2008 FIAT BRAVO spark plugs

104
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
During normal service the
catalyst and the diesel par-
ticulate filter (DPF) reach high tem-
peratures. Do not therefore park the
car over inflammable materials (grass,
dry leaves, pine needles, etc.): fire
hazard.
WARNING
Diesel Particulate Filter clogged
If the warning light hon the instru-
ment panel turns on (together with the
message on the display) refer to section
“Warning lights and messages”. DIESEL PARTICULATE FILTER
(DPF) (where provided)
The Diesel Particulate Filter is a mechan-
ical filter, integral with the exhaust system,
that physically traps particulate present
in the exhaust gases of Diesel engines.
The diesel particular filter has been adopt-
ed to eliminate almost totally particulates
in compliance with current / future law
regulations.
During normal use of the car, the engine
control unit records a set of data (e.g.:
travel time, type of route, temperatures,
etc.) and it will then calculate how much
particulates has been trapped by the filter.
Since this filter physically traps particulates,
it shall be cleaned (reclaimed) at regular
intervals by burning carbon particles. Re-
claiming procedure is controlled auto-
matically by the engine control unit ac-
cording to the filter conditions and the
conditions of use of the car.
During reclaiming the following phenom-
ena could take place: idling slight increase,
fan activation, slight smoke increase, high
exhaust temperatures. These situations
shall not be considered as faults and they
do not affect car performance and envi-
ronment.PROTECTING THE
ENVIRONMENT
The devices for curtailing petrol engine
emissions are the following:
❒three-way catalytic converter;
❒Lambda sensor;
❒fuel evaporation system.
In addition, do not let the engine run, even
for a test, with one or more spark plugs
disconnected.
The devices for curtailing diesel fuel en-
gine emissions are the following:
❒oxidising catalytic converter;
❒exhaust gas recirculation system
(E.G.R.);
❒Lambda sensors;
❒diesel particulate filter (DPF) (where
provided it is fitted instead of the Lamb-
da sensor).
083-104 BRAVO GB 29-10-2008 12:37 Pagina 104

194
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
Thousands of km
Check exhaust emissions (petrol versions)
Check emissions/fumes (1.9 Multijet 8V - 1.9 Multijet 16V versions)
Check operation of engine control systems
(by means of test interface)
Replace accessory drive belt/s
Replace toothed timing belt (petrol versions) (*)
Replace toothed timing belt (1.9 Multijet 8Vversions) (*)
Replace toothed timing belt (1.9 Multijet 16Vversions) (*)
Replace spark plugs (petrol versions)
Replace fuel filter (1.9 Multijet 8V - 1.9 Multijet 16V versions)
Replace air filter cartridge (petrol versions)
Replace air filter cartridge (1.9 Multijet 8V - 1.9 Multijet 16V versions)
Replace engine oil and oil filter (petrol versions)
(or every 24 months)
Change engine oil and oil filter (
1.9 Multijet 8V - 1.9 Multijet 16V
versionswithout DPF) (or every 24 months)
Change engine oil and oil filter
(1.9 Multijet 8V - 1.9 Multijet 16V versionswith DPF) (**)
Change brake fluidr (or every 24 months)
Change pollen filter (or every 15 months)
(*) Irrespective of mileage, the timing drive belt must be replace every 4 years for heavy duty applications, cold climates, town use, long
periods idling) or at least every 5 years.
(**) The engine oil and oil filter should be changed depending on their actual condition, which is indicated by a warning light/message on the control panel or at
least every 2 years.
For 1.4 T-JET versions, in order to ensure correct operation and avoid significant damages to the engine, it is mandatory:
- to use spark plugs specifically certified for the T-JET engine only, of the same type and brand (see paragraph “Engine”);
- to replace the plugs as often as required by the Programmed Maintenance Plan;
- we recommend to refer to the Fiat Dealership.
If the car is used mainly on urban routes or if the yearly kilometres travelled are less than 10,000 km, the engine oil and filter must be changed every 12 months.
30 60 90 120 150 180
●● ● ●● ●
●● ● ●● ●
●● ● ●● ●
●
●
●
●
●● ● ●● ●
●●●
●●●
●●●
●● ● ●● ●
●● ● ●● ●
●●●
●●●
●●●●●●
191-212 BRAVO GB 29-10-2008 12:33 Pagina 194

