2008 FIAT LINEA transmission

100
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
TRANSCEIVERS
AND MOBILE PHONES
Radio transceiver equipment (e.g.: e-tacs
mobile phones, HAM radio systems and
the like) shall not be used inside the car
unless a separate aerial is mounted on the
roof.
IMPORTANT The use of similar devices
inside the passenger compartment (with-
out separated aerial) produces radio-fre-
quency electromagnetic fields which, am-
plified by the resonance effects inside the
passenger compartment, may cause elec-
trical systems equipping the car to mal-
function. This could compromise safety in
addition to constituting a potential hazard
for the passengers.
In addition, transmission and reception of
these devices may be affected by the
shielding effect of the car body.
As concerns EC-approved mobile phones
(GSM, GPRS, UMTS), strictly comply with
the instructions for use provided by the
mobile phone’s manufacturer.ACCESSORIES
PURCHASED BY THE
OWNER
If after buying the car, you decide to install
electrical accessories that require a per-
manent electric supply (alarm, satellite an-
titheft system, etc.) or accessories that in
any case burden the electric supply, con-
tact Fiat Dealership, whose qualified per-
sonnel, besides suggesting the most suit-
able devices belonging to Lineaccessori Fi-
at, will also evaluate the overall electric ab-
sorption, checking whether the car’s elec-
tric system is able to withstand the load
required, or whether it needs to be inte-
grated with a more powerful battery.
Be very careful when fitting
non-standard additional
spoilers, light alloy wheels or wheel
cups: they could reduce brake venti-
lation and consequently brake effi-
ciency in the case of repeated, violent
braking or on long downhill roads.
Make sure that nothing obstructs the
pedal stroke (mats, etc.)
WARNING
ELECTRICAL/ELECTRONIC
DEVICE INSTALLATION
Electrical and electronic devices installed
after buying the car by after-market ser-
vice must carry the following label:
Fiat Auto S.p.A. authorises the installation
of transceiving devices provided that they
are installed according to rules of good en-
gineering practice respecting the manu-
facturer’s indications by a specialised cen-
tre.
IMPORTANT Traffic police may not allow
the car on the road in the event of as-
sembly of devices which imply modifica-
tions to the features of the car. This may
also cause lapse of warranty in relation to
faults caused by the change or either di-
rectly or indirectly related to it.
Fiat Auto S.p.A. shall not be liable for dam-
age caused by the installation of acces-
sories either not supplied or recom-
mended by Fiat Auto S.p.A. and/or in-
stalled in compliance with the provided in-
structions.
091-102 LINEA 1ed GB 3-09-2008 17:29 Pagina 100

183
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
DEMANDING USE
OF THE CAR
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
❒trailer or caravan towing;
❒dusty roads;
❒short distances (less than 7-8 km) re-
peated and with external temperatures
below zero;
❒frequently idling engines or long dis-
tance low speed driving (e.g. taxis or
door-to-door deliveries) or in case of
a long term inactivity;
❒in cities;
perform the following inspections more
frequently than shown on the Service
Schedule:
❒check front disk brake pad conditions
and wear;
❒check cleanness of locks, bonnet and
boot and lever cleanness and lubrica-
tion;
❒visually inspect the conditions of: en-
gine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
❒check battery charge and liquid level
(electrolyte) (see paragraph “Charge
level check” in chapter “Maintenance
and care”);
❒visually inspect the accessory drive belt
conditions;
❒check pollen filter and replace, if re-
quired;
❒check air cleaner and replace, if re-
quired.
REGULAR
INSPECTIONS
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒brake fluid level;
❒tyre pressure and conditions.
❒operation of lights (headlights, direction
indicators, hazard lights, etc.);
❒operation of the windscreen wiper/
washer system, position and wear of
the windscreen and rear window wiper
blades;
Every 3,000 km check the following and
top-up, if required:engine oil level.
You are recommended to use FL
Seleniaproducts, designed and produced
specifically for Fiat cars (see table “Ca-
pacities” in section “Technical specifica-
tions”).
177-200 LINEA 1ed GB 3-09-2008 17:31 Pagina 183

201
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IDENTIFICATION DATA ................................................. 202
ENGINE CODES - BODYWORK VERSIONS............... 204
ENGINE .................................................................................. 205
FUEL FEED/IGNITION ....................................................... 206
TRANSMISSION .................................................................. 207
BRAKES................................................................................... 207
SUSPENSIONS....................................................................... 208
STEERING............................................................................... 208
WHEELS.................................................................................. 209
DIMENSIONS......................................................................... 213
PERFORMANCE................................................................... 214
WEIGHTS............................................................................... 215
CAPACITIES........................................................................... 216
FLUIDS AND LUBRICANTS.............................................. 217
FUEL CONSUMPTION....................................................... 219
CO
2EMISSIONS .................................................................. 221
TT T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
201-221 LINEA 1ed GB 5-09-2008 9:24 Pagina 201

