2008 FORD FUSION (AMERICAS) transmission fluid

Low fluid level
Do not drive the vehicle if the fluid
level does not show at all on the
dipstick.
Driving the vehicle with less than
the recommended fluid level may result in transaxle failure. An under fill
condition of transmission fluid may cause shift and/or engagement
concerns and /or possible damage to the transaxle.
High fluid level
Fluid levels above the normal
operating range may result in
transaxle failure. An overfill
condition of transmission fluid may
cause shift and/or engagement
concerns and/or possible damage to
the transaxle.
High fluid levels can be caused by an overheating condition.
Adjusting automatic transmission fluid levels
Before adding any fluid, make sure the correct type is used. The type of
fluid used is normally indicated on the dipstick and also in the
Maintenance product specifications and capacitiessection in this
chapter.
Note:Only one ATF fluid specification has been tested and approved for
use with the automatic 6-speed: Premium Automatic Transmission fluid.
Mercon fluids cannot be used with the automatic 6-speed without
damage or voiding warranty.
Use of a non-approved automatic transmission fluid may cause
internal transaxle component damage.
If necessary, add fluid in 1/2 pint (250 mL) increments through the filler
tube until the level is correct.
If an overfill occurs, excess fluid should be removed by an authorized
dealer.
An overfill condition of transmission fluid may cause shift and/or
engagement concerns and/or possible damage.
Do not use supplemental transmission fluid additives, treatments or
cleaning agents. The use of these materials may affect transmission
operation and result in damage to internal transaxle components.
2008 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
283

Checking and adding manual transmission fluid (if equipped)
1. Park the vehicle on a level
surface.
2. Engage the parking brake fully –
put in first gear.
3. Ensure the vehicle cannot move.
4. Clean the filler plug.
5. Remove the filler plug and
inspect the fluid level.
6. Fluid level should be at bottom of
the opening.
7. Add enough fluid through the filler opening so that the fluid level is
within 3/8 inch (10mm) of the bottom of the filler hole with the vehicle
on a level surface.
8. Install and tighten the fill plug securely.
Use only fluid that meets Ford specifications. Refer to theMaintenance
product specifications and capacitiessection in this chapter.
AIR FILTER
Refer toscheduled maintenance informationfor the appropriate
intervals for changing the air filter element.
When changing the air filter element, use only the Motorcraft air filter
element listed. Refer toMotorcraft part numbersin this chapter.
To reduce the risk of vehicle damage and/or personal burn
injuries do not start your engine with the air cleaner removed
and do not remove it while the engine is running.
2008 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
284

Item Capacity Ford part nameFord part number /
Ford specification
Engine oil 2.3L engine4.5 quarts
(4.25L)Motorcraft SAE 5W-20
Premium Synthetic
Blend Motor Oil (US)
Motorcraft SAE 5W-20
Super Premium Motor
Oil (Canada)
2
XO-5W20-QSP (US)
CXO-5W20-LSP12
(Canada) /
WSS-M2C930-A with API
Certification Mark Engine oil 3.0Lengine 6.0 quarts (5.7L)
Lock cylinders —Motorcraft Penetrating
and Lock LubricantXL-1/
None
Power steering fluidBetween MIN
and MAX on
reservoirMotorcraft MERCONV
AT FXT-5-QM /
MERCONV
Manual transmission
fluid3.0 quarts
(2.87L)
3
Motorcraft 75W-90 gear
oil (non-synthetic)XY-75W90-Q GL /
WSS-M2C203-A1 and
GL-4
Automatic transmission
fluid 5-Speed7.0 quarts
(6.7L)
4
Motorcraft FNR5
Automatic Transmission
FluidXT-9-QMM5 /
MAZDA M5
Automatic transmission
fluid 6-Speed7.4 quarts
(7.0L)
4
Motorcraft Premium
Automatic Transmission
FluidXT-8-QAW /
WSS-M2C924-A
Rear Differential (AWD)
fluid2.4 pints (1.15L)Motorcraft SAE 80W-90
Premium Rear Axle
LubricantXY-80W90-QL /
WSP-M2C197-A
2008 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
289

