2008 FIAT GRANDE PUNTO headlight

189
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
30 60 90 120 150 180
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●● ●
●●●●● ●
●●●●● ●
●●
●●
●
●●●●● ●
●● ●
SERVICE SCHEDULE FOR PETROL ENGINES
Service coupons shall be performed every 30,000 km
Thousands of km
Check tyre conditions/wear and adjust pressure if required
Check light system operation (headlights, direction indicators,
hazard lights, boot lights, passenger compartment lights,
instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check front disk brake pad conditions and wear
Check rear drum brake linings and wear
Sight inspect the conditions of: bodywork,
underbody protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of locks, bonnet and boot and lever
cleanness and lubrication
Check tension and adjust accessory drive belts
(versions 1.2 - 1.4 with heater)
Sight inspect accessory drive belt conditions
Replace accessory drive belt/s
Check and adjust handbrake lever stroke, if required
Check and adjust tappet clearance, if required
(excluding 1.4 16Vversion)
187-208 Punto GDX GB 31-07-2008 17:28 Pagina 189

191
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
30 60 90 120 150 180
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●●
SERVICE SCHEDULE FOR MULTIJET ENGINES
Service coupons shall be performed every 30,000 km
Thousands of km
Check tyre conditions/wear and adjust pressure if required
Check light system operation (headlights, direction indicators,
hazard lights, boot lights, passenger compartment lights,
instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check the position/wear of the windscreen/rearscreen wiper blades
Check condition and wear of front disc brake pads andbrake
pad wear indication
Check rear disc brake pad seal condition and wear
Check rear drum brake linings and wear
(1.3 Multijet versions)
Sight inspect the conditions of: bodywork, underbody protection,
pipes and hoses (exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of locks, bonnet and boot and lever
cleanness and lubrication
Check and top up, if required, fluid levels (engine coolant,
brake/hydraulic clutch fluid, windscreen washer fluid,
battery fluid, etc)
Check and adjust handbrake lever stroke, if required
Check exhaust emissions/smoke
Sight inspect accessory drive belt conditions
187-208 Punto GDX GB 31-07-2008 17:28 Pagina 191

207
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Normal paint maintenance consists in
washing at intervals depending on the con-
ditions and environment of use. For exam-
ple, in highly polluted areas, or if the roads
are sprayed with salt, it is wise to wash the
car more frequently.
To correctly wash the car:
❒ remove the aerial from the roof to pre-
vent damage to it if the car is washed in
an automatic system;
❒ wash the body using a low pressure jet
of water;
❒ wipe a sponge with a slightly soapy so-
lution over the bodywork, frequently
rinsing with the sponge;
❒ rinse well with water and dry with a jet
of air or a chamois leather.
When drying, take particular care with the
less visible parts like door surrounds, bon-
net and around the headlights where wa-
ter may stagnate. The car should not be
taken to a closed area immediately, but left
in the open so that residual water can
evaporate.Do not wash the car after it has been left
in the sun or with the bonnet hot: this may
alter the shine of the paintwork.
Exterior plastic parts must be cleaned in
the same way as the rest of the car.
Where possible, do not park under trees;
the resinous substance many species re-
lease give the paint a dull appearance and
increase the possibility of triggering rust
processes.
IMPORTANT Bird droppings must be
washed off immediately and thoroughly as
the acid they contain is particularly ag-
gressive.
Detergents cause water pollu-
tion. Therefore the engine
compartment should be
washed in areas equipped for
collecting and purifying the liquid used
in the washing process.
Windows
Use specific window cleaner products.
Use also clean cloths to avoid scratching
the glass or damaging the transparency.
IMPORTANT The inside of the
rearscreen should be wiped gently with a
cloth in the direction of the filaments to
avoid damaging the heating device.
Engine compartment
At the end of the winter the engine com-
partment should be carefully washed,
without directing the jet against electron-
ic control units. Contact a specialised
workshop to have this done.
IMPORTANT The car should be washed
with the engine cold and the ignition key
at STOP. After washing make sure that
the various protections (e.g. rubber caps
and various covers) have not been dam-
aged or removed.
Front headlights
IMPORTANT Never use aromatic sub-
stances (e.g.: petrol) or ketones (e.g.: ace-
tone) for cleaning front headlight plastic
lens.
187-208 Punto GDX GB 31-07-2008 17:28 Pagina 207

Specified fuels and
original lubricants
Unleaded petrol with
no less than 95 R.O.N.
(EN 228 Specification)
Diesel fuel for motor
vehicles
(EN590 Specification)
Mixture of 50% water
and PARAFLU UP (
❒)
SELENIA K P.E.
SELENIA WR
TUTELA CAR
TECHNYX (
▲)
TUTELA CAR
MATRYX (
❍)
TUTELA TOP 4
Mixture of water and
TUTELA
PROFESSIONAL
SC 35
225
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.3
Multijet
75 HP
–
–
45
5 ÷ 7
7.3
–
–
3.0
3.2
1.7 (
▲)
(*)
0.5
2.2
4.5 1.4
45
5 ÷ 7
–
–
5.27
2.4
2.6
–
–
1.5 (▲)
0.5
2.2
4.5 1.2
45
5 ÷ 7
–
–
5.27
2.4
2.6
–
–
1.5 (▲)
0.5
2.2
4.5
1.3
Multijet
90 HP
–
–
45
5 ÷ 7
7.4
–
–
3.0
3.2
2.0 (
❍)
(**)
0.5
2.2
4.5
1.6
Multijet
120 HP
–
–
45
5 ÷ 7
5.7
–
–
4.3
4.6
2.0 (
❍)
0.5
2.2
4.5
1.416V
45
5 ÷ 7
–
–
5.27
2.75
2.9
–
–
1.65 (
▲)
0.5
2.2
4.5
1.4
T-JET
45
5 ÷ 7
–
–
6.0
2.75
3.3
–
–
1.7 (
▲)
0.5
2,2
4,5
CAPACITIES
Fuel tank: litres
including a reserve of: litres
Fuel tank: litres
including a reserve of: litres
Engine cooling system:litres
Engine sump: litres
Engine sump and filter: litres
Engine sump: litres
Engine sump and filter: litres
Gearbox/differential
casing kg:
Hydraulic brake circuit: kg
Windscreen, rear window
andheadlight washer litres
fluid reservoir: litres
(*) Valve also valid for 1.3 Multijet 90 HP version with 5-gear transmission.
(**) Version with 6-speed gearbox
(
❒) When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU UP
and demineralised water.
209-229 Punto GDX GB 6-08-2008 10:11 Pagina 225

