2008 DODGE CHARGER steering

WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturer's recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to ªFluids, Lubricants, and Genuine
Partsº in this section for the correct fluid type.
Front & Rear Suspension Ball Joints
The suspension ball joints should be inspected for exter-
nal leakage or damage when other maintenance is per-
formed.
Steering Linkage
The tie rod end ball joints should be inspected for
external leakage or damage when other maintenance is
performed.
Body Lubrication
Locks and all body pivot points, including seat tracks,
door hinges, trunk hinges, and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
attention should also be given to hood latching compo-
nents to insure proper function. When performing other
underhood services, the hood latch, release mechanism,
and safety catch should be cleaned and lubricated.
MAINTAINING YOUR VEHICLE 385
7

Care should be taken in installing quick connect fittings
to insure they are properly installed and fully connected.
See your authorized dealer for service.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in the ªMainte-
nance Scheduleº in Section 8 of this manual.
WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn't have your full
braking capacity in an emergency.
Brake And Power Steering Hoses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, tears, cuts, abrasion, and excessive swelling
indicate deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE:
²Often, fluid such as oil, power steering fluid, and
brake fluid are used during assembly plant operations
to facilitate the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is not
394 MAINTAINING YOUR VEHICLE

Cavity Car-
tridge
FuseMini
FuseDescription
27 Ð 10 Amp
RedOccupant Restraint Con-
troller (ORC)
28 Ð 10 Amp
RedIgnition Run
29 Ð 5 Amp
OrangeCluster/Electronic Sta-
bility Program (ESP) - if
equipped/Powertrain
Control Module (PCM)/
Stop Light Switch
30 Ð 10 Amp
RedDoor Modules/Power
Mirrors/Steering Con-
trol Module (SCM)
31ÐÐÐ
32ÐÐÐ
33ÐÐÐ
34ÐÐÐCavity Car-
tridge
FuseMini
FuseDescription
35 Ð 5 Amp
OrangeAntenna Module - if
equipped/Power Mir-
rors
36 Ð 20 Amp
YellowHands Free Phone - if
equipped/Video Moni-
tor - if equipped/Radio
37 Ð 15 Amp
BlueTransmission
38 Ð 10 Amp
RedCargo Light/Satellite
Receiver (SDARS) Video
- if equipped/Vehicle
Information Module - if
equipped
39 Ð 10 Amp
RedHeated Mirrors - if
equipped
MAINTAINING YOUR VEHICLE 409
7

Chassis
Component Fluids, Lubricants and Genuine Parts
Automatic Transmission MopartATF+4 Automatic Transmission Fluid.
Brake Master Cylinder MopartDOT 3, SAE J1703 or equivalent should be used. If DOT 3 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids.
Front Axle API GL-5 SAE 75W90 Synthetic Gear Lubricant or equivalent.
Power Steering Reservoir MopartPower Steering Fluid + 4, MopartATF+4 Automatic Transmission
Fluid.
Rear Axle API GL-5 SAE 75W140 Synthetic Gear Lubricant or equivalent.
Transfer Case MopartTransfer Case Lubricant LX, P/N 05170055AA, or equivalent.
MAINTAINING YOUR VEHICLE 423
7

²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering, and transmission,
and add as needed.
²Check all lights and other electrical items for correct
operation.At Each Oil Change
²Change the engine oil filter.
²Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
428 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Cooling System....................... 388
Engine Oil........................374,375
Power Steering........................ 384
Transfer Case......................... 398
Fluids................................ 421
Fluids, Lubricants and Genuine Parts.......... 421
Fog Lights..........................126,168
Folding Rear Seat........................ 120
Freeing A Stuck Vehicle................... 359
Front Suspension Ball Joints................ 385
Front Wheel Bearings..................... 398
Fuel................................. 319
Adding............................. 323
Additives............................ 321
Clean Air............................ 320
Conserving.......................... 178
Ethanol............................. 320
Filler Cap (Gas Cap).................... 323
Filter............................... 379Gasoline............................ 319
Gauge.............................. 164
Hoses.............................. 393
Materials Added....................... 321
Methanol............................ 320
Octane Rating......................319,421
Requirements......................... 319
Saver Mode.......................... 178
Specifications......................... 421
Tank Capacity........................ 419
Fuel System Caution..................... 324
Fueling............................... 323
Fuses................................ 404
Garage Door Opener (HomeLinkt) ........... 139
Gas Cap (Fuel Filler Cap)...............323,370
Gasoline, Clean Air...................... 320
Gasoline (Fuel)......................... 319
Conserving.......................... 178
INDEX 451
10

Phone, Cellular.....................87,209,211
Phone, Hands-Free (UConnectŸ)........87,209,211
Placard, Tire and Loading Information......... 294
Port
Universal Serial Bus (USB).............191,209
USB .............................191,209
Power
Brakes.............................. 280
Deck Lid Release....................... 38
Distribution Center (Fuses)............... 404
Door Locks........................... 29
Mirrors.............................. 86
Outlet (Auxiliary Electrical Outlet).......... 149
Seats............................... 115
Steering............................. 282
Steering, Checking..................... 384
Sunroof............................. 146
Windows............................. 34
Power Steering Fluid..................384,423Pregnant Women and Seat Belts.............. 49
Preparation for Jacking.................... 347
Pretensioners
Seat Belts............................. 47
Programmable Electronic Features............ 186
Programming Transmitters (Remote Keyless
Entry)................................. 20
Radial Ply Tires......................... 301
Radiator Cap (Coolant Pressure Cap).......... 390
Radio Broadcast Signals................... 190
Radio, Navigation....................... 209
Radio Operation...................192,211,239
Radio Remote Controls.................... 237
Radio, Satellite...............191,192,209,211,226
Radio (Sound Systems).................191,209
Rear Cup Holder........................ 152
Rear Seat, Folding....................... 120
Rear Wheel Bearings..................... 398
458 INDEX

Setting the Clock................192,196,211,215
Settings, Personal........................ 186
Shifting............................... 258
Automatic Transmission............258,262,267
Shoulder Belt Upper Anchorage.............. 46
Shoulder Belts........................... 41
Side Airbag...........................52,58
Side Curtain (Window Airbag)............... 52
Signals, Turn......................78,127,166
Slippery Surfaces, Driving On............... 275
Snow Chains (Tire Chains)................. 307
Snow Tires............................ 308
Sound Systems (Radio).................191,209
Spare Tire..........................302,348
Spark Plugs.........................379,421
Specifications
Fuel (Gasoline)........................ 421
Oil ................................ 421
Speed Control (Cruise Control).............. 135Speedometer........................... 164
Starting.............................26,255
Automatic Transmission................. 256
Cold Weather......................... 256
Emergency (Jump Starting)............... 356
Engine Fails to Start.................... 257
Remote.............................. 26
Starting and Operating.................... 255
Starting Procedures...................... 255
Steering
Column Controls...................... 126
Column Lock......................... 133
Linkage............................. 385
Power...........................282,384
Tilt Column.......................... 133
Wheel, Tilt........................... 133
Steering Wheel Mounted Sound System
Controls.............................. 237
Storage............................153,411
INDEX 461
10