Item Capacity Ford part nameFord part number /
Ford specification
Power Transfer Unit
(PTU) fluid (AWD)
5
12 ounces
(0.35L)Motorcraft SAE 75W-140
Synthetic Rear Axle
LubricantXY-75W140-QL /
WSL-M2C192-A
Windshield washer fluid4.75 quarts
(4.5L)Motorcraft Premium
Windshield Washer
ConcentrateZC-32-A /
WSB-M8B16-A2
Fuel tank17.5 gallons
(66.2L)——
Fuel Tank (AWD)16.5 gallons
(62.4L)——
1Add the coolant type originally equipped in your vehicle.2Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C930-A and the API Certification mark.3Service refill capacity is determined by filling the transmission within 3/8 inch (10mm) of the
bottom of the filler hole with the vehicle on a level surface.4Indicates only approximate dry-fill capacity. Some applications may vary based on cooler size and
if equipped with an in-tank cooler. The amount of transmission fluid and fluid level should be set
by the indication on the dipstick’s normal operating range.5The Power Transfer Unit is lubricated for life with synthetic lube. Lubricant levels are not to be
checked or changed unless a leak is suspected or repair required. Replace Power Transfer Unit
lubricant with specified synthetic lubricant anytime the unit is submerged in water.
See your authorized dealer for fluid level checking or filling of the Power Transfer Unit.
2008 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
290

A
Accessory delay ..........................74
Air cleaner filter ...............284–286
Air conditioning ....................48, 50
Airbag supplemental restraint
system ........................135, 144, 147
and child safety seats ............137
description ..............135, 144, 147
disposal ....................................150
driver airbag ............137, 145, 148
indicator light .........144, 146, 149
operation .................137, 145, 148
passenger airbag .....137, 145, 148
side airbag ...............................144
All Wheel Drive (AWD),
driving off road .........................206
Ambient mood/lighting ...............59
Antifreeze
(see Engine coolant) ................261
Anti-lock brake system
(see Brakes) ......................193–194
Anti-theft system ..............109, 112
arming the system ..................112
disarming a triggered
system .....................................113
triggering .................................113
Audio system
(see Radio) ......................17, 21, 29
Automatic transaxle
fluid, adding ............................279
fluid, checking ........................279
Automatic transmission
driving an automatic
overdrive .........................199–200
fluid, adding ....................281, 284
fluid, checking ................281, 284
fluid, refill capacities ..............288fluid, specification ..................288
Auxiliary input jack (Line in) ....37
Axle
lubricant specifications ..........288
B
Battery .......................................259
acid, treating emergencies .....259
jumping a disabled battery ....227
maintenance-free ....................259
replacement, specifications ...286
servicing ..................................259
Belt-Minder.............................130
Booster seats .............................151
Brakes ........................................193
anti-lock ...........................193–194
anti-lock brake system (ABS)
warning light ...........................194
fluid, checking and adding ....279
fluid, refill capacities ..............288
fluid, specifications .................288
lubricant specifications ..........288
parking ....................................194
shift interlock ..........................197
Break-in period .............................5
Bulbs ............................................59
C
Capacities for refilling fluids ....288
Cassette tape player ...................21
Cell phone use ..............................7
Changing a tire .........................221
Child safety restraints ..............151
child safety belts ....................151
Child safety seats ......................154
attaching with tether straps ..158
2008 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
296

