2008 DODGE SPRINTER fuel reserve

22 At a glanceInstrument cluster
1
Function
Page
c
Fuel gauge with:\4
Reserve fuel warning
lamp
\4
Fuel filler flap location
indicatorÖ
: Fuel filler flap is
on the left-
hand side
145
475
iVehicles without steering wheel
buttons:
Display
8
contains a digital fuel
gauge.
Vehicles with steering wheel but-
tons*:
The tachometer contains an analog
fuel gauge.
Indicator and Warning Lamps
Page
v
ESP
® warning lamp
72
468
ASR warning lamp
73
74
465
/
Coolant level too low
474
D
Coolant temperature
too high
475
1
Restraint systems
malfunction
469
nf_BA.book Page 22 Friday, January 25, 2008 3:53 PM

23 At a glance
Instrument cluster
1
Brake fluid level too
low
463
EBV malfunction
462
Malfunction in trailer's
brake booster
464
N
Engine oil level warning
as47
1
±
Engine diagnostic
indicator lamp
477
q
Pre-glow system, die-
sel engine only
186
476
Turn signal, left
135
Indicator and Warning Lamps
Page
Indicator and warning lamps
Page
X
Combination low tire
pressure/TPMS mal-
function telltale, USA
only
478
Low tire pressure tell-
tale, Canada only
478
J
Windshield washer/
headlamp cleaning sys-
tem* washer fluid level
too low
482
Door open
483
2
Brake pads / linings
worn
470
Turn signal, right
135
-
ABS malfunction
466
k
ASR malfunction
465
BAS malfunction
465
#
ESP
® malfunction
468
‰
Air cleaner dirty
477
A
Reserve fuel
475
Fuel filler flap open
476
Indicator and warning lamps
Page
nf_BA.book Page 23 Friday, January 25, 2008 3:53 PM

146 Controls in detailInstrument cluster
3
Resetting the trip meter
\1
Vehicles with steering wheel but-
tons*: Make sure that the display is
showing the trip meter
(\2
page 157).
\1
Keep reset button
0 pressed until
the trip meter is set to
0.0
.
Fuel gauge1
Vehicles without steering wheel
buttons
2
Vehicles with steering wheel but-
tons*
3
Fuel filler flap location indicatorÖ
: The fuel filler cap is on the
left-hand side
4
Reserve fuel warning lamp
(\2
page 475)
Trip meter
nf_BA.book Page 146 Friday, January 25, 2008 3:53 PM

437 Practical hints
What to do if ...
5
Problem
Possible cause / result
Suggested solutions
The engine does not start.
You can hear the starter motor working.
There may be a malfunction in the fuel supply.
\1
Turn the key back to position
0 in the igni-
tion lock before the next starting attempt.
\1Start the engine again.
Note that excessively long attempts to
start the engine may drain the battery.
If the engine still will not start after several
starting attempts:
\1Consult an authorized Sprinter Dealer.
Vehicles with a diesel engine:
The engine does not start.
You can hear the starter motor working. The
reserve fuel warning lamp is lit and the fuel
gauge is at 0.
The fuel tank has been run dry.
\1Refuel the vehicle.
\1Bleed the fuel system (\2page 544).
nf_BA.book Page 437 Friday, January 25, 2008 3:53 PM

475 Practical hints
What to do if ...
5
•
The red coolant warning
lamp lights up while the en-
gine is running.
The coolant temperature is too high.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
If the vehicle is switched off after being sub-
jected to extreme loads (for example driving
in mountainous terrain, trailer towing, etc.),
the coolant warning lamp may light up when
the ignition is switched on or the engine is
restarted. Run the engine for approximately
1 minute at idling speed.
Consult an authorized Sprinter Dealer if the
coolant warning lamp remains lit.
A
The yellow reserve fuel
warning lamp lights up while
the vehicle is in motion.
The fuel level has fallen into the reserve range.
\1Refuel at the nearest refueling station
(\2page 316).
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 475 Friday, January 25, 2008 3:53 PM

476 Practical hintsWhat to do if ...
5
A
The yellow reserve fuel
warning lamp lights up while
the engine is running and
the gauge for the fuel tank
shows zero although there is
still fuel in the tank.
The fuel filler cap is not closed.
\1Close the fuel filler cap. A clicking
sound indicates that the fuel filler cap is
closed.
\1If the malfunction continues to be indi-
cated, have it rectified immediately at
an authorized Sprinter Dealer.
q
The yellow preglow indicator
lamp lights up while the en-
gine is running.
There is a malfunction in the preglow system.
\1Consult an authorized Sprinter Dealer.
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 476 Friday, January 25, 2008 3:53 PM

511 Practical hints
Display messages
5
W
Reserve fuel
Drive to a
gas station
The fuel level has fallen into the reserve
range.
\1Refuel at the nearest gas station
(\2page 316).
Tank open
Check

filler cap
The fuel filler cap is not closed.
\1Close the fuel filler cap. A clicking sound in-
dicates that the fuel filler cap is closed.
\1If the malfunction continues to be indicat-
ed, have it rectified immediately at an au-
thorized Sprinter Dealer.
9
Doors open
You are already driving at walking pace, even
though not all the doors are closed.
\1Close the doors.
Hood open
You are already driving at walking pace, even
though the hood is not closed.
\1Close the hood.
Display symbol
Display message
Possible cause / result
Possible solution
nf_BA.book Page 511 Friday, January 25, 2008 3:53 PM

621 *Technical data
Service products and capacities
6
CapacitiesVehicle
Engine with
oil filter
Tank
Cooling
system
Windshield washer /
headlamp cleaning
system
Engine oil
Capacity
Including
reserve fuel
Coolant
1
1 Whenever the coolant is replaced, a concentration of 50% by volume of corrosion inhibitor/antifreeze should be maintained. This provides antifreeze pro-
tection down to -34,6 °F (-37 °C). Do not exceed a concentration of 55% by volume (antifreeze protection down to approximately -49 °F (-45 °C)), as the
heat dissipation properties deteriorate at higher concentrations. Observe the Mercedes-Benz Specifications for Service Products, Sheet 325.
Water with MB windshield
washer fluid
2500 CRD, 3500 CRD
13.21 US qt.
(12.5 l)
25.0 US gal
(100 l)
2
2 Including a reserve of 5.3 US gal (20 l).
5.3 US gal
(20 l)
10.75 US qt.
(10.0 l)
approx. 7.40 US qt. (7.0 l)
2500, 3500
10.04 US qt.
(9.5 l)
25.0 US gal
(100 l)
2
5.3 US gal
(20 l)
7.40 US qt.
(7.0 l)
approx. 7.40 US qt. (7.0 l)
nf_BA.book Page 621 Friday, January 25, 2008 3:53 PM