2008 HONDA CIVIC SEDAN manual transmission

µµ
If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
with just a rope or chain. It is very
dangerous.
The operator
loads your vehicle on the back of a
truck. Therearetwowaystotowyour
vehicle: If , due to damage, your vehicle must
be towed with the f ront wheels on
the ground, do this:
Release the parking brake.
Shif t the transmission to neutral.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.
The tow
truck uses two pivoting arms that go
under the f ront tires and lif t them of f
the ground. The rear tires remain on
the ground. With the f ront wheels on the ground,
do not tow the vehicle more than 50
miles (80 km), and keep the speed
below35mph(55km/h).
Start the engine.
Press on the brake pedal. Move
the shif t lever through all its
positions.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock. Release the parking brake. Turn of f the engine. Shif t to D position f or 5 seconds,
then to N.
Manual transmission:
Automatic transmission:
Flat -bed Equipment
Wheel-lif t Equipment
T his is the best way to
transport your vehicle.
This is an acceptable
way to tow your vehicle.
Emergency Towing
286
Improper towing preparation will
damage the transmission. Follow the
above procedure exactly. If you cannot
shif t the transmission or start the
engine (automatic transmission), your
vehicle must be transported with the
f ront wheels of f the ground.
——y
y
(#y
y
2008 Civic Sedan

The engine number is stamped into
the engine block. It is on the f ront.
The transmission number is on a
label on top of the transmission.
Identif ication Numbers
Technical Inf ormation
291
MANUAL TRANSMISSION
NUMBER ENGINE NUMBER ENGINE NUMBER
AUTOMATIC/MANUAL
TRANSMISSION NUMBER
Except Si
Si
——y

y
(#yy
2008 Civic Sedan

µµ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Î
Î
Î
ÎÎÎ Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Specif ications
Technical Inf ormation
293
Air Conditioning
Lights
Capacities
Refrigerant type
Charge quantity
Lubricant oil typeHFC-134a (R-134a)
14.1 15.9 oz (400 450 g) SP-10
Headlights
Front turn signal/side marker/
Parking lights
Rear turn signal lights
Stop/Taillights
Rear side marker lights
Back-up lights
Taillights
High-mount brake light
License plate lights
Ceiling light
Spotlights
Trunk light 12 V 60 W (HB3)
12 V 51 W (HB4)
12 V 21/5 W
12 V 21 W
12 V 21/5 W
12 V 2 CP
12 V 21 W
12 V 3 CP
12 V 21 W
12 V 5 W
12 V 8 W
12 V 8 W
12 V 5 W
4.8 US qt (4.5
)
1.8 US qt (1.7
)
1.6 US qt (1.5
)
1.19 US gal (4.5
)
1.80 US gal (6.8
)
4.6 US qt (4.4
)
4.4 US qt (4.2
)
5.8 US qt (5.5
)
6.2 US qt (5.9
)
2.5 US qt (2.4)
1.40 US gal (5.3
)
1.77 US gal (6.7
)
2.6 US qt (2.5
)
1.7 US qt (1.6
)
1.5 US qt (1.4
)
1.37 US gal (5.2
)
1.72 US gal (6.5
)
3.9 US qt (3.7
)
3.7 US qt (3.5
)
4.8 US qt (4.5
)
13.2 US gal (50
)
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity: 0.11 US gal (0.4
)
Excluding the oil remaining in the engine
Fuel tank
Engine
coolant
Engine oil
Manual
transmission
fluid
Automatic
transmission
fluid
Windshield
washer
reservoir
High
Low
A/T
M/T
A/T
M/T
Change
Total
U.S. Vehicles
Canada
Vehicles Approx.
1:
2:
3:
4: Except Si
Si Change
Including filter
Without filter
Total
Change
Total
Change
Total
13 3
4
3
3
4
3
4
3
4
3
4
3
4
3
4
2
3
—
—y
y
(#yy
2008 Civic Sedan

