2008 DODGE SPRINTER brake fluid

422 OperationCleaning and care of the vehicle
4
Headlamps
\1
Wipe the headlamp lenses with a
damp sponge.
Parktronic sensors* The sensors are located in the front and
rear bumpers.\1
Clean the sensors in the bumpers us-
ing water, shampoo and a soft cloth.
Rear view camera lens* The rear view camera is located in the
center of the roof above the third brake
lamp.
!
CAUTION
Only use washer fluid which is suit-
able for plastic lamp lenses.
Unsuitable washer fluid may damage
the plastic headlamp lenses.
For this reason, do not use a dry
cloth, abrasive material, solvent or
solvent-based cleaning agent. You
could otherwise scratch or damage
the lens surface.
1 Parktronic sensors
!
CAUTION
D o n o t u s e d r y , c o a r s e o r h a r d c l o t h s
and do not scrub. You will otherwise
scratch or damage the sensors.
If you clean the sensors with a high-
pressure cleaner or steam cleaner,
observe the information provided by
the manufacturer regarding the dis-
tance to be maintained between the
vehicle and the nozzle of the high-
pressure cleaner.
nf_BA.book Page 422 Friday, January 25, 2008 3:53 PM

463 Practical hints
What to do if ...
5
6
The red brake system indicator
lamp is lit while the engine is run-
ning.
A signal also sounds.
WARNING
G
There is insufficient brake fluid in the fluid res-
ervoir.
\1Also observe the messages in the dis-
play on vehicles with steering wheel
buttons (\2page 489).
\1Do not add brake fluid under any cir-
cumstances. This will not solve the
problem.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 463 Friday, January 25, 2008 3:53 PM

498 Practical hintsDisplay messages
5
6
Brake force
distribution
WARNING
G
EBV has been deactivated due to undervolt-
age.
The battery may not be being charged.
The rear wheels could lock up sooner than
expected when you apply the brakes.
\1Stop your vehicle as soon as it is safe to do
so.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
6
Brake fluid
Visit
workshop
WARNING
G
There is insufficient brake fluid in the fluid
reservoir.
\1Stop your vehicle as soon as it is safe to do
so.
\1Do not add brake fluid under any circum-
stances. This will not solve the problem.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer. .
Display symbol
Display message
Possible cause / result
Possible solution
nf_BA.book Page 498 Friday, January 25, 2008 3:53 PM

604 *Technical dataService products and capacities
6
\3 Service products and capacitiesService products are:\4
fuels
\4
lubricants (e.g. engine oils, transmis-
sion oils, hydraulic fluids, greases)
\4
antifreeze additives, coolant
\4
brake fluid
Service products are tested for suitabili-
ty in our assemblies. Approved service
products meet the highest quality stan-
dards and are listed in the
Mercedes-
Benz Specifications for Service Pro-
ducts
. For this reason, only use service
products that have been approved for
your vehicle. This is an important condi-
tion for warranty claims to be upheld. In-formation about approved service
products is available from all authorized
Sprinter Dealers.
You will find details about windshield
washer fluid in the “Operation” section
(
\2
page 333).
It is neither necessary nor permissible to
mix special additives with approved ser-
vice products (except for approved fuel
additives). Therefore, special additives
must not be mixed with fuels or lubri-
cants. The properties of the service
products could be adversely affected by
special additives and result in damage to
the assemblies.The vehicle operator is responsible at all
times for any use of special additives.
The use of special additives may result in
a limitation or an invalidation of your
warranty entitlement.
nf_BA.book Page 604 Friday, January 25, 2008 3:53 PM

605 *Technical data
Service products and capacities
6
Warning
G
Failure to use fluids and lubricants which
meet the standards and specifications de-
scribed in this booklet or failure to adhere
to the specified replacement intervals
may result in damage to safety/ and/or
emissions-related systems of your vehi-
cle, such as the brake system, which
could cause an accident and/or serious
injury to you and others.
Use only fluids and lubricants meeting the
standards and specifications and adhere
to specified replacement intervals.
!
CAUTION
Damage caused by the use of non-ap-
proved service products is not cov-
ered by the Sprinter vehicle warranty.
Warning
G
Service products constitute a health haz-
ard. They contain toxic and highly corro-
sive constituents.For this reason, bear the following points
in mi n d t o avo i d i nj ur y to y o ur s el f a nd ot h -
ers:
Continued
Warning (Continued)
G
Do not inhale fumes. Make sure that en-
closed spaces are adequately ventilated
to prevent poisoning.Service products must not come into con-
tact with the skin, eyes or clothing. If con-
tact is made with a service product, clean
the affected areas of skin with water and
soap to prevent burns and other injuries.Rinse thoroughly with plenty of water in
case of contact with eyes. Consult a doc-
tor immediately if a service product is
swallowed.

