IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT
3.5L V6 ENGINE
1. Power steering fluid reservoir
2. Engine coolant reservoir
3. Brake fluid reservoir
4. Battery
5. Power distribution box
6. Air filter assembly
7. Automatic transmission fluid dipstick
8. Engine oil dipstick
9. Engine oil filler cap
10. Windshield washer fluid reservoir
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
279
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated areas for normal operating temperature.
Low fluid level
Do not drive the vehicle if the fluid
level is in the add range or does not
show at all on the dipstick.
Correct fluid level
The transmission fluid should be checked at normal operating
temperature 149°F (65°C) on a level surface. The normal operating
temperature can be reached after approximately 20 miles (30 km) of
driving.
The transmission fluid should be
within the cross-hatch area if at
normal operating temperature 149°F
(65°C).
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
303
High fluid level
Fluid levels above the safe range
may result in transaxle failure. An
overfill condition of transmission
fluid may cause shift and/or
engagement concerns and/or possible damage.
High fluid levels can be caused by an overheating condition.
Adjusting automatic transmission fluid levels
Before adding any fluid, make sure the correct type is used. The type of
fluid used is normally indicated on the dipstick and also in the
Maintenance product specifications and capacitiessection in this
chapter.
Use of a non-approved automatic transmission fluid may cause
internal transaxle component damage.
If necessary, add fluid in 1/2 pint
(250 mL) increments through the
filler tube until the level is correct.
If an overfill occurs, excess fluid
should be removed by an authorized
dealer.
An overfill condition of
transmission fluid may cause shift and/or engagement concerns
and/or possible damage.
Do not use supplemental transmission fluid additives, treatments or
cleaning agents. The use of these materials may affect transmission
operation and result in damage to internal transaxle components.
AIR FILTER
Refer toscheduled maintenance informationfor the appropriate
intervals for changing the air filter element.
When changing the air filter element, use only the Motorcraft air filter
element listed. Refer toMotorcraft part numbersin this chapter.
To reduce the risk of vehicle damage and/or personal burn
injuries do not start your engine with the air cleaner removed
and do not remove it while the engine is running.
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
304
MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES
Items CapacityFord Part Name or
equivalentFord Part Number /
Ford Specification
Brake fluidBetween MAX and
MIN on reservoirMotorcraft High
Performance DOT 3
Motor Vehicle Brake
FluidPM-1-C /
WSS-M6C62-A
Door latch, hood latch,
auxiliary hood latch,
seat tracks, trunk and
liftgate latches— Multi-Purpose GreaseXG-4 or XL-5 /
ESA-M1C93-B
Lock cylinders —Motorcraft Penetrating
and Lock LubricantXL-1 /
None
Automatic transmission
fluid10.0 quarts
(9.5L)
1
Motorcraft MERCONV
AT F
2
XT-5-QM /
MERCONV
Rear differential (AWD)
fluid2.4 pints (1.15L)Motorcraft SAE 80W-90
Premium Rear Axle
LubricantXY-80W90-QL /
WSP-M2C197-A
Power Transfer Unit
(PTU) fluid (AWD)
5
18 ounces (0.53L)Motorcraft SAE 75W-140
Synthetic Rear Axle
LubricantXY-75W140-QL /
WSL-M2C192-A
Engine oil 5.5 quarts (5.2L)Motorcraft SAE 5W-20
Premium Synthetic
Blend Motor Oil (US)
Motorcraft SAE 5W-20
Super Premium Motor
Oil (Canada)
3
XO-5W20-QSP (US)
CXO-5W20- LSP12
(Canada) /
WSS-M2C930-A and API
Certification Mark
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
307
Items CapacityFord Part Name or
equivalentFord Part Number /
Ford Specification
Engine coolant11.1 quarts
(10.5L)Motorcraft Premium
Gold Engine Coolant
with bittering agent
(yellow-colored)
4
VC-7-B /
WSS-M97B51-A1
Power steering fluidBetween MAX and
MIN on reservoirMotorcraft MERCONV
AT FX T-5-QM /
MERCONV
Windshield washer fluidTop- off fluid as
neededMotorcraft Premium
Windshield Washer
ConcentrateZC-32-A /
WSB-M8B16-A2
Fuel tank20.5 gallons
(77.6L) AWD,
PZEV AWD and
PZEV FWD——
20.0 gallons
(75.7L) (FWD)
1Approximate dry fill capacity. Actual amount may vary during fluid changes.2Automatic transmissions that require MERCONV should only use MERCONV fluid or fluid that
is specified dual usage MERCON/MERCONV. Refer toscheduled maintenance informationto
determine the correct service interval. Use of any fluid other than the recommended fluid may
cause transmission damage.3Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C930-A and the API Certification mark.4Add the coolant type originally equipped in your vehicle.5See your authorized dealer for fluid level checking or filling.
