2008 CHRYSLER PT CRUISER tow

INTEGRATED POWER MODULE (IPM)
An Integrated Power Module is located in the engine
compartment near the air cleaner assembly. This center
contains cartridge fuses and mini fuses. A description of
each fuse and component may be stamped on the inside
of the cover.INTEGRATED POWER MODULE (IPM)
CavityCartridge
FuseMini Fuse Description
140 Amp
GreenPower Top
Feed Ð
Convertible
Only
220 Amp Yel-
lowAWD ECU
Feed
3 10 Amp RedCHMSL
Brake
Switch Feed
4 10 Amp RedIgnition
Switch Feed
520 Amp Yel-
lowTrailer Tow
Integrated Power Module Location
MAINTAINING YOUR VEHICLE 419
7

EMISSIONS CONTROL SYSTEM MAINTENANCE
The Scheduled Maintenance services listed inbold type
must be done at the times or mileages specified to ensure
the continued proper functioning of the emission control
system. These, and all other maintenance services in-
cluded in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions, such as dusty areas and very short trip
driving.
Inspection and service should also be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sions control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part that has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULE
There are three maintenance schedules that showre-
quiredservice for your vehicle.
First is ScheduleªBºÐALL ENGINES. It is for vehicles
that are operated under the conditions that are listed
below and at the beginning of the schedule.
²Day and night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.²L
434 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE ªBºÐALL ENGINES
Follow schedule ªBºÐAll Engines if you usually operate
your vehicle under one or more of the following condi-
tions.
Change the automatic transmission fluid and filter every
60,000 miles (100 000 km) if the vehicle is usually
operated under one or more of the conditions marked
with anL.
Change the manual transaxle fluid every 48,000 miles (80
000 km) if the vehicle is usually operated under one or
more of the conditions marked with an ².
²Day and night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16.2 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.²L
²Taxi, police, or delivery service (commercial ser-
vice).²L
²Off-road or desert operation.
²If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first, and follow schedule ªBÐAll
Enginesº of the9Maintenance Schedules9section of this
manual.
SCHEDULE ªBºÐALL ENGINES 437
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 39,000 42,000 45,000 48,000 51,000 54,000
(Kilometers) (65 000) (70 000) (75 000) (80 000) (85 000) (90 000)
Change engine oil and engine oil filter, if not
replaced at 3 months.XXXXX X
Rotate tires. X X X
Inspect the brake linings. X
Change the brake fluid. If vehicle is used for
trailer towing.X
Inspect theengine air cleaner filter,replace as
necessary.*X
Change the manual transaxle fluid.² X
Inspect theMake-up air filter.Replace as nec-
essary.X
SCHEDULE ªBºÐALL ENGINES 441
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 93,000 96,000 99,000 102,000 105,000
(Kilometers) (155 000) (160 000) (165 000) (170 000) (175 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Rotate tires. X X
Inspect the brake linings. X
Change the brake fluid. If vehicle is used for trailer
towing.X
Inspect theengine air cleaner filterand replace as
necessary.*X
Change the manual transaxle fluid.² X
Replace theengine timing belt.*X
Flush and replace the engine coolant, if not replaced
at 60 months.X
Inspect theMake-up air filter,replace as necessary. X
444 SCHEDULE ªBºÐALL ENGINES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 138,000 141,000 144,000 147,000 150,000
(Kilometers) (230 000) (235 000) (240 000) (245 000) (250 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Rotate tires. X X X
Inspect the brake linings. X
Replace theengine air cleaner filter.*X
Replace the spark plugs.X
Change the manual transaxle fluid.² X
Replace theMake-up air filter.X
Inspect thePCV valve and replace if necessary.*³ X
* This maintenance is recommended by the manufacturer
to the owner, but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
² This maintenance is required only for police, taxi,
limousine type operation, or trailer towing.LThis maintenance is required only for police, taxi,
limousine type operation, or trailer towing.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE ªBºÐALL ENGINES 447
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Door Opener, Garage..................... 197
Downshifting.......................... 304
Drive Belts............................ 388
Driver's Seat Back Tilt.................... 167
Driving
On Slippery Surfaces.................... 369
Electric Rear Window Defrost............... 217
Electric Remote Mirrors................... 137
Electrical Power Outlets................... 206
Electronic Speed Control (Cruise Control)...... 194
Electronic Vehicle Information Center
(EVIC)..........................234,235,240
Emergency Deck Lid Release Latch (Convertible) . . 41
Emergency, In Case of
Jacking............................. 360
Jump Starting......................... 367
Towing............................. 371
Emergency Seat Back Release (Sedan).......... 40Emission Control System Maintenance......381,434
Engine.......................... 115,378,379
Break-In Recommendations............... 115
Checking Oil Level..................... 384
Coolant (Antifreeze).................... 398
Cooling............................. 398
Exhaust Gas Caution.................... 339
Fuel Requirements..................... 337
Jump Starting......................... 367
Oil ...........................384,429,430
Oil Change Interval.................... 385
Oil Filler Cap...................378,379,387
Oil Filter............................ 430
Oil Selection.......................... 386
Oil Synthetic......................... 387
Operation............................ 115
Overheating.......................... 358
Temperature Gauge..................... 226
Timing Belt.......................... 390
474 INDEX

Ethanol............................... 337
Event Data Recorder...................70,105
Exhaust Gas Caution............38,39,115,339,397
Exhaust System......................... 397
Fabric Care.........................413,414
Filler Location Fuel....................226,340
Filters
Air Cleaner.......................... 391
Automatic Transaxle.................... 409
Engine Fuel.......................... 391
Engine Oil........................387,430
Flashers.............................. 358
Hazard Warning....................... 358
Flat Tire Stowage........................ 367
Flooded Engine Starting................... 293
Fluid, Brake........................... 431
Fluid Capacities......................... 429
Fluid Leaks............................ 117Fluid Level Checks
Automatic Transaxle.................... 408
Brake............................... 406
Cooling System....................... 398
Power Steering........................ 394
Fluids................................ 430
Fluids, Lubricants and Genuine Parts.......... 430
Fog Light Service........................ 426
Fog Lights..........................188,233
Folding Front Passenger Seat............... 167
Folding Rear Seat.....................171,173
Folding Rear Seat (Convertible).............. 173
Folding Rear Seat (Sedan).................. 171
Freeing A Stuck Vehicle................... 370
Fuel..............................337,430
Adding............................. 340
Additives............................ 338
Capacity............................ 429
Clean Air............................ 337
INDEX 475
10