2008 FIAT BRAVO transmission

93
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
INSTALLATION OF
ELECTRIC/ELECTRONIC
DEVICES
Electric/electronic devices installed after
buying the car and in after-market shall
bear the following marking:IMPORTANT The installation of devices
involving modifications of car character-
istics may determine the withdrawal of the
driving licence by the appointed public au-
thorities and the forfeiture of the warranty
as concerns defects/failures due to said
modification or leading directly or indi-
rectly to it.
Fiat Auto S.p.A. declines all responsibility
due to damages connected with the in-
stallation of accessories/devices not sup-
plied by or recommended by Fiat Auto
S.p.A. and installed not in compliance with
the specified prescriptions.RADIO TRANSMITTERS AND
CELLULAR TELEPHONES
Radio transceiver equipment (e.g.: e-tacs
mobile phones, HAM radio systems and
the like) shall not be used inside the car
unless a separate aerial is mounted on the
roof.
IMPORTANT The use of similar devices
inside the passenger compartment (with-
out separated aerial) produces radio-fre-
quency electromagnetic fields which, am-
plified by the resonance effects inside the
passenger compartment, may cause elec-
trical systems equipping the car to mal-
function. This could compromise safety in
addition to constituting a potential hazard
for the passengers.
In addition, transmission and reception of
these devices may be affected by the
shielding effect of the car body.
As concerns -approved mobile phones
(GSM, GPRS, UMTS), strictly comply with
the instructions for use provided by the
mobile phone’s manufacturer.
Fiat Auto S.p.A. authorizes the installation
of transceivers, provided that installation
is workmanlike performed in compliance
with Manufacturer’s specifications at a spe-
cialised service centre.
083-104 BRAVO GB 29-10-2008 12:37 Pagina 93

197
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
ROUTINE
MAINTENANCE
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre pressure and conditions;
❒light system operation (headlights, di-
rection indicators, hazard lights, etc.);
❒windscreen wiper/washer operation
and windscreen/rear window blade
position/wear;
Every 3,000 km check and top up if re-
quired: engine oil level.
You are recommended to use FL Sele-
nia, products, designed and produced
specifically for Fiat cars (see table “Ca-
pacities” in section “Technical specifica-
tions”).
HEAVY-DUTY
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
❒trailer or caravan towing;
❒dusty roads;
❒short distances (less than 7-8 km) re-
peated and with external tempera-
tures below zero;
❒frequently idling engines or long dis-
tance low speed driving (e.g. door-to-
door deliveries) or in case of a long
term inactivity;
❒driving in the city;
carry out the following checks more fre-
quently than required in the Service
Schedule:
❒check front disk brake pad conditions
and wear;
❒check cleanness of locks, bonnet and
boot and lever cleanness and lubrica-
tion;
❒sight inspect the conditions of: engine,
gearbox, transmission, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.);
❒check battery charge and fluid level
(electrolyte) (only to be carried out by
skilled personnel or at Fiat Dealership
– see also paragraph “Battery” in this
section);
❒visual check on various drive belt con-
ditions;
❒check and replace pollen filter, if re-
quired;
❒check and replace air cleaner, if re-
quired.
191-212 BRAVO GB 29-10-2008 12:33 Pagina 197

213
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
IDENTIFICATION DATA ................................................. 214
ENGINE CODES - BODYWORK VERSIONS .............. 216
ENGINE .................................................................................. 217
FUEL FEED/IGNITION ....................................................... 219
TRANSMISSION .................................................................. 219
BRAKES................................................................................... 220
SUSPENSIONS....................................................................... 220
STEERING............................................................................... 220
WHEELS.................................................................................. 221
DIMENSIONS......................................................................... 225
PERFORMANCE................................................................... 226
WEIGHTS............................................................................... 227
CAPACITIES .......................................................................... 228
FLUIDS AND LUBRICANTS.............................................. 229
FUEL CONSUMPTION....................................................... 231
CO
2EMISSIONS .................................................................. 232
RADIO FREQUENCY REMOTE CONTROL:
MINISTERIAL HOMOLOGATION ................................. 233
TT T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
213-237 BRAVO GB 30-10-2008 9:22 Pagina 213

219
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
Modifications or repairs to the fuel system that are not carried out properly or do not take the system’s techni-
cal specifications into account can cause malfunctions leading to the risk of fire.
Six forward gears
and reverse
with synchromesh for
forward gear
engagement
Self-adjusting pedal
without idle
stroke
FrontFive forward gears
and reverse
with synchromesh for
forward gear
engagement
Self-adjusting pedal
without idle
stroke
Front
FUEL FEED/IGNITION
1.4 16V1.4 T-JET 1.6 Multijet - 1.9 Multijet 8V1.9 Multijet 16V - 2.0 Multijet
Fuel feed Multipoint sequential Multipoint sequential phased Direct injection with
phased electronic injection electronic injection with electronically controlled
returnless system turbosupercharger Multijet “Common Rail”
and intercooler turbosupercharger
and intercooler
TRANSMISSION
1.4 16V- 1.4 T-JET - 1.6 Multijet - 1.9 Multijet 16V- 2.0 Multijet1.9 Multijet 8V
Gearbox
Clutch
Drive
213-237 BRAVO GB 30-10-2008 9:22 Pagina 219

