2008 FORD TAURUS steering

INSTRUMENT PANEL/INTERIOR TRIM AND CLUSTER LENS
Clean the instrument panel, interior trim areas and cluster lens with a
clean and damp white cotton cloth, then with a clean and dry white
cotton cloth; you may also use Motorcraft Dash & Vinyl Cleaner
(ZC-38-A) on the instrument panel and interior trim areas.
•Avoid cleaners or polishes that increase the gloss of the upper portion
of the instrument panel. The dull finish in this area helps protect the
driver from undesirable windshield reflection.
•Be certain to wash or wipe your hands clean if you have been in
contact with certain products such as insect repellent and suntan
lotion in order to avoid possible damage to the interior painted
surfaces.
•Do not use household or glass cleaners as these may damage the
finish of the instrument panel, interior trim and cluster lens.
Do not use chemical solvents or strong detergents when cleaning
the steering wheel or instrument panel to avoid contamination of
the airbag system.
If a staining liquid like coffee/juice has been spilled on the instrument
panel or on interior trim surfaces, clean as follows:
1. Wipe up spilled liquid using a clean white cotton cloth.
2. Apply Motorcraft Deluxe Leather and Vinyl Cleaner (ZC-11-A) [In
Canada use Motorcraft Multi-Purpose Cleaner (CXC-101)] to the wiped
area and spread around evenly.
3. Apply more Motorcraft cleaner to a clean white cotton cloth and press
the cloth onto the soiled area–allow this to set at room temperature for
30 minutes.
4. Remove the soaked cloth, and if it is not soiled badly, use this cloth to
clean the area by using a rubbing motion for 60 seconds.
5. Following this, wipe area dry with a clean white cotton cloth.
INTERIOR
For fabric, carpets, cloth seats, safety belts and seats equipped with side
airbags:
•Remove dust and loose dirt with a vacuum cleaner.
•Remove light stains and soil with Motorcraft Professional Strength
Carpet & Upholstery Cleaner (ZC-54).
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Cleaning
274

OPENING THE HOOD
1. Inside the vehicle, pull the hood
release handle located under the
bottom of the instrument panel near
the steering column.
2. Go to the front of the vehicle and
release the auxiliary latch that is
located under the front center of
the hood.
3. Lift the hood until the lift
cylinders hold it open.
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
278

IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT
3.5L V6 ENGINE
1. Power steering fluid reservoir
2. Engine coolant reservoir
3. Brake fluid reservoir
4. Battery
5. Power distribution box
6. Air filter assembly
7. Automatic transmission fluid dipstick
8. Engine oil dipstick
9. Engine oil filler cap
10. Windshield washer fluid reservoir
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
279

Readiness for Inspection/Maintenance (I/M) testing
Some state/provincial and local governments may have
Inspection/Maintenance (I/M) programs to inspect the emission control
equipment on your vehicle. Failure to pass this inspection could prevent
you from getting a vehicle registration. Your vehicle may not pass the I/M
test if the
indicator is on or not working properly (bulb is burned
out), or if the OBD-II system has determined that some of the emission
control systems have not been properly checked. In this case, the vehicle
is considered not ready for I/M testing.
If the
indicator is on or the bulb does not work, the vehicle may
need to be serviced. Refer to the On board diagnostics (OBD-II)
description in this chapter.
If the vehicle’s engine or transmission has just been serviced, or the
battery has recently run down or been replaced, the OBD-II system may
indicate that the vehicle is not ready for I/M testing. To determine if the
vehicle is ready for I/M testing, turn the ignition key to the ON position
for 15 seconds without cranking the engine. If the
indicator blinks
eight times, it means that the vehicle is not ready for I/M testing; if
the
indicator stays on solid, it means that the vehicle is ready for
I/M testing.
The OBD-II system is designed to check the emission control system
during normal driving. A complete check may take several days. If the
vehicle is not ready for I/M testing, the following driving cycle consisting
of mixed city and highway driving may be performed:
15 minutes of steady driving on an expressway/highway followed by 20
minutes of stop-and-go driving with at least four 30-second idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete. If
the vehicle is still not ready for I/M testing, the above driving cycle will
have to be repeated.
POWER STEERING FLUID
Refer to thescheduled maintenance informationfor the service
interval schedules.
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
301

1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge indicator will be
near the center of the normal area
between H and C).
2. While the engine idles, turn the
steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN
and MAX lines. Do not add fluid if the level is in this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the range between the MIN and MAX lines. Be
sure to put the cap back on the reservoir. Refer toMaintenance
product specifications and capacitiesin this chapter for the proper
fluid type.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the “MIN” and
“MAX” lines are within the normal
operating range; there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range the performance of the
system could be compromised; seek
service from your authorized dealer
immediately.
TRANSAXLE FLUID
Checking automatic transaxle fluid
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes.Your transaxle does not consume
fluid. However, the fluid level should be checked if the transaxle is not
working properly, i.e., if the transaxle slips or shifts slowly or if you
notice some sign of fluid leakage.
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
302