µ
µ
µ
µ
µ
µ
µ
Î
Î
Î
Î
Î
Î
Î
Î
Î Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î Î
Specif ications
294
Fuses
Alignment Battery Tires
P195/65R15 89H
Interior
Under-hood
Toe-in
Camber
Caster 7°24’ 0°45’0°
0.08 in (2.0 mm) 0.00 in (0.0 mm)
See page284or the fuse box
cover. See page285or the fuse label
attached to the inside of the fuse
box door under the steering
column.
Capacity 12 V
12 V
12 V36 AH/5 HR
38 AH/5 HR 45 AH/20 HR
47 AH/20 HR
12 V
12 V 38 AH/5 HR
47 AH/20 HR
12 V
60 psi (420 kPa , 4.2 kgf/cm
)
33 psi (230 kPa , 2.3 kgf/cm)
32 psi (220 kPa , 2.2 kgf/cm)
30 psi (210 kPa , 2.1 kgf/cm)
Size
Pressure
T135/80R16 101M
T125/70D15 95M
215/45ZR17 91W P215/45R17 87V
P205/55R16 89H
T125/70D16 96M P195/65R15 89S
Front
Rear
Front
Rear
Front Front/Rear
Spare
LX, EX, EX-L
Si (all season tires)
Except Si
Si Optional for Si (summer tires)
U.S.
Vehicles
Canada
Vehicles
1:
2:
3:
4:
5:
6:
7:
8:DX, Canadian DX-G with automatic transmission
Canadian DX-G with manual transmission
Si without VSA system Front/Rear
Spare
3 1
2
4
5
7
7
3
4, 6
6
7
8 1, 2
—
—y
y
(#yy
2008 Civic Sedan

The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
qualitypartsmayincreasethe
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion.
The exhaust emissions controls
include f our systems: PGM-FI,
ignition timing control, exhaust gas
recirculation, and three way catalytic
converter. These f our systems work
together to control the engine’s
combustion and minimize the
amount of HC, CO, and NOx that
come out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.
The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine how
much air is going into the engine. It then controls how much f uel to inject
under all operating conditions.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The exhaust gas recirculation (EGR)
system takes some of the exhaust
gas and routes it back into the intake
manif old. Adding exhaust gas to the
air/f uel mixture reduces the amount
of NOx produced when the f uel is
burned.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
2
2
Exhaust Emissions Controls Replacement Parts
PGM-FI System Ignit ion T iming Cont rol Syst em
Exhaust Gas Recirculat ion (EGR)Syst em
Three Way Catalytic Converter
Emissions Cont rols
Technical Inf ormation
301
——y
y
(#yy
2008 Civic Sedan

If you take your vehicle f or an
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Make sure the vehicle has been
parked with the engine of f f or 6
hours or more.
Make sure the ambient
temperature is between 40° and
95°F.
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.
Make sure the gas tank is nearly,
but not completely, f ull (around
3/4). Keep the vehicle in Park
(automatic transmission) or
neutral (manual transmission).
Increase the engine speed to 2,000
rpm,andholditthereuntilthe
temperature gauge rises to at least
1/4of thescale(about3minutes).
Without touching the accelerator
pedal and let the engine idle f or 20
seconds.
1.
2.
3. 4.
5.
6.
CONT INUED
T esting of Readiness Codes
Emissions T esting
Technical Inf ormation
303
——y