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
308
A
Accessory delay ..........................95
AdvanceTrac ..............................221
Air cleaner filter ...............304–306
Air conditioning ....................73, 75
Airbag supplemental restraint
system ........................159, 168, 170
and child safety seats ............161
description ..............159, 168, 170
disposal ....................................173
driver airbag ............161, 169, 171
indicator light .................167, 173
operation .................161, 169, 171
passenger airbag .....161, 169, 171
side airbag ...............................168
All Wheel Drive (AWD),
driving off road .........................231
Antifreeze
(see Engine coolant) ................286
Anti-lock brake system
(see Brakes) ..............................219
Anti-theft system ..............132, 135
arming the system ..................135
disarming a triggered
system .....................................136
Audio system
(see Radio) ......................16, 20, 27
Automatic transaxle
fluid, adding ............................302
fluid, checking ........................302
fluid, refill capacities ..............307
fluid, specification ..................307
Automatic transmission
driving an automatic
overdrive .................................226
Auxiliary input jack (Line in) ....36B
Battery .......................................284
acid, treating emergencies .....284
jumping a disabled battery ....254
maintenance-free ....................284
replacement, specifications ...306
servicing ..................................284
Belt-Minder.............................154
Booster seats .............................174
Brakes ........................................218
anti-lock ...................................219
anti-lock brake system (ABS)
warning light ...........................219
fluid, checking and adding ....302
fluid, refill capacities ..............307
fluid, specifications .................307
lubricant specifications ..........307
parking ....................................220
shift interlock ..........................225
Bulbs ............................................83
C
Capacities for refilling fluids ....307
Cargo net ...................................116
Cell phone use ..............................7
Changing a tire .........................246
Child safety restraints ..............174
child safety belts ....................174
Child safety seats ......................177
attaching with tether
straps .......................................181
in front seat ............................178
in rear seat ..............................178
Child safety seats - booster
seats ...........................................174
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
314
Cleaning your vehicle
engine compartment ..............272
instrument panel ....................274
interior .....................................274
plastic parts ............................273
washing ....................................270
waxing .....................................271
wheels ......................................271
wiper blades ............................273
Climate control (see Air
conditioning or Heating) ......73, 75
Clock ............................................91
Clock adjust
6-CD in dash .............................28
AM/FM/CD .................................21
Compass, electronic
set zone adjustment ...............109
Console
overhead ....................................91
Controls
power seat ...............................140
steering column ......................100
Coolant
checking and adding ..............286
refill capacities ................290, 307
specifications ..........................307
Cruise control
(see Speed control) ....................97
Cupholder(s) .............................145
Customer Assistance ................237
Ford Extended Service
Plan ..........................................266
Getting assistance outside
the U.S. and Canada ..............267
Getting roadside assistance ...237
Getting the service you
need .........................................262
Ordering additional
owner’s literature ...................268Utilizing the Mediation/
Arbitration Program ...............266
D
Daytime running lamps
(see Lamps) ................................81
Dipstick
automatic transmission
fluid ..........................................302
engine oil .................................281
Driving under special
conditions ..........................232, 234
sand .........................................233
snow and ice ...........................235
through water .................233, 236
DVD system .................................43
E
Electronic message center .......107
Emergencies, roadside
jump-starting ..........................254
Emission control system ..........299
Engine ........................................309
cleaning ...................................272
coolant .....................................286
idle speed control ...................284
lubrication specifications .......307
refill capacities ........................307
service points ..........................279
starting after a collision .........239
Engine block heater .................218
Engine oil ..................................281
change oil soon warning,
message center .......................281
checking and adding ..............281
dipstick ....................................281
filter, specifications ........283, 306
recommendations ...................283
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
315
Tires ...........................185–186, 246
alignment ................................193
care ..........................................189
changing ..........................246, 250
checking the pressure ............189
inflating ...................................187
label .........................................199
replacing ..................................191
rotating ....................................193
safety practices .......................192
sidewall information ...............195
snow tires and chains ............205
spare tire .................................247
terminology .............................186
tire grades ...............................186
treadwear ........................185, 190
Towing .......................................211
recreational towing .................213
trailer towing ..........................211
wrecker ....................................260
Traction control ........................223
Transaxle
fluid, checking and adding
(automatic) .............................302
fluid, refill capacities ..............307
lubricant specifications ..........307
Transmission .............................225
brake-shift interlock (BSI) ....225
Trunk .................................123, 126remote release ........................116
Turn signal ..................................83
U
USB port ......................................37
V
Vehicle Identification Number
(VIN) ..........................................310
Vehicle loading ..........................205
Ventilating your vehicle ...........218
W
Warning lights (see Lights) .......10
Washer fluid ..............................280
Water, Driving through .............236
Windows
power .........................................93
Windshield washer fluid and
wipers ..........................................89
checking and adding fluid .....280
replacing wiper blades ...........281
Wrecker towing .........................260
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
319