231
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Doors..................................................... 77
Door puddle lights
– side bulb replacement ................. 174
Engine
– identification code ........................ 212
– marking ........................................... 211
– specifications ................................. 213
Engine compartment
– washing ........................................... 197
Engine coolant fluid level ..................200
Engine cooling gauge........................... 16
Engine oil
– consumption .................................. 197
– checking fluid level ....................... 194
– specifications ................................. 228
EOBD system ...................................... 94
ESP system............................................ 91
Exterior lights ...................................... 58
Fiat CODE system............................. 7
Fix & Go automatic ............................ 161
Flashing the headlights ....................... 58Fluid levels ............................................ 194
Fluids and lubricants ........................... 228
Follow me home (device) ................. 59
Front courtesy lights
– bulb replacement........................... 169
– control ............................................ 65
Front fog lights
– bulb replacement .......................... 170
– control button .............................. 68
Fuel
– consumption................................... 228
– cut-off switch.................................. 70
– level gauge ....................................... 16
Fuel cut-off switch............................... 70
Fuel filler cap ....................................... 106
Fuel level gauge ................................... 16
Fuses (if a fuse blows) ........................ 175
Gearbox
– using manual gearbox .................. 132
Glass/can holder.................................. 73
Glove compartment............................ 72 Control buttons .................................. 68
Correct use of the car ...................... 127
Cruise Control
(Constant speed regulator) ........... 63
Courtesy light
– bulb replacement .......................... 174
– control button .............................. 67
Dashboard
– Left hand drive version ............... 5
– Right hand drive version ............. 6
Dashboard and controls..................... 5
Dead lock device................................. 78
Digital display ....................................... 17
Dimensions .......................................... 221
Dipped headlamps
– bulb replacement........................... 169
– control ............................................ 58
Direction indicators
– control ............................................ 59
– front bulb replacement ............... 169
– rear bulb replacement ................. 170
– side bulb replacement ................. 170
230-240 Punto GDX GB 8-08-2008 9:20 Pagina 231

232
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Interiors ................................................ 208
Isofix (child seat) ................................. 120
Jack ........................................................ 156
Jacking the car ..................................... 184
Key with remote control ................ 8
Key without remote control ...........11
Keys ........................................................ 8
Load limiters ...................................... 112
Main beam headlamps
– bulb replacement .......................... 169
– control ............................................ 58
– blinks ............................................... 58
Manual climate control system ........ 45
Multifunctional display........................ 22
Number plate light ............................ 172
Oddment compartments.................. 71
Paint ..................................................... 206
Parking .................................................. 131Parking sensors.................................... 100
Performance ........................................ 222
Plates
– bodywork paintwork ................... 211
– identification data ......................... 210
Pollen filter ........................................... 200
Power point ......................................... 74
Power steering .............................69-95
Power windows ........................... 80
Pretensioners ...................................... 112
Protecting the environment ............. 107
Radio .................................................... 102
Radio transmitters and mobile
telephones ......................................... 104
Rain sensor............................................ 61
Rear courtesy lights
– bulb replacement........................... 173
– control ............................................ 66
Rear doors emergency lock device ... 79
Rear fog lights
– bulb replacement .......................... 171
– control button .............................. 69
Handbrake .......................................... 131
Hands free system with
voice recognition and
Bluetooth
®technology..................... 103
Hazard warning lights ........................ 68
Headrest
– front ................................................ 38
– rear................................................... 38
Headlight washer
– control ............................................ 62
– fluid level ........................................ 199
Headlights.............................................. 88
– light beam alignment..................... 88
– headlamp alignment corrector .. 88
Heated rear window .........44-49-57-69
Heating and ventilation ...................... 41
Identification data .............................. 210
Ignition switch ..................................... 12
In an emergency .................................. 153
Instrument panel ................................. 13
Instruments .......................................... 15
Interior fittings .................................... 71
230-240 Punto GDX GB 8-08-2008 9:20 Pagina 232

234
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Windscreen washer
– control ............................................ 60
– fluid level ........................................ 199
Windscreen wiper
– brushes ........................................... 204
– control ............................................ 60
– sprays .............................................. 205 – maintenance .................................. 203
– standard .......................................... 219
– correct tyre reading .................... 217
Using the manual gearbox .............. 132
Vehicle inactivity................................. 138
Ventilation ............................................ 43
Warning lights and messages ......... 139
Weights ................................................ 225
Wheel
– changing .......................................... 155
– spare wheel ................................... 221
Wheel geometry ................................. 217
Wheel rims
– reading rim marking ..................... 218
Window (cleaning) ............................. 207
Window winders................................. 80
Windscreen/rear window/headlight
washer fluid level ............................. 200
Windscreen/rear window
Wiper blades ....................................... 206
230-240 Punto GDX GB 8-08-2008 9:20 Pagina 234