217
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
1.4 16V
192B2000
Otto
4 in line
72.0 x 84,0
1368
11
66
90
5500
128
13
4500
NGK
DCPR7E-N-10
Unleaded petrol
95 RON
(Specification
EN228)
1.4 T-JET
120 HP
198A4000
Otto
4 in line
72.0 x 84.0
1368
9.8
88
120
5000
206
21
1750
NGK IKR9F8
Unleaded petrol
95 RON
(Specification
EN228)
1.4 T-JET
150 HP
198A1000
Otto
4 in line
72.0 x 84.0
1368
9.8
110
150
5500
206
21
2250
NGK IKR9F8
Unleaded petrol
95 RON
(Specification
EN228)
1.6 Multijet105 HP
198A3000
Diesel
4 in line
79.5 x 80.5
1598
16.5
77
105
4000
290
29.5
1500
_
Diesel fuel for
motor vehicles
(Specification
EN590)
1.6 Multijet120 HP
198A2000
Diesel
4
in line
79.5 x 80.5
1598
16.5
88
120
4000
300
30.6
1500
_
Diesel fuel for
motor vehicles
(Specification
EN590)
1.6 Multijet90 HP(●)
198A6000
Diesel
4 in line
79.5 x 80.5
1598
16.5
66
90
4000
290
29.5
1500
_
Diesel fuel for
motor vehicles
(Specification
EN590)
ENGINE
GENERAL
Engine code
Cycle
Number and layout of cylinders
Piston bore and stroke mm
Total displacement cm3
Compression ratio
Maximum power (EEC) kW
HP
corresponding ratio rpm
Maximum torque (EEC) Nm
kgm
corresponding ratio rpm
Spark plugs
Fuel
(●)Versions for specific markets
213-237 BRAVO GB 30-10-2008 9:22 Pagina 217

2.0
Multijet
198A5000
Diesel
4 in line
83.0 x 90.4
1956
16.5
121
165
4000
360
36.7
1750
–
Diesel fuel for
motor vehicles
(Specification
EN590)
218
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS2.0
Multijet (●)
844A2000
Diesel
4 in line
83.0 x 90.4
1956
16.5
121
163
4000
360
36.7
1750
–
Diesel fuel for
motor vehicles
(Specification
EN590)
GENERAL
Engine code
Cycle
Number and layout of cylinders
Piston bore and stroke mm
Total displacement cm3
Compression ratio
Maximum power (EEC) kW
HP
corresponding ratio rpm
Maximum torque (EEC) Nm
kgm
corresponding ratio rpm
Spark plugs
Fuel
(●)Versions for specific markets
(*) For versions/markets where applicable
1.9
Multijet 8V (*)
192A8000
Diesel
4 in line
82.0 x 90.4
1910
18
88
120
4000
255
26
2000
–
Diesel fuel for
motor vehicles
(Specification
EN590)
1.9 Multijet 16V (*)
937A5000
Diesel
4 in line
82.0 x 90.4
1910
17,5
110
150
4000
305
31
2000
–
Diesel fuel for
motor vehicles
(Specification
EN590)
1.9 Multijet 8V (●)(*)
192B4000
Diesel
4 in line
82.0 x 90.4
1910
18
85
115
4000
255
26
2000
–
Diesel fuel for
motor vehicles
(Specification
EN590)
1.9 Multijet 8V (●)(*)
192B5000
Diesel
4 in line
82.0 x 90.4
1910
18
66
90
4000
255
26
2000
–
Diesel fuel for
motor vehicles
(Specification
EN590)
213-237 BRAVO GB 30-10-2008 9:22 Pagina 218

240
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Spray nozzles ....................................... 207
Steering ................................................. 220
Steering column lock ......................... 19
Steering wheel ..................................... 40
Sun roof ................................................ 72
Sun visors ............................................. 71
Suspensions .......................................... 220
Symbols ................................................. 8
T.P.M.S. system................................... 96
Technical specifications .............. 220
Third brake light
(bulb replacement) .......................... 174
Towing the car .................................... 189
Towing trailers .................................... 137
Transmission ........................................ 219
Trip Computer .................................. 35
Tyres
– replacement ................................... 157
– snow tyres ..................................... 139
– standard tyres ............................... 223
– tyre marking .................................. 221
– pressure........................................... 224
Using the gearbox ............................. 134
Isofix child restraint system .............117
Warning lights and messages... 141
Weights ................................................ 227
Wheel geometry ................................. 221
Wheels and tyres .......................206-221
When needing to change a bulb ...... 167
Window washing ................................ 57
Windows (cleaning) ........................... 210 Reconfigurable Multifunction
display ................................................. 23
Remote control: ministerial
homologations .................................. 233
Right hand drive versions............ 235
Rim marking ......................................... 221
Roof rack/ski rack .............................. 84
Rubber hoses ....................................... 207
Safe lock device ................................. 14
S.B.R system ........................................ 108
Safety devices.................................. 105
Seat belts .............................................. 106
Seats ...................................................... 37
– cleaning ........................................... 211
– manual adjustment ....................... 37
– electrical adjustment .................... 38
– seat warming ................................. 38
Side lights
– activation ........................................ 55
– bulbs replacement ...............171-172
Smart washing function ..................... 58
Snow chains ......................................... 139
Sound System ...................................... 92
Spark plugs ........................................... 217
Sport function ..................................... 95
238-244 BRAVO GB 29-10-2008 12:37 Pagina 240