Items CapacityFord Part Name or
equivalentFord Part Number /
Ford Specification
Engine coolant11.1 quarts
(10.5L)Motorcraft Premium
Gold Engine Coolant
with bittering agent
(yellow-colored)
4
VC-7-B /
WSS-M97B51-A1
Power steering fluidBetween MAX and
MIN on reservoirMotorcraft MERCONV
AT FX T-5-QM /
MERCONV
Windshield washer fluidTop- off fluid as
neededMotorcraft Premium
Windshield Washer
ConcentrateZC-32-A /
WSB-M8B16-A2
Fuel tank20.5 gallons
(77.6L) AWD,
PZEV AWD and
PZEV FWD——
20.0 gallons
(75.7L) (FWD)
1Approximate dry fill capacity. Actual amount may vary during fluid changes.2Automatic transmissions that require MERCONV should only use MERCONV fluid or fluid that
is specified dual usage MERCON/MERCONV. Refer toscheduled maintenance informationto
determine the correct service interval. Use of any fluid other than the recommended fluid may
cause transmission damage.3Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C930-A and the API Certification mark.4Add the coolant type originally equipped in your vehicle.5See your authorized dealer for fluid level checking or filling.
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
308

Cleaning your vehicle
engine compartment ..............272
instrument panel ....................274
interior .....................................274
plastic parts ............................273
washing ....................................270
waxing .....................................271
wheels ......................................271
wiper blades ............................273
Climate control (see Air
conditioning or Heating) ......73, 75
Clock ............................................91
Clock adjust
6-CD in dash .............................28
AM/FM/CD .................................21
Compass, electronic
set zone adjustment ...............109
Console
overhead ....................................91
Controls
power seat ...............................140
steering column ......................100
Coolant
checking and adding ..............286
refill capacities ................290, 307
specifications ..........................307
Cruise control
(see Speed control) ....................97
Cupholder(s) .............................145
Customer Assistance ................237
Ford Extended Service
Plan ..........................................266
Getting assistance outside
the U.S. and Canada ..............267
Getting roadside assistance ...237
Getting the service you
need .........................................262
Ordering additional
owner’s literature ...................268Utilizing the Mediation/
Arbitration Program ...............266
D
Daytime running lamps
(see Lamps) ................................81
Dipstick
automatic transmission
fluid ..........................................302
engine oil .................................281
Driving under special
conditions ..........................232, 234
sand .........................................233
snow and ice ...........................235
through water .................233, 236
DVD system .................................43
E
Electronic message center .......107
Emergencies, roadside
jump-starting ..........................254
Emission control system ..........299
Engine ........................................309
cleaning ...................................272
coolant .....................................286
idle speed control ...................284
lubrication specifications .......307
refill capacities ........................307
service points ..........................279
starting after a collision .........239
Engine block heater .................218
Engine oil ..................................281
change oil soon warning,
message center .......................281
checking and adding ..............281
dipstick ....................................281
filter, specifications ........283, 306
recommendations ...................283
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
315

Power point .................................92
Power steering ..........................224
fluid, checking and adding ....301
fluid, refill capacity ................307
fluid, specifications .................307
Power Windows ...........................93
R
Radio ................................16, 20, 27
Rear seat entertainment
system ..........................................43
Relays ........................................239
Remote entry system .......124–125
illuminated entry ............128–129
locking/unlocking doors .........125
opening the trunk ...................126
panic alarm .............................126
replacement/additional
transmitters .............................128
replacing the batteries ...........127
Reverse sensing system ...........228
Roadside assistance ..................237
S
Safety Belt Maintenance ..........153
Safety belts (see
Safety restraints) ......145, 149–152
Safety Canopy ...................168, 170
Safety defects, reporting ..........269
Safety restraints ........145, 149–153
Belt-Minder...........................154
extension assembly ................153
for adults .........................150–152
for children .....................173–174
Occupant Classification
Sensor ......................................147safety belt maintenance .........153
warning light and chime ........154
Safety seats for children ..........177
Safety Compliance
Certification Label ....................310
Satellite Radio Information ........40
Seats ..........................................138
child safety seats ....................177
front seats ...............138, 140, 142
heated ........................................75
memory seat ...................126, 143
SecuriLock passive anti-theft
system ........................................132
Servicing your vehicle ..............277
Setting the clock
AM/FM single CD .....................21
AM/FM/In-dash 6 CD ................28
Spare tire
(see Changing the Tire) ...........250
Spark plugs,
specifications .....................306, 309
Specification chart,
lubricants ...................................307
Speed control ..............................97
Starting your vehicle ........215–217
jump starting ..........................254
Steering wheel
controls ....................................100
tilting .........................................90
T
Tilt steering wheel ......................90
Tire Pressure Monitoring
System (TPMS)
Roadside Emergencies ...........246
Tires, Wheels and Loading ....200
2008 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
318