
....
Equipment and Accessories .227
.......................
Traction Devices .268
..................
Trailer Driving Tips .227
.............................
Weight Limit .223
Transmission ...............
Checking Fluid Level .250
...........................
Fluid Selection .250
..............
Identif ication Number .292
.............
Shif ting the Automatic .206 .....................................
Treadwear .296
.......................................
Trip Meter .70
....................................
Turn Signals .75
Index
U
V W
VIII
——y

y
(+yy
2008 Pilot

4WD models only
Service Inf ormation Summary
Gasoline:
Fuel Tank Capacity:
Recommended Engine Oil:Power Steering Fluid:
Brake Fluid:Tire Pressure (measured cold):
Automatic Transmission Fluid: Rear Differential Fluid: 32 psi (220 kPa , 2.2 kgf/cm
)
60 psi (420 kPa , 4.2 kgf/cm
)
Honda Power Steering Fluid
preferred, or another brand of
power steering fluid as a
temporary replacement. Do not
use ATF (see page ).
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ). Compact Spare Tire:
Front/Rear:
API Premium grade 5W-20
detergent oil (see page ).
Oil change capacity (including
filter): 4.5 US qt (4.3
)
Honda ATF-Z1 (Automatic
Transmission Fluid) (see page ).
Unleaded gasoline, pump octane
number of 87 or higher.
Honda VTM-4 Differential Fluid
(see page ).
245
251 253
252
251
20.34 US gal (77.0)
\f—\f—\fy

y
(+\fy\fy
2008 Pilot