2008 FORD C MAX brake

Downloaded from www.Manualslib.com manuals search engine WARNINGS
Only add coolant when theengine is cold. If the engine ishot, wait 10 minutes for the engine tocool down.
Do not allow coolant to touchyour skin or eyes. If thishappens, rinse the affected areasimmediately with plenty of water andcontact your doctor.
CAUTION
Do not spill coolant on any partof the engine.
Only add coolant that meets the Fordspecification. See Technicalspecifications (page 204).
BRAKE AND CLUTCH
FLUID CHECK
WARNING
Do not allow brake fluid to touchyour skin or eyes. If thishappens, rinse the affected areasimmediately with plenty of water andcontact your doctor.
The brake and the clutch systemsare supplied from the same reservoir.
Make sure that the brake fluid levelis between the MIN and the MAXmarks.
POWER STEERING FLUID
CHECK
Vehicles with 1.4L Duratec-16V (Sigma) or 1.6LDuratec-16V (Sigma) or1.6L Duratec-16V Ti-VCT(Sigma) engine
The fluid level should come up to theMAX mark when the engine is cold.
202
MaintenanceE78897 E73701

Downloaded from www.Manualslib.com manuals search engine TECHNICAL SPECIFICATIONS
Vehicle fluids
SpecificationRecommended fluidItem
WSS-M2C913-B
Ford or MotorcraftFormula E SAE 5W-30
Engine Oil*Engine oil
WSS-M2C204-A2Ford or MotorcraftPower Steering FluidPower steering fluid
WSS-M97B44-DMotorcraft SuperPlusAntifreezeAntifreeze
ESD-M6C57-AFord or Motorcraft SuperDOT 4 Brake FluidBrake fluid
* You can use an alternative SAE 5W-30 engine oil, providing it meets the
specification defined by WSS-M2C913-B.
Note:If you operate your vehicle in temperatures below -20°C, you mustnot use SAE 10W-40 engine oil.
Topping up the oil: If you are unable to find an oil that meets thespecification defined by WSS-M2C913-B, you must use SAE 5W-30(preferred), SAE 5W-40 (except Flexfuel vehicles) or SAE 10W-40 thatmeets the specification defined by either ACEA A1/B1 (preferred) or ACEAA3/B3. Using these oils can result in longer engine cranking periods, reducedengine performance, reduced fuel economy and increased emission levels.
Capacities
Capacity in litres(gallons)ItemVariant
MAX-markPower assisted steeringfluidAll
55 (12.1)Fuel tankVehicles with a petrolengine
55 (12.1)Fuel tankVehicles with a dieselengine
204
Maintenance

Downloaded from www.Manualslib.com manuals search engine Removing a wheel
All vehicles
WARNINGS
Park your vehicle in such aposition that neither the trafficnor you are hindered or endangered.
Set up a warning triangle.
Make sure that the vehicle is onfirm, level ground with thewheels pointing straight ahead.
WARNINGS
Switch off the ignition and applythe parking brake.
If your vehicle has a manualtransmission, select first orreverse gear. If it has an automatictransmission, select park.
Have the passengers leave thevehicle.
Secure the diagonally oppositewheel with an appropriate blockor wheel chock.
Make sure that the arrows ondirectional tyres point in thedirection of rotation when the vehicleis moving forwards. If you have to fita spare wheel with the arrowspointing in the opposite direction,have the tyre refitted in the correctdirection by a properly trainedtechnician.
Do not work underneath thevehicle when it is supported onlyby a jack.
Make sure that the jack isvertical to the jacking point andthe base is flat on the ground.
CAUTION
Do not lay alloy wheels facedown on the ground, this willdamage the paint.
215
Wheels and tyresE92932 E93020