y
(#yy
2008 Civic Sedan

Î
CONT INUED
Doors.
Auto Door Locking/Unlocking .81
.....................
Auto Door Locking .81
.................
Auto Door Unlocking .83
..............
Locking and Unlocking .79
......................
Power Door Locks .80
........
DOT Tire Quality Grading .295
Downshif ting, Manual
.............................
Transmission .199
...........
Driver and Passenger Safety .5
...........................................
Driving .195
....................................
Economy .186
..................................
Guidelines .196
..................
Dust and Pollen Filter .250
..............................
Economy, Fuel .186
............
Emergencies on the Road .265
.............
Battery, Jump Starting .273
...........
Brake System Indicator .279
................
Changing a Flat Tire .267
.....
Charging System Indicator .277
..................
Checking the Fuses .280
.....
Low Oil Pressure Indicator .277
...
Malf unction Indicator Lamp .278 ..................
Overheated Engine .275
.........................
Emergency Brake .103
......................
Emergency Flashers .74
......................
Emergency Towing .286
............
Emergency Trunk Opener .87
.......................
Emissions Controls .300
........................
Emissions Testing .303
Engine
....
Coolant Temperature Gauge .67
......
Engine Speed Limiter .201, 204
Malf unction Indicator
......................................
Lamp .278
........
Oil Pressure Indicator .65, 277
..............
Oil, What Kind to Use .232
...............................
Overheating .275
............................
Specif ications .292
.......................................
Starting .198
......................
Ethanol in Gasoline .181
.
Evaporative Emissions Controls .300
...............................
Exhaust Fumes .51
Expectant Mothers, Use of Seat
........................................
Belts by .16
...................................
Fan, Interior .108 .........................................
Features .107
....................
Filling the Fuel Tank .181
Filters
.........................
Dust and Pollen .250
...............................................
Oil .234
5-speed Manual Transmission ...............
Checking Fluid Level .241
................................
Shif ting the .199
.............
Flashers, Hazard Warning .74
...................
Flat Tire, Changing a .267
Fluids
..........
Automatic Transmission .240
..........................................
Brake .242
.........................................
Clutch .243
...................................
Locations .230
..............
Manual Transmission .241
..........................
Power Steering .243
..................
Windshield Washer .239
FM Stereo Radio ...................................
Reception .166
...........................
Folding Rear Seat .95
..........................
Four-way Flashers .74
..............................
Front Airbags .9, 24
Index
F
E
INDEX
III
——y

y
(#y
y
2008 Civic Sedan

.................................................
Fuel .180
......................
Fill Door and Cap .181
...........................................
Gauge .67
................
Octane Requirement .180
...............................
Oxygenated .181
........................
Reserve Indicator .64
........................
Tank, Filling the .181
.....................
Fuses, Checking the .280
.................
Jacking up the Vehicle .268
.......................................
Jack, Tire .267
................................
Jump Starting .273
...............
Gas Mileage, Improving .186
.........................................
Gasoline .180
...............
Fuel Reserve Indicator .64
...........................................
Gauge .67
................
Octane Requirement .180
........................
Tank, Filling the .181
................
Gas Station Procedures .181
Gauges
...
Engine Coolant Temperature .67
...............................................
Fuel .67
Gearshif t Lever Positions ..........
Automatic Transmission .202
..............
Manual Transmission .199
......................................
Glove Box .106 .............
Halogen Headlight Bulbs .244
..............
Hazard Warning Flashers .74
Headlights
........................................
Aiming .244
............
Daytime Running Lights .73
..................
High Beam Indicator .61
........................
Reminder Beeper .72
........
Replacing Halogen Bulbs .244
...................................
Turning on .72
..............................
Head Restraints .92
.............................
Heated Mirrors .103
.....................
Heating and Cooling .108
.............
High Altitude, Starting at .198
.................
High-Low Beam Switch .72
..............
High-mount Brake Light .249
.......................
Hood, Opening the .182
..............................................
Horn .4,70
...
Identif ication Number, Vehicle .290
Ignition
..............................................
Keys .76
...........................................
Switch .78 ............
Timing Control System .301
.........
Important Safety Precautions .6
.........
Indicators, Instrument Panel .59
...............................
Inf ant Restraint .38
Inf ant Seats
.............
LATCH Anchor System .42
...........................
Lower Anchors .42
................
Tether Anchor Points .45
Inf lation, Recommended Tire ...................................
Pressures .255
........................
Inf ormation Display .66
.................................
Inside Mirror .102
.............................
Inspection, Tire .256
............................
Instrument Panel .57
................
Instrument Panel Lights .59
........
Instrument Panel Brightness .73
..............
Instruments and Controls .55
...............................
Interior Lights .104
........................................
Introduction .i
Index
H
I
G
J
IV
——y
y
(#y
y
2008 Civic Sedan