Windscreen/
rear window/
headlight
washer fluid Protective
agent
for radiatorsSynthetic-based oil, grade SAE 75W-85
that passes API GL-4 PLUS specifications.
Qualification FIAT 9.55550-MX3.
Synthetic-based oil, grade SAE 75W-85
that passes API GL-4 specifications.
Qualification FIAT 9.55550-MZ1
Specifc grease to be used for constant-velocity joints with
low friction coefficient. N.L.G.I. 0-1 consistency.
Qualification FIAT 9.55580.
Grease containing Molybdenum bisulphide for high
temperature appliances. N.L.G.I. 1-2 consistency.
Qualification FIAT 9.55580.
Synthetic fluid for brake and clutch system. Exceeds specifications:
FMVSS no. 116 DOT 4, ISO 4925, SAE J 1704.
Qualification FIAT 9.55597.
Protective with antifreeze action, red colour
based on inhibited monoethylen glycol and organic formula,
that passes CUNA NC 956-16, ASTM D 3306 specifications.
Qualification FIAT 9.55523.
Additive for diesel fuels with protective action for Diesel engines.
Mixture of alcohol and surfactants.
That passes CUNA NC 956-11.
Qualification FIAT 9.55522. Brake
fluid
230
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
DASHBOARD
AND CONTROLSMechanic gearboxes
and differentials
Mechanical gearbox
and differential
(1.4 T-JET versions)
CV joints
on differential side
CV joints on wheel side
Hydraulic brakes and clutch
hydraulic controls
Radiator antifreeze
proportion:
50% water and
50% PARAFLU
UP(❑)
To be used diluted
or undiluted
To be mixed with diesel fuel
(25 cc per 10 litres)
TUTELA CAR
TECHNYX
Contractual Technical
Reference N° F010.B05
TUTELA CAR
MATRYX
Contractual Technical
Reference N°F108.F02
TUTELA
STAR 700
Contractual Technical
Reference N°F701.C07
TUTELA ALL STAR
Contractual Technical
Reference N°F702.G07
TUTELA TOP 4
Contractual Technical
Reference N°F001.A93
PARAFLU
UP(●)
Contractual Technical
Reference N°F101.M01
TUTELA
DIESEL ART
Contractual Technical
Reference N°F601.L06
TUTELA
PROFESSIONALSC 35
Contractual Technical
Reference N° F201.D02 Fuel additivel Lubricants
and greases for
transmissions
Use Fluid and lubricant specifications Genuine fluids Applicationsfor correct car operation and lubricants
(●) IMPORTANT Do not add or mix fluids having different specifications from that already existing.
(❑) For particularly hard climate conditions, we recommend use of a 60% PARAFLUUPand 40% demineralized water mixture.
213-237 BRAVO GB 30-10-2008 9:22 Pagina 230

240
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Spray nozzles ....................................... 207
Steering ................................................. 220
Steering column lock ......................... 19
Steering wheel ..................................... 40
Sun roof ................................................ 72
Sun visors ............................................. 71
Suspensions .......................................... 220
Symbols ................................................. 8
T.P.M.S. system................................... 96
Technical specifications .............. 220
Third brake light
(bulb replacement) .......................... 174
Towing the car .................................... 189
Towing trailers .................................... 137
Transmission ........................................ 219
Trip Computer .................................. 35
Tyres
– replacement ................................... 157
– snow tyres ..................................... 139
– standard tyres ............................... 223
– tyre marking .................................. 221
– pressure........................................... 224
Using the gearbox ............................. 134
Isofix child restraint system .............117
Warning lights and messages... 141
Weights ................................................ 227
Wheel geometry ................................. 221
Wheels and tyres .......................206-221
When needing to change a bulb ...... 167
Window washing ................................ 57
Windows (cleaning) ........................... 210 Reconfigurable Multifunction
display ................................................. 23
Remote control: ministerial
homologations .................................. 233
Right hand drive versions............ 235
Rim marking ......................................... 221
Roof rack/ski rack .............................. 84
Rubber hoses ....................................... 207
Safe lock device ................................. 14
S.B.R system ........................................ 108
Safety devices.................................. 105
Seat belts .............................................. 106
Seats ...................................................... 37
– cleaning ........................................... 211
– manual adjustment ....................... 37
– electrical adjustment .................... 38
– seat warming ................................. 38
Side lights
– activation ........................................ 55
– bulbs replacement ...............171-172
Smart washing function ..................... 58
Snow chains ......................................... 139
Sound System ...................................... 92
Spark plugs ........................................... 217
Sport function ..................................... 95
238-244 BRAVO GB 29-10-2008 12:37 Pagina 240