Downloaded from www.Manualslib.com manuals search engine •Keep the kit out of the reach ofchildren.
•Only use the kit when the ambienttemperature is between –30°C(-22°F) and +70°C (+158°F).
Using the tyre repair kit
WARNINGS
Compressed air can act as anexplosive or propellant.
Never leave the tyre repair kitunattended while in use.
CAUTION
Do not keep the compressoroperating for more than 10minutes.
Note:Use the tyre repair kit only forthe vehicle with which it was supplied.
•Park your vehicle at the roadsideso that you do not obstruct theflow of traffic and so that you areable to use the kit without beingin danger.
•Apply the parking brake, even ifyou have parked on a level road,to make sure that the vehicle willnot move.
•Do not attempt to remove foreignobjects like nails or screwspenetrating the tyre.
•Leave the engine running whilethe kit is in use, but not if thevehicle is in an enclosed or poorlyventilated area (for example,inside a building). In thesecircumstances, switch thecompressor on with the engineturned off.
•Replace the sealant bottle with anew one before the expiry date(see top of bottle) is reached.
•Inform all other users of thevehicle that the tyre has beentemporarily sealed with the tyrerepair kit and make them awareof the special driving conditions tobe observed.
Inflating the tyre
WARNINGS
Check the sidewall of the tyreprior to inflation. If there are anycracks, bumps or similar damage, donot attempt to inflate the tyre.
Do not stand directly beside thetyre while the compressor ispumping.
Watch the sidewall of the tyre.If any cracks, bumps or similardamage appear, turn off thecompressor and let the air out bymeans of the pressure relief valve B.Do not continue driving with this tyre.
The sealant contains naturalrubber latex. Avoid contact withskin and clothing. If this happens,rinse the affected areas immediatelywith plenty of water and contact yourdoctor.
218
Wheels and tyres

Downloaded from www.Manualslib.com manuals search engine ELECTROMAGNETIC
COMPATIBILITY
WARNINGS
Your vehicle has been testedand certified to Europeanlegislations relating toelectromagnetic compatibility(2004/104/EC). It is your responsibilityto ensure that any equipment youhave fitted complies with applicablelocal legislations. Have anyequipment fitted by properly trainedtechnicians.
WARNINGS
Radio frequency (RF) transmitterequipment (e.g. cellulartelephones, amateur radiotransmitters etc.) may only be fittedto your vehicle if they comply with theparameters shown in the table below.There are no special provisions orconditions for installations or use.
Do not mount any transceiver,microphones, speakers, or anyother item in the deployment path ofthe airbag system.
Do not fasten antenna cablesto original vehicle wiring, fuelpipes and brake pipes.
Keep antenna and powercables at least 100mm from anyelectronic modules and airbags.
262
AppendicesE8599867123845

Downloaded from www.Manualslib.com manuals search engine A
A/CSee: Climate control..........................107
About this handbook........................7ABSSee: Brakes.........................................158
ABS driving hintsSee: Hints on driving with ABS.........158
AccessoriesSee: Parts and accessories..................7
Adaptive front lighting system(AFS)...............................................68Adjusting the pedals.......................58Adjusting the steering wheel.........55Adjusting the windscreen washerjets...................................................62AFSSee: Adaptive front lighting system(AFS)..................................................68
Air conditioningSee: Climate control..........................107
Air vents..........................................107Alarm.................................................53Appendices...................................255Arming the alarm.............................53Automatic arming delay.....................53Interior sensors....................................53
Arming the engine immobiliser.....52ASLSee: Automatic speed limiter(ASL).................................................166
Audible warnings andindicators........................................94Automatic transmission......................94Electronic parking brake (EPB).........94Frost.......................................................94Key-in-ignition......................................94Key outside car....................................94Lights on................................................94Low fuel.................................................94Seat belt reminder...............................95
Audio control...................................55Mode.....................................................56Seek.......................................................56Volume..................................................56
Audio unit commands.................242CD Player/CD Changer....................242Radio...................................................244
Autolamps........................................65Automatic climate control.............111Air distribution......................................112Blower...................................................112Mono mode.........................................112Recirculated air...................................113Setting the temperature.....................111Switching off the automatic climatecontrol...............................................113Switching the air conditioning on andoff.......................................................113To switch mono mode back on.......112To switch mono mode off.................112Windscreen defrosting anddemisting..........................................113
Automatic speed limiter(ASL)..............................................166Principle of operation........................166
Automatic transmission................154Drive modes.......................................156Emergency park position releaselever..................................................156General information...........................154Hints on driving with an automatictransmission....................................156Selector lever positions.....................155
Auxiliary heater...............................114Auxiliary heater....................................116Fuel operated heater.........................116Programmable auxiliary heater........114
Auxiliary input (AUX IN)socket...........................................140Type 1...................................................140Type 2..................................................140
265
Index