in front seat ............................155
in rear seat ..............................155
Child safety seats - booster
seats ...........................................151
Cleaning your vehicle
engine compartment ..............243
instrument panel ....................245
interior .....................................246
plastic parts ............................244
washing ....................................241
waxing .....................................242
wheels ......................................242
wiper blades ............................245
Climate control (see Air
conditioning or Heating) ......48, 50
Clock ............................................72
Clock adjust
6-CD in dash .............................31
AM/FM/CD .................................23
Clutch
fluid ..........................................279
operation while driving ..........202
recommended shift speeds ....203
Compass, electronic
set zone adjustment .................86
Console ........................................71
overhead ....................................71
Controls
power seat ...............................117
steering column ........................79
Coolant
checking and adding ..............261
refill capacities ................265, 288
specifications ..........................288
Cruise control
(see Speed control) ....................76
Cupholder(s) .............................121
Customer Assistance ................212Ford Extended Service
Plan ..........................................237
Getting assistance outside the
U.S. and Canada .....................238
Getting roadside assistance ...212
Getting the service you
need .........................................233
Ordering additional owner’s
literature .................................239
Utilizing the
Mediation/Arbitration
Program ...................................237
D
Daytime running lamps
(see Lamps) ................................55
Dipstick
automatic transmission
fluid ..................................279, 281
engine oil .................................254
Driving under special
conditions ..................201, 207, 209
sand .........................................208
snow and ice ...........................210
through water .................208, 211
E
Electronic message center .........83
Emergencies, roadside
jump-starting ..........................227
Emission control system ..........275
Engine ........................................291
cleaning ...................................243
coolant .....................................261
fail-safe cooling .......................266
idle speed control ...................259
lubrication specifications .......288
refill capacities ........................288
service points ..................251–252
2008 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
297

lighting up panel and
interior .......................................56
J
Jack ............................................221
positioning ...............................221
storage .....................................221
Jump-starting your vehicle ......227
K
Keyless entry system ...............107
autolock .....................................96
keypad .....................................107
locking and unlocking doors ..108
programming entry code .......107
Keys .....................................93, 110
positions of the ignition .........188
L
Lamps
autolamp system .......................54
bulb replacement
specifications chart ..................59
daytime running light ...............55
fog lamps ...................................55
headlamps .................................54
headlamps, flash to pass ..........56
instrument panel, dimming .....56
interior lamps ...........................58
replacing bulbs .........................60
Lane change indicator
(see Turn signal) ........................58
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........194
Load limits .................................181
Locks
autolock .....................................96childproof ................................100
doors ..........................................95
Lubricant specifications ...........288
Lug nuts ....................................226
Lumbar support, seats .............115
M
Manual transmission .................202
fluid capacities ........................288
lubricant specifications ..........288
reverse .....................................203
Message center ...........................83
english/metric button ...............88
system check button ................87
warning messages .....................89
Mirrors ...................................75–76
automatic dimming rearview
mirror ........................................75
heated ........................................76
side view mirrors (power) .......76
Moon roof ....................................81
Motorcraft parts ........247, 267, 286
N
Navigation system .......................45
O
Octane rating ............................271
Oil (see Engine oil) ..................254
P
Parking brake ............................194
Parts (see Motorcraft parts) ....286
Passenger Occupant
Classification Sensor .................122
2008 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
299

Tire Pressure Monitoring
System (TPMS)
Tires, Wheels and Loading ....177
Tires ...........................162–163, 221
alignment ................................170
care ..........................................166
changing ..................................221
checking the pressure ............166
inflating ...................................164
label .........................................176
replacing ..................................168
rotating ....................................170
safety practices .......................169
sidewall information ...............171
snow tires and chains ............181
spare tire .................................221
terminology .............................163
tire grades ...............................163
treadwear ........................162, 167
Towing .......................................186
recreational towing .................186
trailer towing ..........................186
wrecker ....................................232
Traction control ........................195
Transaxle
fluid, checking and adding
(automatic) .............................279
fluid, checking and adding
(manual) .................................284
Transmission .............................197brake-shift interlock (BSI) ....197
fluid, refill capacities ..............288
lubricant specifications ..........288
manual operation ....................202
Trunk .........................................100
remote release ..................92, 104
Turn signal ..................................58
U
USB port ......................................38
V
Vehicle Identification Number
(VIN) ..........................................292
Vehicle loading ..........................181
Ventilating your vehicle ...........191
W
Warning lights (see Lights) .......10
Washer fluid ..............................253
Water, Driving through .............211
Windows
power .........................................73
Windshield washer fluid and
wipers ..........................................69
checking and adding fluid .....253
replacing wiper blades ...........253
Wrecker towing .........................232
2008 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
301