2008 BMW Z4 M COUPE engine

BMW Engine Oil Service stamps
11

Battery Care
If your car is driven only for short distances of
less than 10 miles over a prolonged period of
time, without an occasional drive at highway
speeds, the engine’s charging system will not
maintain the battery. Insufficient use of the vehi-
cle could result in short term starting problems
and in the long term could damage the battery.
In case the car is not operated for more than
four weeks it is advisable to:
 consider using a proper trickle charger, fol-
lowing the charger manufacturer’s instruc-
tions, to maintain the battery’s state of
charge; or
 consult your BMW center regarding battery
removal. Once removed, the battery must be
charged and stored in a cool, dry place where
it can be protected from freezing. If the bat-
tery will be stored for over 3 months, it must
be recharged every 3 months, or else it will
become damaged and useless.
Please consult with your BMW center for further
guidance and information.
Corrosion Protection
Extensive corrosion protection measures imple-
mented by BMW now make it possible to offer a
twelve-year limited anti-corrosion warranty
against rust perforation on your vehicle provided
that the vehicle is maintained in accordance
with the provisions of the New Vehicle Limited
Warranty as outlined in the Warranty Section of
this Statement (page 29).
The major degree of corrosion protection is due
to the electrophoretic dip painting process
which cathodically deposits paint particles on all
body parts, attracting paint particles into the
minutest cavities or seams. Body parts are
designed to provide optimum corrosion
protection.
During manufacture, exterior body parts receive
an additional corrosion protection coat. Hood,
trunk, doors and other body parts with metal
folds are coated with PVC and sealed from the
outside. All floor panels receive a resilient coating of PVC
for maximum protection against damage due to
stones, etc.
Corrosion protection materials tested over many
years are applied to the surfaces of cavities and
to the entire underside of the vehicle during and
after assembly.
Requirements for maintaining the twelve year
unlimited mileage anti-corrosion warranty are
outlined in the Warranty Section of this State-
ment (page 31).
Restoring corrosion protection
Please take care that anti-corrosion material is
replaced when your car is repaired after body or
chassis damage.
BMW NA will not accept any liability for any
parts and accessories not approved by
BMW.
Underbody maintenance
The underbody has to be cleaned at least once
a year, in spring, with plain water in order to
remove mud, chemical sediments and other
deposits. If those materials are not removed,
corrosion (rust) will occur.
Your BMW center will do this anti-corrosion ser-
vice for you.
Do not apply additional undercoating or
rust-proofing on or near the exhaust
manifold, exhaust pipes, catalytic converter or
heat shields. During driving, the substance used
for undercoating could overheat and cause a
fire.
14

New Vehicle Limited Warranty –
2008 Models (Valid only in the
U.S.A. and Puerto Rico)
Warrantor
BMW of North America, LLC (BMW NA) war-
rants 2008 U.S. specification vehicles distrib-
uted by BMW NA or sold through the BMW NA
European Delivery Program against defects in
materials or workmanship to the first retail pur-
chaser, and each subsequent purchaser.
Warranty Period
The warranty period is 48 months or
50,000 miles, whichever occurs first.
Warranty Begins
Coverage begins on the date of first retail sale,
or the date the vehicle is first placed into service
as a sales demonstrator, service loaner (SLP) or
company vehicle, whichever is earlier.
Warranty Coverage
To obtain service under this warranty, the vehi-
cle must be brought, upon discovery of a defect
in material or workmanship, to the workshop of
any authorized BMW center in the United States
or Puerto Rico, during normal business hours.
The BMW center will, without charge for parts
or labor, either repair or replace the defective
part(s) using new or authorized remanufactured
parts. The decision to repair or replace said
part(s) is solely the prerogative of BMW NA.
Parts for which replacements are made become
the property of BMW NA.
In all cases, a reasonable time must be allowed
for warranty repairs to be completed after the
vehicle is received by the BMW center.
Safety Belt Warranty - Kansas
Safety belts are covered under the BMW New
Vehicle Limited Warranty for defects in material
or workmanship for a period of 10 years, unlim-
ited mileage from the date of purchase. In order
to be eligible for this coverage, the vehicle must be a new car retailed in the State of Kansas and
the repair performed by an authorized BMW
center in Kansas.
Other Items
Wheel alignment, balancing and wiper blade
inserts are covered up to 2,000 miles.
Items which are subject to wear and tear or
deterioration due to driving habits or condi-
tions, such as brake pads/linings, brake
discs, clutch disc, pressure plate, filters,
upholstery, trim and chrome items, paint fin-
ish, drive belts, glass, and similar items, are
specifically limited to defects in material or
workmanship.
This warranty does not apply to the
following:
Damage which results from negligence,
improper operation of the vehicle, improper
repair, lack of or improper maintenance, environ-
mental influences, flood, accident or fire dam-
age, road salt corrosion, or use of improper or
contaminated fuel.
Maintenance services and parts when replaced
during maintenance such as spark plugs, lubri-
cants, fluids, engine tuneup parts, replacement
of filters, coolant, and refrigerant.
Failure to maintain the vehicle properly in accor-
dance with the instructions in the Owner’s Man-
ual or the Service section of this Statement, that
results in the failure of any part of the vehicle.
Modification of the vehicle or installation of any
performance accessories or components
attached to the vehicle which alters the original
engineering and/or operating specifications or
which result in damage to the other original
components, electrical interference, electrical
short, radio static, water leaks and wind noise.
Tires are warranted by their respective manufac-
turer as detailed in the applicable tire manufac-
turer’s warranty statements. Instructions for
proper tire care and maintenance are contained
in the Owner’s Manual. Should you experience
difficulty in obtaining warranty service from a tire
manufacturer, your authorized BMW center will
assist you in resolving the difficulty.
29

