2008 DODGE NITRO manual transmission

NPower Steering Fluid Check..............363
NDriveline And Steering Component
Lubrication..........................364
NBody Lubrication.....................364
NWindshield Wiper Blades................365
NWindshield Washers...................365
NExhaust System......................366
NCooling System.......................366
NHoses And Vacuum/Vapor Harnesses.......371
NBrake System........................372
NAutomatic Transmission................374
NHydraulic Clutch Fluid Ð Manual
Transmission........................375
NManual Transmission..................375NTransfer Case........................376
NFront/Rear Axle Fluid..................377
NAppearance Care And Protection From
Corrosion...........................377
mFuses (Integrated Power Module)...........381
mReplacement Light Bulbs.................389
mBulb Replacement......................389
NHead Light..........................389
NLeft Front Turn Signal..................390
NRight Front Turn Signal.................391
NFront Side Marker.....................391
NFront Fog Light (Front Fascia Mounted).....391
NRear Tail, Stop, Turn Signal, And Back-Up
Lights.............................392
346 MAINTAINING YOUR VEHICLE

Fluid Level Check Ð W5A580 (4.0L Engine)
Your vehicle is equipped with a capped dipstick tube, it
is sealed and should not be tampered with. Your autho-
rized dealer has the proper tools to ensure that the fluid
level is set properly.
Special Additives
The manufacturer strongly recommends against the ad-
dition of any additives to the transmission. The only
exception to this policy is the use of special dyes to aid in
detecting fluid leaks. The use of transmission sealers
should be avoided as they may adversely affect seals.
Hydraulic Clutch Fluid Ð Manual Transmission
The clutch hydraulic system is fed by a segregated
volume of fluid within the brake system master cylinder
reservoir. In the event of leakage or wear, use only
manufacturer's recommended brake fluid, refer to Fluids,
Lubricants, and Genuine Parts for correct fluid type.
Manual Transmission
Selection of Lubricant
Use only manufacturer's recommended manual trans-
mission fluid, refer to Fluids, Lubricants, and Genuine
Parts for correct fluid type.
Fluid Level Check
Check the fluid level by removing the fill plug. The fluid
level should be between the bottom of the fill hole and a
point not more than 3/16º (4.76 mm) below the bottom of
the hole.
Add fluid, if necessary, to maintain the proper level.
Frequency of Fluid Change
Under normal operating conditions, the fluid installed at
the factory will give satisfactory lubrication for the life of
the vehicle. Fluid changes are not necessary unless the
lubricant has become contaminated with water. If con-
taminated with water, the fluid should be changed im-
mediately.
MAINTAINING YOUR VEHICLE 375
7

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MopartATF+4, Automatic Transmission Fluid.
Manual Transmission MopartManual Transmission Lubricant or equivalent (meeting the re-
quirements of DaimlerChrysler Material Standard MS-9224)
Transfer Case MopartATF+4, Automatic Transmission Fluid.
Front Axle SAE 80W-90 Multipurpose Type, GL-5 Gear Lubricant or equivalent.
Rear Axle SAE 75W-140 Synthetic Gear Lubricant or equivalent.
Brake Master Cylinder/Manual
Transmission Clutch SystemMopartDOT 3 Brake Fluid, SAE J1703 should be used. If DOT 3, SAE
J1703 brake fluid is not available, then DOT 4 is acceptable. Use only rec-
ommended brake fluids.
Power Steering Reservoir MopartATF+4, Automatic Transmission Fluid.
396 MAINTAINING YOUR VEHICLE

Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
²Check all lights and other electrical items for correct
operation.At Each Oil Change
²Change the engine oil filter.
²Inspect the brake hoses and lines.
²Check the manual transmission fluid level.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
400 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Check the PCV valve, replace if necessary.30,000 50 000 30
Change the manual transmission fluid if using your
vehicle for any of the following: trailer towing, snow
plowing, heavy loading, taxi, police, delivery service
(commercial service), off-road, desert operation or
more then 50% of your driving is at sustained high
speeds during hot weather, above 90ÉF (32ÉC).30,000 50 000 30
Inspect the transfer case fluid. 30,000 50 000 30
Replace the spark plugs (3.7L Only).30,000 50 000 30
Change the automatic transmission fluid & filter if
using your vehicle for any of the following: police,
taxi, fleet or frequent trailer towing.60,000 100 000 60
Change the transfer case fluid if using your vehicle for
any of the following: police, taxi, fleet, off-road or fre-
quent trailer towing.60,000 100 000 60
402 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Exhaust System......................... 366
Exterior Finish Care...................... 378
Fabric Care.........................379,380
Filters
Air Cleaner.......................... 361
Engine Fuel.......................... 361
Engine Oil........................357,395
Finish Care............................ 378
Flashers
Hazard Warning....................... 334
Turn Signal..................171,390,391,392
Flooded Engine Starting................... 246
Floor Console.......................... 152
Fluid, Brake........................... 396
Fluid Capacities......................... 394
Fluid Leaks............................. 78
Fluid Level Checks...................... 377
Automatic Transmission................. 374Engine Oil........................... 354
Manual Transmission................... 375
Power Steering........................ 363
Fluids, Lubricants and Genuine Parts.......... 395
Fog Light Service........................ 391
Fog Lights..........................124,391
Folding Rear Seat........................ 118
Four Wheel Drive....................... 265
Operation........................... 265
Systems............................. 265
Four Wheel Drive Operation................ 265
Four-Way Hazard Flasher.................. 334
Front Axle (Differential)................... 377
Fuel................................. 306
Filler Cap (Gas Cap).................... 310
Filter............................... 361
Gasoline............................ 306
Gauge.............................. 168
Materials Added....................... 308
INDEX 421
10

Side Marker.......................... 392
Tire Pressure Monitoring (TPMS)........... 296
Traction Control....................... 135
Turn Signal..................125,390,391,392
Warning (Instrument Cluster Description)..... 168
Load Floor, Cargo....................... 154
Load N Go
Sliding Cargo Floor..................... 156
Loading Vehicle......................... 313
Tires ............................... 283
Locks................................. 27
Child Protection........................ 32
Door................................ 27
Power Door........................... 29
Steering Wheel......................... 17
Low Tire Pressure System.................. 296
Lower Anchors and Tether for CHildren
(LATCH)............................70,71
Lubrication, Body....................... 364Luggage Carrier......................... 160
Maintenance Free Battery.................. 362
Maintenance Procedures................... 354
Maintenance Schedule.................... 398
Maintenance, Sunroof..................... 147
Malfunction Indicator Light (Check Engine) . . 178,351
Manual, Service......................... 410
Manual Transmission..................249,375
Fluid Level Check...................... 375
Lubricant Selection..................375,396
Shift Speeds.......................... 251
Master Cylinder (Brakes).................. 373
Mini-Trip Computer...................180,188
Mirrors................................ 83
Automatic Dimming..................... 84
Electric Powered....................... 85
Outside.............................. 84
Rearview............................. 83
INDEX 425
10

Shoulder Belt Anchorage.................. 44
Seats................................. 113
Adjustment.......................... 113
Cleaning............................ 379
Head Restraints....................... 116
Heated.............................. 116
Rear Folding......................... 118
Reclining............................ 114
Security Alarm (Theft Alarm).............18,170
Selection of Coolant (Antifreeze)............. 395
Selection of Oil......................... 356
Sentry Key (Immobilizer)................... 14
Sentry Key Programming................... 16
Sentry Key Replacement................... 15
Service Assistance....................... 406
Service Contract......................... 408
Service Manuals........................ 410
Setting the Clock..................199,215,226
Settings, Personal........................ 193Shift Lock Manual Override................ 253
Shift Speeds, Manual Transmission........... 251
Shifting
Automatic Transmission...............255,260
Manual Transmission................... 249
Shoulder Belts........................... 40
Signals, Turn................125,171,390,391,392
Sliding Cargo Floor
LoadNGo ........................... 156
Snow Chains (Tire Chains)................. 294
Spare Tire............................. 337
Spark Plugs............................ 358
Specifications
Fuel (Gasoline)........................ 306
Oil ................................ 356
Speed Control (Cruise Control).............. 128
Speedometer........................... 170
Starting............................... 245
Automatic Transmission................. 245
INDEX 429
10