Continued
nf_BA.book Page 605 Friday, January 25, 2008 3:53 PM

617 *Technical data
Service products and capacities
6
BrakesUse brake fluid approved for Chrysler Vans LLC standard MB 331.0 and/or Chrysler Vans LLC material standard MS-9971, brake
fluid certified to DOT 4 Plus standards, that also maintains a minimum dry boiling point (ERBP) of 500 °F (260 °C), a minimum wet
boiling point (WERBP) of 356 °F (180 °C) and a maximum viscosity of 1500 mm
2/s, conforming to FMVSS 116 and ISO 4925.
Brake fluid
2 years
2
Intac B026E Dry boiling point: 500°F
(260°C)
Wet boiling point: 356°F
(180°C)
MOPAR
® MS-9971 Part No. 04549625AC or
equivalent
331.0
9971
1 Chrysler Vans LLC Material Standard-No.
2 Over the course of a brake fluid’s service life, its boiling point falls due to the continuous absorption of moisture from the atmosphere. If the boiling point
of the brake fluid is too low, vapor pockets may form in the brake system when the brakes are applied hard (e.g. when driving on long downhill stretches).
This has a detrimental effect on braking efficiency, which could increase the stopping distance. This increases the risk of an accident. Have the brake fluid
renewed every 2 years.
Service interval
Product name/product number
MB sheet
MS-No.
1
nf_BA.book Page 617 Friday, January 25, 2008 3:53 PM

638 IndexAlarmaudible . . . . . . . . . . . . . . . . . . . . 431Anticorrosion/antifreeze fluid
. . . . 618
Antilock Brake System (ABS)
. . . . 70
display message . . . . . . . . 491–492
indicator lamp . . . . . . . . . . 462,466
malfunction . . . . . . . . . . . . 466–467
Anti-theft alarm system (ATA)
. . . 77
malfunction . . . . . . . . . . . . . . . . 431
switching off the alarm . . . . . . . . 78
Anti-theft systemimmobilizer . . . . . . . . . . . . . . . . . 77
see Anti-theft alarm
system (ATA)Aquaplaningsee HydroplaningArmrest
. . . . . . . . . . . . . . . . . . . . 120
Ashtray
. . . . . . . . . . . . . . . . . . . . 294
Aspect ratio
. . . . . . . . . . . . . . . . . 394
ASRsee Acceleration skid controlASSYST
. . . . . . . . . . . . . . . . . . . . . 411
calling up the due date
vehicles with steering wheel
buttons . . . . . . . . . . . . . . . . . . 413
vehicles without steering wheel but-
tons . . . . . . . . . . . . . . . . . . . . 414
Attaching lashing straps
. . . . . . 280
Attaching locking rods
. . . . . . . . 280
Audible alarm
. . . . . . . . . . . . . . . 431
Automatic car wash
. . . . . . . . . . 418
headlamps . . . . . . . . . . . . . . . . . 333
windshield . . . . . . . . . . . . . . . . . 333
Automatic headlamp control
. . . 132
Automatic locking
. . . . . . . . . . . 106
entire vehicle . . . . . . . . . . . . . . . 107
rear doors . . . . . . . . . . . . . . . . . 108
Automatic transmission
. . . . . . 201
accelerator pedal position . . . . . 205
changing gear yourself . . . . . . . 203
driving tips . . . . . . . . . . . . . . . . . 205
fluid . . . . . . . . . . . . . . . . . . . . . . 616
gearshift pattern . . . . . . . . . . . . 201
kickdown . . . . . . . . . . . . . . . . . . 206
malfunctions . . . . . . . . . . . . . . . 440
maneuvering . . . . . . . . . . . . . . . 206
one-touch gearshifting . . . . . . . . 203
releasing the parking lock
manually . . . . . . . . . . . . . . . . . . 524
selector lever positions . . . . . . . 202
shift ranges . . . . . . . . . . . . . . . . 204
nf_BA.book Page 638 Friday, January 25, 2008 3:53 PM

639 Index
stopping . . . . . . . . . . . . . . . . . . . 206
towing . . . . . . . . . . . . . . . . . . . . 587
trailer towing . . . . . . . . . . . . . . . 207
working on the vehicle . . . . . . . . 207Auxiliary heating
. . . . . . . . . . . . . 236
heater booster function . . . . . . . 234
malfunctions . . . . . . . . . . . . . . . 453
with water heater
changing the remote control
batteries . . . . . . . . . . . . . . . . . 541
remote control . . . . . . . . . . . . 239
selecting a switch-on time . . . 240
setting the switch-on time . . . 242
B
Bar
. . . . . . . . . . . . . . . . . . . . . . . . 394
BASsee Brake AssistBatteryauxiliary . . . . . . . . . . . . . . . . . . . 577
charge indicator lamp . . . . . . . . 469
check lamp (auxiliary heating
remote control) . . . . . . . . . . . . . 240
display message . . . . . . . . . . . . 497
in the auxiliary heating remote
control . . . . . . . . . . . . . . . . . . . . 541
in the engine compartment . . . . 577
in the key . . . . . . . . . . . . . . . . . . 540
indicator lamp (key) . . . . . . . . . . . 86
isolating switch . . . . . . . . . 338
,339
recharging . . . . . . . . . . . . . . . . . 579
reconnecting . . . . . . . . . . . . . . . 580
removing . . . . . . . . . . . . . . . . . . 578safety notes . . . . . . . . . . . . . . . . 335
starter battery
disconnecting . . . . . . . . . . . . 575
Bead
. . . . . . . . . . . . . . . . . . . . . . . 394
Belt force limiters
. . . . . . . . . . . . .44
Bi-xenon headlamps
. . . . . . . . . . 527
driving abroad . . . . . . . . . . . . . . 311
Body builder guideline
. . . . . . . . . .11
Bottle holdersee Cup holdersBrake Assist (BAS)
. . . . . . . . . . . . .71
display message . . . . . . . . 500
–501
indicator lamp . . . . . . . . . . 462,465
malfunction . . . . . . . . . . . . . . . . 465
Brake fluid
. . . . . . . . . . . . . . . . . . 617
checking the brake fluid level . . 331
display message . . . . . . . . . . . . 498
B
nf_BA.book Page 639 Friday, January 25, 2008 3:53 PM