Downloaded from www.Manualslib.com manuals search engine Auxiliary power sockets...............134Power inverter....................................134
B
Battery care...................................209Bluetooth setup............................233Compatibility of phones...................234Handling of phones...........................233Requirements for Bluetoothconnection.....................................233
Bonnet lockSee: Opening and closing thebonnet..............................................189
Booster cablesSee: Using booster cables..............209
Booster cushions............................23Booster cushion..................................23Booster seat.........................................23
Brake and clutch fluid check......202Brakes.............................................158Principle of operation........................158
Bulb changingSee: Changing a bulb..........................74
C
Car washSee: Cleaning the exterior...............207
Catalytic converter........................150Driving with a catalytic converter.....150Parking.................................................150
Centre console..............................135Front seat centre console................135Rear seat centre console.................136
Changing a bulb..............................74Approach lamps...................................78Central brake lamp...............................81Footwell lamp.......................................83Front fog lamps (Type 1).....................78Front fog lamps (Type 2)....................79Headlamps, side lamps, directionindicators...........................................74Interior and reading lamps..................81Luggage compartment lamp............82Number plate lamp..............................81Rear lamps............................................80Side repeater indicator on exteriormirrors................................................77Side repeaters......................................77Vanity mirror lamps..............................82
Changing a fuse.............................177Changing a road wheel.................211Fitting a wheel.....................................216Jacking and lifting points...................213Removing a wheel.............................215Spare wheel.........................................211Vehicle jack.........................................212
Changing the remote controlbattery............................................36Opening the container........................37Passive key...........................................36Reassembling the container..............39Remote control type 1........................36Replacing the battery.........................38
Changing the vehicle battery......210Vehicles with a petrol engine...........210
Changing the wiper blades...........63Rear window wiper blades................63Windscreen wiper blades..................63
Checking the wiper blades...........63Childminder mirror.........................140Child safety......................................20Child safety locks............................26Child seat positioning......................21
266
Index

Downloaded from www.Manualslib.com manuals search engine Engine coolant check...................201Topping up the coolant.....................201
Engine heater.................................148Engine immobiliser..........................52Principle of operation..........................52
Engine number....................................Engine oil check............................200Checking the oil level........................200Topping up..........................................201
Engine oil dipstick................................Exterior mirrors................................85Convex mirrors....................................85Folding mirrors.....................................86
F
Fastening the seat belts.................31First aid kit.......................................174Foot pedalsSee: Adjusting the pedals..................58
Front fog lamps...............................65Fuel and refuelling.........................149Technical specifications....................152
Fuel burning heaterSee: Auxiliary heater...........................114
Fuel consumptionSee: .....................................................152
Fuel consumption..........................151Fuel cut-off switch.........................175Vehicles with a Duratec engine........175
Fuel filler flap....................................151Fuel quality............................................Fuse box locations........................176Auxiliary fuse box................................176Central fuse box.................................177
Fuse labels......................................177Fuses...............................................176Fuse specification chart................179Engine junction box...........................179Passenger junction box.....................181
G
Gauges.............................................88Engine coolant temperaturegauge.................................................90Fuel gauge............................................90
GearboxSee: Transmission..............................154
General information on radiofrequencies....................................35Glasses holder...............................139Global opening and closing...........50Global closing.......................................50Global opening.....................................50
H
HandbrakeSee: Parking brake............................159
Hazard warning flashers................70Headlamp levelling..........................66Headlamp washers........................62Head restraints...............................121Adjusting the head restraint..............121Removing the head restraint...........122
Heated seats.................................132Heated windows and mirrors......114Heated exterior mirrors.....................114Heated windows.................................114
HeatingSee: Climate control..........................107
Hints on driving with ABS.............158Horn..................................................55
I
Ignition switch.................................141Ignition switch positions.....................141
ImmobiliserSee: Engine immobiliser.....................52
Information displays........................96General information.............................96
268
Index