207
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
TRANSMISSION
1.4 - 1.4 T-JET- 1.6 - 1.8 -1.3 Multijet 1.6 Multijet
Gearbox Five forward gears plus reverse Six forward gears plus reverse with synchronisers for forward gears with synchronisers for forward gears
Clutch Self-adjusting with pedal without idle stroke Self-adjusting with pedal without idle stroke
Drive Front Front
BRAKES
1.4 - 1.4 T-JET - 1.6 - 1.8 - 1.3 Multijet - 1.6 Multijet
Service brakes:
– front
– rear
Parking brake
IMPORTANT Water, ice and salt sprinkled on the roads may deposit on the brake disks reducing braking efficiency
the first time the brakes are applied.controlled by hand lever, operating on rear brakesdrum / disk (T-JET version and 1.6 Multijet) disk
201-221 LINEA 1ed GB 5-09-2008 9:24 Pagina 207

218
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Lubricants and
greases
for transmission
Use Fluid and lubricant specifications Original fluids and Applications
for correct car operation lubricants
(*) IMPORTANT Do not top up or mix with fluids having characteristics different from those specified.
When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU UP and demineralised water. LSynthetic-based oils, grade SAE 75W- 85.
Qualification FIAT 9.55550-MX3
Synthetic-based oil, grade SAE 75W-85.
Qualification FIAT 9.55550-MX3
Lubricant for automatic transmissions.
QualificationFIAT 9.55550-AG1.
NLGI 1-2 consistency.
Grease containing Molybdenum bisulphide for high
temperature appliances. Qualification FIAT 9.55580
N.L.G.I. 1-2 consistency
Specifc grease to be used for constant-velocity joints with
low friction coefficient. Qualification FIAT 9.55580
N.L.G.I. 0-1 consistency.
Synthetic fluid FMVSS no. 116 DOT 4, ISO 4925
SAE J1704, CUNA NC 956- 01.
QualificationFIAT 9.55597
Protective with antifreeze action, red colour
based on inhibited monoethylen glycol and organic formula,
that passes CUNA NC 956-16, ASTM D 3306 specifications.
Qualification FIAT 9.55523
Additive for diesel fuels with protective action
for Diesel engines.
Mixture of alcohol, water and surfactants CUNA NC 956-II.
Qualification FIAT 9.55522TUTELA CAR
MATRIX
Contractual Technical
Reference N° F108.F02
TUTELA CAR
TECHNYX
Contractual Technical
Reference N° F010.B05
TUTELA GI/A
Contractual Technical
Reference N° F002.B92
TUTELA ALL STAR
Contractual Technical
Reference N° F702.G07
TUTELA STAR 700
Contractual Technical
Reference N° F701.C07
TUTELA TOP 4
Contractual Technical
Reference N° F001.A93
PARAFLU UP
Contractual Technical
Reference N° F101.M01
TUTELA DIESEL ART
Contractual Technical
Reference N°F601.L06
TUTELA PROFES-
SIONAL SC 35
Contractual Technical
Reference N° F201.D02Mechanical gearbox and
differential (1.3 Multijet
Dualogic and 1.6 Multijet
versions)
Mechanical gearbox
and differential
(petrol and 1.3 Multijet
versions)
Hydraulic power
steering
CV joints
on wheel side
CV joints on differential
side
Brake and clutch
hydraulic controls
Radiator antifreeze
proportion: 50% water and
50% PARAFLU UP
To be mixed with diesel fuel
(25 cc per 10 litres)
To be used diluted or
undiluted in windscreen/
rear window washer/
wiper systems
Brake fluids
Protective agent for
radiators
Windscreen/ rear
window washer fluid
Fuel additivel
201-221 LINEA 1ed GB 5-09-2008 9:24 Pagina 218

225
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Towing trailers
– tow hook installation ................... 129
Transmission ........................................ 207
Trip computer ..................................... 42
Tyres
– replacing a wheel ........................... 147
– maintenance .................................. 193
– reading tyre markings .................. 209
– standard tyres................................ 211
– cold tyre inflation pressure ........ 212
Using the manual gearbox .............. 126
Ventilation .......................................... 49
Warning lights and messages ......... 133
Weights ................................................ 215
Wheel..................................................... 206
– replacing a wheel ..................147-155
– spare wheel ................................... 211
– wheel geometry ............................ 209
Wheel rims
– understanding rim marking ........ 210
Window washing................................. 68
Window winders................................. 83
Windscreen/rear window/
headlight washer fluid level ............ 200Windscreen/rear window
wiper blades ...................................... 194
Windscreen washer
– control ............................................ 68
– fluid level ........................................ 187
Windscreen wiper
– blades .............................................. 194
– control ............................................ 68
– spray nozzles ................................. 195 Spark plugs
– type ................................................. 205
Speedometer ....................................... 16
Starting and driving ............................ 121
Starting the engine
– bump starting ................................ 147
– diesel engines ................................ 123
– emergency start-up ...................... 146
– ignition switch ............................... 13
– jump starting .................................. 146
– petrol engines ............................... 122
– stopping the engine....................... 124
– warm up the engine after
just started.......................................... 124
Steering.................................................. 208
Steering column lock ......................... 13
Steering wheel ..................................... 47
Sunroof.................................................. 74
Sun visors ............................................. 81
Suspensions .......................................... 208
Symbols ................................................. 6
Tailgate ................................................ 86
Technical specifications ..................... 201
Third brake light ................................. 164
Top speeds ........................................... 214
Towing the car .................................... 175
222-232 LINEA 1ed GB 9-09-2008 14:25 Pagina 225