2008 DODGE SPRINTER coolant

410 OperationMaintenance and servicing
4
Mechanical elements and the lubricants
used for them must be carefully
matched.
For this reason, only brands tested and
approved by the manufacturer should be
used. Please contact your Sprinter Deal-
er to obtain the necessary information.
No lubricant additives should be used.
The use of such additives could affect
your warranty rights. Information is
available from any authorized Sprinter
Dealer.For specifications of engine oils, coolant
and brake fluid, see "Service products
and capacities" (
\2
page 604) and con-
tact your authorized Sprinter Dealer.
Observe the information on spare parts
in the “Technical data” section
(
\2
page 600).
Warning (Continued)
G
The manufacturer recommends that you
use an authorized Sprinter Dealer for this
purpose. In particular, work relevant to
safety or on safety-related systems must
be carried out at an authorized Sprinter
Dealer.
Service products
Warning
G
If handled incorrectly, service products
can constitute a health risk for people and
an environmental hazard.
Always observe relevant guidelines for
handling, storing and disposing of service
products.
nf_BA.book Page 410 Friday, January 25, 2008 3:53 PM

439 Practical hints
What to do if ...
5
The coolant temperature gauge is above
250°F (+120°C).
The coolant is too hot and the engine is not be-
ing sufficiently cooled.
\1Park your vehicle in a safe location as
quickly as possible and let the engine
continue to run at idle speed for about
1 to 2 minutes before switching it off.
This allows the coolant temperature to
return to normal again.
If the coolant temperature is still too high:
\1Switch off the engine and let it as well
as the coolant cool down.
\1Check the coolant level and observe the
warning notes as you do so
(\2page 329).
\1Add coolant as necessary.
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 439 Friday, January 25, 2008 3:53 PM

455 Practical hints
What to do if ...
5
The auxiliary heating does not switch on or the
engine does not start
WARNING
G
The auxiliary heating has overheated about ten
times in succession.
The engine or heater is malfunctioning.
\1Have the auxiliary heating checked at
an authorized Sprinter Dealer.
The heater has overheated.
The coolant level is too low.
\1Check the coolant level and add coolant
if necessary (\2page 329).
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 455 Friday, January 25, 2008 3:53 PM

474 Practical hintsWhat to do if ...
5
/

The yellow coolant level
warning lamp lights up while
the engine is running.
The coolant level is too low.
Never run the engine if the coolant level is too low.
The engine could overheat and be damaged.
\1Stop at the earliest opportunity.
\1Switch off the engine to cool down.
\1Check the coolant level and add coolant
as necessary (\2page 329).
\1If you are having to add coolant fre-
quently, have the cooling system
checked at an authorized Sprinter Deal-
er.
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 474 Friday, January 25, 2008 3:53 PM

475 Practical hints
What to do if ...
5
•
The red coolant warning
lamp lights up while the en-
gine is running.
The coolant temperature is too high.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
If the vehicle is switched off after being sub-
jected to extreme loads (for example driving
in mountainous terrain, trailer towing, etc.),
the coolant warning lamp may light up when
the ignition is switched on or the engine is
restarted. Run the engine for approximately
1 minute at idling speed.
Consult an authorized Sprinter Dealer if the
coolant warning lamp remains lit.
A
The yellow reserve fuel
warning lamp lights up while
the vehicle is in motion.
The fuel level has fallen into the reserve range.
\1Refuel at the nearest refueling station
(\2page 316).
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 475 Friday, January 25, 2008 3:53 PM

502 Practical hintsDisplay messages
5
Z
Coolant
Stop, turn engine
off
The coolant temperature is too high.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
If the vehicle is switched off after being
subjected to extreme loads (for example driving
in mountainous terrain, trailer towing, etc.), this
message may be displayed when the ignition is
switched on or the engine is restarted. Run the
engine for approximately 1 minute at idling
speed.
Consult an authorized Sprinter Dealer if the
message remains displayed.
H
Coolant
Check level
The coolant level is too low.
Never run the engine if the coolant level is
too low. The engine could overheat and be
damaged.
\1Add coolant (\2page 329).
\1If you are having to add coolant frequently,
have the cooling system checked at an au-
thorized Sprinter Dealer.
Display symbol
Display message
Possible cause / result
Possible solution
nf_BA.book Page 502 Friday, January 25, 2008 3:53 PM

604 *Technical dataService products and capacities
6
\3 Service products and capacitiesService products are:\4
fuels
\4
lubricants (e.g. engine oils, transmis-
sion oils, hydraulic fluids, greases)
\4
antifreeze additives, coolant
\4
brake fluid
Service products are tested for suitabili-
ty in our assemblies. Approved service
products meet the highest quality stan-
dards and are listed in the
Mercedes-
Benz Specifications for Service Pro-
ducts
. For this reason, only use service
products that have been approved for
your vehicle. This is an important condi-
tion for warranty claims to be upheld. In-formation about approved service
products is available from all authorized
Sprinter Dealers.
You will find details about windshield
washer fluid in the “Operation” section
(
\2
page 333).
It is neither necessary nor permissible to
mix special additives with approved ser-
vice products (except for approved fuel
additives). Therefore, special additives
must not be mixed with fuels or lubri-
cants. The properties of the service
products could be adversely affected by
special additives and result in damage to
the assemblies.The vehicle operator is responsible at all
times for any use of special additives.
The use of special additives may result in
a limitation or an invalidation of your
warranty entitlement.
nf_BA.book Page 604 Friday, January 25, 2008 3:53 PM

616 *Technical dataService products and capacities
6
Coolants, lubricants, etc.
Service interval
Product name/product number
MB sheet
MS-No.
1
Air conditioningThe air conditioning system of your vehicle contains R-134a, a refrigerant that does not deplete the ozone layer in the upper
atmosphere.Refrigerant R-134a
—
Refrigerant R-134a
361.0
Automatic transmissionAutomatic transmission fluid
60,000 mi
(96,000 km)
MOPAR
® 05127382AB
Shell ATF 3403
Shell ATF 3353
236.10
236.12
nf_BA.book Page 616 Friday, January 25, 2008 3:53 PM