2008 DODGE RAM 3500 GAS belt

Engine Oil Filter
The engine oil filter should be replaced at every engine
oil change.
Engine Oil Filter Selection
The manufacturer's engines have a full-flow type oil
filter. Use a filter of this type for replacement. The quality
of replacement filters varies considerably. Only high-
quality filters should be used to assure most efficient
service. Mopar Engine Oil Filters are a high-quality oil
filter and are recommended.
Drive Belts Ð Check Condition and Tension
Belt tension is controlled by means of an automatic
tensioner. No belt tension adjustments are required.
However, belt and belt tensioner condition should be
inspected at the specified intervals and replaced if re-
quired. See your authorized dealer for service.At the mileage indicated in the maintenance schedule, all
belts and tensioner should be checked for condition.
Improper belt tension can cause belt slippage and failure.
Belts should be inspected for evidence of cuts, cracks,
glazing or frayed cords and replaced if there is indication
of damage which could result in belt failure. Low gen-
erator belt tension can cause battery failure.
Also check belt routing to make sure there is no interfer-
ence between the belts and other engine components.
Spark Plugs (Gas Engines)
Spark plugs must fire properly to assure engine perfor-
mance and emission control. New plugs should be in-
stalled at the specified mileage. The entire set should be
replaced if there is any malfunction due to a faulty spark
plug. Malfunctioning spark plugs can damage the cata-
lytic converter. For proper type of replacement spark
plugs, refer to the ªSpark Plugsº under ªFluids, Lubri-
cants and Genuine Partsº in Section 7.
454 MAINTAINING YOUR VEHICLE

Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an Authorized Dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
NOTE:Refer to Section 3 of the Warranty Information
book for further warranty information.WARNING!
²Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs.
²The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced repairman.
NOTE:Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, or Refrigerants.
MAINTAINING YOUR VEHICLE 459
7

Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with MopartGlass Cleaner or any commercial
household-type glass cleaner. Never use an abrasive type
cleaner. Use caution when cleaning the inside rear win-
dow equipped with electric defrosters or the right rear
quarter window equipped with the radio antenna. Do
not use scrapers or other sharp instruments which may
scratch the elements. When cleaning the rearview mirror,
spray cleaner on the towel or rag that you are using. Do
not spray cleaner directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Dry with a soft tissue.
488 MAINTAINING YOUR VEHICLE

Cavity Cartridge
FuseMini
FuseDescription
32 10 Amp
RedPower Ignition Run
Ð Adjustable Pedals
LED
33 10 Amp
RedPower-IGN Run Ð
HVAC
34 Ð Ð
35 15 Amp
BlueCabin Compartment
Node (CCN) Illumi-
nation
36 25 Amp
NaturalAudio_Amplifier
37 15 Amp
BlueVariable Gate Turbo
(VGT) Ð Turbo Die-
sel
38 20 Amp
YellowPower Outlet IPCavity Cartridge
FuseMini
FuseDescription
39 10 Amp
RedSeatbelt Tension
Reducer/Power IGN
Run/Acc
40 20 Amp
YellowPower IGN Run/Acc
Ð Cigar Lighter/Rear
Power Point
41 Ð Ð
42 30 Amp
PinkDiesel PCM (Diesel
Only)
492 MAINTAINING YOUR VEHICLE

Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Change the manual transmission fluid if using your
vehicle for any of the following: trailer towing, snow
plowing, heavy loading, taxi, police, delivery service
(commercial service), off-road, desert operation or
more then 50% of your driving is at sustained high
speeds during hot weather, above 90FÉ (32CÉ).60,000 100 000 60
Inspect and replace PCV valve if necessary. ²90,000 150 000 90
Flush and replace the engine coolant. 102,000 170 000 60
Replace the ignition cables on 4.7L engines.102,000 170 000 102
Replace the side row of spark plugs on 4.7L engines. **102,000 170 000 102
Change the automatic transmission fluid & filter. 120,000 200 000 120
Replace Accessory Drive Belt(s). 120,000 200 000 120
² This maintenance is recommended by the manufacturer
to the owner, but is not required to maintain emissions
warranty.
MAINTENANCE SCHEDULES 519
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Axle Lubrication (Axle Fluid)............... 474
Ball Joints............................. 460
Battery............................... 457
Emergency Starting..................... 434
Saving Feature (Protection)............... 136
Bearings.............................. 479
Belts, Drive............................ 454
Belts, Seat.............................. 35
Body Builders Guide....................... 6
Body Mechanism Lubrication............... 462
B-Pillar Location........................ 343
Brake Assist System...................... 326
Brake Control System, Electronic............. 324
Brake Fluid.........................472,511
Brake System........................319,471
Anti-Lock (ABS).................320,321,325
Disc Brakes.......................... 471
Fluid Check.......................... 472Hoses.............................. 471
Master Cylinder....................... 472
Parking............................. 318
Warning Light........................ 202
Break-In Recommendations, New Vehicle........ 76
Bulb Replacement....................... 495
Bulbs, Light............................ 494
Cab Top Clearance Lights.................. 503
Calibration, Compass..................... 154
Camper............................... 185
Capacities, Fluid........................ 508
Caps, Filler
Oil (Engine).......................... 452
Power Steering........................ 460
Radiator (Coolant Pressure)............... 468
Car Washes............................ 484
Carbon Monoxide Warning............78,187,375
Cargo Light............................ 138
INDEX 533
10

Cassette Tape and Player Maintenance......... 257
Catalytic Converter...................... 455
CD (Compact Disc) Player............ 211,219,233
Cellular Phone.......................... 91
Center High Mounted Stop Light............ 502
Center Lap Belts......................... 45
Center Seat Storage Compartment.........173,174
Certification Label....................... 381
Chart, Tire Sizing........................ 340
Check Engine Light
(Malfunction Indicator Light)............... 201
Child Restraint........................62,63
Child Restraint Tether Anchors.............66,71
Child Seat............................63,70
Cigar Lighter........................... 168
Cleaning
Wheels............................. 486
Climate Control......................... 259
Clock.....................209,213,221,234,248Clutch............................... 474
Clutch Linkage Maintenance................ 474
Compact Disc (CD) Maintenance............. 258
Compact Spare Tire...................... 351
Compass...........................153,154
Compass Calibration..................... 154
Compass Variance....................... 155
Computer, Trip/Travel.................... 149
Console, Overhead....................... 148
Contract, Service........................ 525
Coolant Pressure Cap (Radiator Cap).......... 468
Cooling System......................... 465
Adding Coolant (Antifreeze).............. 467
Coolant Capacity...................... 508
Coolant Level......................465,469
Disposal of Used Coolant................ 469
Drain, Flush, and Refill.................. 466
Inspection........................... 469
Points to Remember.................... 469
534 INDEX

Pressure Cap......................... 468
Radiator Cap......................... 468
Selection of Coolant (Antifreeze)......466,508,510
Temperature Gauge..................... 198
Cruise Control (Speed Control).............. 145
Cupholders............................ 169
Customer Assistance..................... 523
Data Recorder, Event...................... 60
Daytime Running Lights................... 137
Dealer Service.......................... 450
Defroster, Rear Window.................89,182
Defroster, Windshield................79,260,263
Delay (Intermittent) Wipers................. 141
Differential, Limited-Slip.................. 313
Dipsticks
Automatic Transmission................. 477
Power Steering........................ 460
Disc Brakes............................ 471Disposal
Antifreeze (Engine Coolant)............... 469
Door Locks............................. 27
Door Opener, Garage..................... 156
Drive Belts............................ 454
Drive Shaft Universal Joints................ 461
Driving
Through Flowing, Rising, or Shallow Standing
Water................................ 315
Dual Rear Wheels.....................361,431
DVD Player (Video Entertainment SystemŸ).... 251
E-85 Fuel............................. 377
Electric Rear Window Defrost.............89,182
Electrical Power Outlets................... 166
Electronic Brake Control System............. 324
Anti-Lock Brake System................. 325
Brake Assist System.................... 326
Electronic Roll Mitigation................ 332
INDEX 535
10