2008 CHRYSLER 300 SRT air conditioning

Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluorocar-
bon (HFC) that is endorsed by the Environmental Pro-
tection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealers or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C system
sealers, stop leak products, seal conditioners, compressor
oil, and refrigerants.
A/C Air Filter — If Equipped
The filter is located in the fresh air inlet under the hood,
behind a removable panel in the cowl on the passenger
side of the vehicle, next to the windshield wipers. When
installing a new filter, ensure its proper orientation. To
replace the filter, remove the access door in the cowl
screen by pressing the retaining clips. Slide the lid on the
filter adapter forward and down and remove the usedfilter. Install the new filter with arrows pointing in the
direction of airflow, which is toward the rear of the
vehicle (text and arrows on the filter indicate this).
Refer to the Maintenance Schedule in Section 8 for the
recommended air conditioning filter replacement inter-
vals.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through an autho-
rized dealer. No chemical flushes should be used in any
power steering system; only the approved lubricant may
be used.
400 MAINTAINING YOUR VEHICLE

•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses and Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hoserouting to be sure hoses do not come in contact with any
heat source or moving component, which may cause heat
damage or mechanical wear.
Ensure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.Fuel System
The Electronic Fuel Injection high-pressure fuel system’s
hoses and quick connect fittings have unique material
characteristics that provide adequate sealing and resist
attack by deteriorated gasoline.
MAINTAINING YOUR VEHICLE 409
7

VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take these steps to protect your
battery.
•Disconnect the negative cable from the battery.
•Anytime you store your vehicle, or keep it out of
service (i.e., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
REPLACEMENT BULBS
LIGHT BULBS — Interior Bulb Number
Rear Courtesy/Reading Lights.............. W5W
Rear Compartment (Trunk) Light............. 579
Overhead Console Reading Lights............. 578
Visor Vanity Lights.....................A6220
Glove Box Light......................... 194
Door Courtesy.......................... 562
Shift Indicator Light................. JKLE14140
Optional Door Map Pocket / Cupholder
Lighting........ LED(ServicedatAuthorized Dealer)
NOTE:For lighted switches, see your authorized dealer
for replacement instructions.
All of the interior bulbs are glass wedge base or glass
cartridge types. Aluminum base bulbs are not approved
and should not be used for replacement.
MAINTAINING YOUR VEHICLE 427
7

Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Replace the air conditioning filter (if equipped). 12,000 20 000 12
Inspect the rear axle fluid. 18,000 30 000 18
Inspect the CV joints. Perform the first inspection at
12,000 mi (20 000 km) or 12 months.24,000 40 000 24
Inspect the exhaust system. Perform the first inspec-
tion at 12,000 mi (20 000 km) or 12 months.24,000 40 000 24
Inspect the front suspension, tie rod ends and boot
seals, and replace if necessary.24,000 40 000 24
Replace the engine air cleaner filter. 30,000 50 000 30
Change the rear axle fluid if using your vehicle for
any of the following: police, taxi, fleet, off-road, or fre-
quent trailer towing.48,000 80 000 48
Change the automatic transmission fluid and filter if
using your vehicle for any of the following: police,
taxi, fleet, or frequent trailer towing.60,000 100 000 60
444 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

About Your Brakes....................315,317
ABS (Anti-Lock Brake System)............317,321
Adaptive Cruise Control (ACC) (Cruise Control) . . 153
Adding Engine Coolant (Antifreeze).......... 406
Adding Fuel........................... 361
Adding Washer Fluid...............144,146,402
Additives, Fuel......................... 359
Adjustable Pedals....................... 148
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 394
Air Conditioner Maintenance............... 399
Air Conditioning Filter.................290,400
Air Conditioning, Operating Tips............ 291
Air Conditioning Refrigerant.............399,400
Air Conditioning System................284,399
Air Pressure, Tires....................206,337
Airbag................................ 49
Airbag Deployment..................... 55,59
Airbag Light..................... 56,61,76,201
Airbag Maintenance....................... 61Airbag, Side.......................... 50,57
Airbag, Window (Side Curtain)............. 50,57
Alarm, Panic............................ 22
Alarm (Security Alarm)................. 18,205
Alarm System (Security Alarm)............... 18
Alignment and Balance................... 343
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 270
Antifreeze (Engine Coolant)...........405,406,435
Disposal............................ 407
Anti-Lock Brake System (ABS)............317,321
Anti-Lock Warning Light...............200,319
Anti-Theft Security Alarm (Theft Alarm)........ 18
Anti-Theft System....................... 205
Appearance Care........................ 414
Arming Theft System (Security Alarm)......... 18
Assistance Towing....................... 101
Audio Systems (Radio).................232,251
Auto Down Power Windows................ 34
458 INDEX

Filters
Air Cleaner.......................... 394
Air Conditioning....................290,400
Engine Fuel.......................... 395
Engine Oil........................393,436
Engine Oil Disposal.................... 393
Flashers
Hazard Warning....................... 370
Turn Signal...................... 77,138,199
Flash-To-Pass........................... 138
Flooded Engine Starting................... 300
Floor Console.......................... 190
Fluid, Brake........................... 437
Fluid Capacities......................... 435
Fluid Leaks............................. 77
Fluid Level Checks
Automatic Transmission................. 413
Brake............................... 411
Cooling System....................... 404Engine Oil........................... 391
Power Steering........................ 400
Fluids ................................ 436
Fluids, Lubricants and Genuine Parts.......... 436
Fog Lights..........................137,199
Folding Rear Seat........................ 125
Freeing A Stuck Vehicle................... 380
Front Suspension Ball Joints................ 401
Front Wheel Bearings..................... 414
Fuel................................. 357
Adding............................. 361
Additives............................ 359
CleanAir ............................ 358
Ethanol............................. 358
Filler Cap (Gas Cap).................... 361
Filter ............................... 395
Gasoline............................ 357
Gauge.............................. 205
Hoses.............................. 409
464 INDEX