The following systems are covered by the Fed-
eral Emission Performance Warranty for a period
of two years or 24,000 miles, whichever occurs
first. The specific systems may vary according to
model, therefore, all of the systems listed may
not be used on your vehicle. For assistance in
determining which systems and specific compo-
nents within these systems apply to your vehi-
cle, please contact your BMW center.
AIR INDUCTION SYSTEM
FUEL METERING SYSTEM
IGNITION SYSTEM
POSITIVE CRANKCASE VENTILATION SYS-
TEM (PCV)
FUEL EVAPORATIVE CONTROL SYSTEM
EXHAUST SYSTEM
ENGINE EMISSION CONTROL SYSTEM
SENSORS/DEVICES
ON BOARD DIAGNOSTIC SYSTEM (OBD)
RELATED PARTS ASSOCIATED WITH THE
ABOVE SYSTEMS
The following components and/or system are/is
covered under the Federal Emission Perfor-
mance Warranty for a period of 8 years or
80,000 miles, whichever occurs first.
CATALYTIC CONVERTER
ENGINE CONTROL MODULE (INCLUDING ON-
BOARD DIAGNOSTIC SYSTEM)
For assistance in determining coverage of the
specific components of the on-board diagnostic
system, please contact your BMW center.
35

California Emission Control
Warranty Statement* Your
Warranty Rights and Obligations
The California Air Resources Board and BMW of
North America, LLC (BMW NA) are pleased to
explain the emission control system warranty on
your 2008 vehicle. In California, new motor vehi-
cles must be designed, built and equipped to
meet the State’s stringent anti-smog standards.
BMW NA must warrant the emission control
system on your vehicle for the periods of time
listed below provided there has been no abuse,
neglect or improper maintenance of your
vehicle.
Your emission control system may include parts
such as the fuel injection system, the ignition
system, catalytic converter, and engine com-
puter. Also included may be hoses, belts, con-
nectors and other emission-related assemblies.
Where a warrantable condition exists, BMW NA
will repair your vehicle at no cost to you includ-
ing diagnosis, parts and labor.
Manufacturer’s Warranty Coverage:
– For 3 years or 50,000 miles whichever occurs first:
1. If your vehicle fails a Smog Check inspec- tion, all necessary repairs and adjustments
will be made by BMW NA to ensure that
your vehicle passes the inspection. This is
your emission control system PERFOR-
MANCE WARRANTY.
2. If any emission-related part on your vehicle is defective, the part will be repaired or
replaced by BMW NA. This is your short-
term emission control system DEFECTS
WARRANTY.
For 7 years or 70,000 miles whichever occurs
first:
If an emission-related part, specially noted on
page 39 as having coverage for 7 years or
70,000 miles is defective, the part will be
repaired or replaced by BMW NA. This is your
long-term emission control system DEFECTS
WARRANTY.
Owner’s Warranty Responsibilities:
– As the vehicle owner, you are responsible for the performance of the required maintenance
listed in your Owner’s Manual. BMW NA rec-
ommends that you retain all receipts covering
maintenance on your vehicle, but BMW NA
cannot deny warranty solely for the lack of
receipts or for your failure to ensure the perfor-
mance of all scheduled maintenance.
– You are responsible for presenting your vehicle to an authorized BMW center as soon as a
problem exists. The warranty repairs should be
completed in a reasonable amount of time, not
to exceed 30 days.
– As the vehicle owner, you should also be aware that BMW NA may deny your warranty
coverage if your vehicle or part has failed due
to abuse, neglect, improper maintenance or
unapproved modifications.
If you have any questions regarding your war-
ranty rights and responsibilities, you should
contact: BMW of North America, LLC
Customer Relations and Services Department
PO. Box 1227
Westwood, N.J. 07675-1227
Telephone: 1 800 831-1117
Website: www.bmwusa.com
or the California Air Resources Board
9528 Telstar Avenue
El Monte, CA 91731
*The California Emissions Control System Lim-
ited Warranty applies to all 2008 U.S. specifica-
tion BMW vehicles sold, leased, and/or
registered in California, Connecticut, Maine,
Massachusetts, Rhode Island or Vermont.
36

California Emission Warranty Parts
List
The following components are covered for
defects by the California Emission Control Sys-
tem Limited Warranty for a period of 7 years or
70,000 miles, whichever comes first.
Component Z4 M
Coupe,
Roadster
Camshaft Adjustment Unit •
Engine Control Module •
Exhaust Manifold Gasket •
Exhaust Manifold w/ Catalyst •
Exhaust Pipe w/ Catalyst •
Fuel Pump •
Fuel Tank •
Idle Speed Control Valve •
Intake Air Plenum •
Oxygen Sensor, Rear (Monitor) •
Pressure Regulator w/ Fuel Filter •
Seal, Fuel Pump/Level Sensor •
Throttle Actuator •
Throttle Body •
Throttle Body Gasket •
VANOS Camshaft Position Control •
VANOS Solenoid Valve •
Notice
The “National Traffic & Motor Vehicle Safety Act
of 1966” requires manufacturers to be in a posi-
tion to contact the vehicle owners when a cor-
rection of a product defect becomes necessary.
Please fill in the attached postcard if you change
your address or purchase a used BMW.
Tire Warranty Statement
Tires are warranted by their respective manufac-
turer as detailed in the applicable tire manufac-
turer’s warranty statements. Instructions for
proper tire care and maintenance are contained
in the Owner’s Manual. Should you experience
difficulty in obtaining warranty service from a tire
manufacturer, your authorized BMW center will
assist you in resolving the difficulty.
39