2008 Abarth Grande Punto brake

174
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
WINDSCREEN/REAR
WINDOW WIPERS
BLADES
Periodically clean the rubber part using
special products; TUTELA PROFES-
SIONAL SC 35is recommended.
If the rubber blades are bent or worn they
should be replaced. In any case they
should be changed once a year.
A few simple notions can reduce the pos-
sibility of damage to the blades:
❒ if the temperature fall below zero,
make sure that ice has not frozen the
rubber against glass. If necessary, thaw
using an antifreeze product;
❒ remove any snow from the glass: in ad-
dition to protecting the blades, this pre-
vents effort on the motor and over-
heating;
❒do not operate the windscreen wipers
on dry glass.
RUBBER HOSES
As far as the brake system and fuel rubber
hoses are concerned, carefully follow the
“Service schedule” in this section.
Indeed ozone, high temperatures and pro-
longed lack of fluid in the system may
cause hardening and cracking of the hoses,
with possible leaks. Careful control is
therefore necessary.If the pressure is too low the
tyre overheats and this can
cause it serious damage.
WARNING
Do not cross switch the
tyres, moving them from the
right of the car to the left and vice
versa.
WARNING
Never submit alloy rims to
repainting treatments re-
quiring to use temperatures exceed-
ing 150°C. The mechanical properties
of the wheels could be impaired.
WARNING
Driving with worn wiper
blades is a serious hazard,
because visibility is reduced in bad
weather.
WARNING

181
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IDENTIFICATION DATA ................................................. 182
ENGINE CODES - BODYWORK VERSIONS ............... 184
ENGINE .................................................................................. 184
FUEL FEED/IGNITION ....................................................... 185
TRANSMISSION .................................................................. 185
BRAKES................................................................................... 186
SUSPENSIONS....................................................................... 186
STEERING ............................................................................... 186
WHEELS.................................................................................. 187
DIMENSIONS......................................................................... 190
PERFORMANCE ................................................................... 191
WEIGHTS............................................................................... 191
CAPACITIES .......................................................................... 192
FLUIDS AND LUBRICANTS .............................................. 193
FUEL CONSUMPTION....................................................... 195
CO
2EMISSIONS .................................................................. 196
T T
E E
C C
H H
N N
I I
C C
A A
L L

S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S

186
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
SUSPENSIONS
1.4 T-JET
Front
Rear
BRAKES
1.4 T-JET
Service brakes
– front disc
– rear disc
Parking brake controlled by hand lever, it works on rear brakes
IMPORTANT Water, ice and antifreeze salt on roads may deposit on the brake discs thus reducing braking efficiency at first brak-
ing.
Mc Pherson independent wheels
twisting axle with interconnected wheels
STEERING
1.4 T-JET
Type rack and pinion with electric power steering
Minimum steering
cycle m 11

191
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
PERFORMANCE
Top admitted speed after initial car use in km/h.
1.4 T-JET
208
Weights (kg)1.4 T-JET
Empty weight (including all fluids, fuel tank at 90% and with no optional): 1185
Payload (*) including the driver: 480
Maximum admitted loads (**)
– front axle:950
– rear axle:850
– total: 1665
Towable loads
– trailer with brakes:500
– trailer without brakes: 400
Maximum load on roof: 75
Maximum load on tow hitch (trailer with brakes): 60
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
(**) Loads not be exceeded. The driver is responsible for arranging the loads in the boot and/or on the roof so that they comply with these
limits.
WEIGHTS

192
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.4 T-JET
45
5 ÷ 7
6
2.4
2.6
2
0.5
2.2
CAPACITIES
Fuel tank: litresincluding a reserve of: litres
Engine cooling system: litres
Engine sump: litresEngine sump and filter: litres
Gearbox/differential casing litres
Hydraulic brake circuit: kg
Windscreen, rear window
andheadlight washer litres
(❑) For particularly hard climate conditions, we recommend use of a 60% Paraflu UP and 40% demineralized water mixture.
Specified fuels and
original lubricants
Unleaded petrol with no less than 95 R.O.N.
(EN 228 Specification)
Mixture of 50% water and
PARAFLU UP
(❑)
SELENIA ABARTH 10W50
TUTELA CAR MATRYX
TUTELA TOP 4
Mixture of water and
TUTELA PROFESSIONAL SC 35

Lubricants and
greases for
transmission
194
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Use Fluid and lubricant specifications Original fluids and Applicationsfor correct car operation lubricants
Brake fluids
Protective agent
for radiators
Windscreen/
rear window
washer fluid
(*) IMPORTANT Do not top up or mix with fluids having characteristics different from those specified.
(❑) For particularly hard climate conditions, we recommend use of a 60% Paraflu UP and 40% demineralized water mixture. LSynthetic-based oils, grade SAE 75W- 85
that passes API GL4 PLUS specifications.
Grease containing Molybdenum bisulphide for high
temperature appliances. N.L.G.I. 1-2 consistency.
Specifc grease to be used for constant-velocity joints with
low friction coefficient. N.L.G.I. 0-1 consistency.
Synthetic fluid FMVSS no. 116 DOT 4, ISO 4925 SAE
J1704, CUNA NC 956- 01
Red protective with antifreeze action, based on inhibited
monoethylen glycol with organic formula based on O.A.T,
that passes CUNA NC 956-16, ASTM D 3306
specifications.
Mixture of alcohol, water and surfactants CUNA NC
956-II
TUTELA CAR
MATRYX
Contractual
Technical Reference
N° F108.F02
TUTELA
ALL STAR
Contractual
Technical Reference
N° F702.G07
TUTELA
STAR 325
Contractual
Technical Reference
N° F301.D03
TUTELA TOP 4
Contractual
Technical Reference
N° F001.A93
PARAFLU UP (*)
Contractual
Technical Reference
N° F101.M01
TUTELA
PROFESSIONAL
SC 35
Contractual
Technical Reference
N° F201.D02Mechanical gearbox
and differential
CV joints
on wheel side
CV jointùs on
differential side
Brake and clutch
hydraulic controls
Radiator antifreeze
proportion:
50% water and 50%
PARAFLU UP
(❑)
To be used diluted
or undiluted in
windscreen/rear
window washer/wiper
systems

197
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
– version codes ............................... 184
Bonnet .................................................. 71
Boot ........................................................ 68
– extension ........................................ 69
– tailgate opening/closing ............... 68
– emergency opening....................... 69
Boot light .............................................. 55
Brake Assist (brake assist
in an emergency)............................... 78
Brakes
– fluid level ........................................ 169
– technical data ................................ 186
Bulb (replacement)
– general instructions ..................... 139
– types of bulbs ................................ 139
Car inactivity ...................................... 120
Car maintenance
– periodical checks........................... 165
– scheduled servicing ...................... 162
– service schedule ........................... 163
– use of the car under heavy
conditions ........................................... 165Card box - CD box............................. 60
Carrying children safely ..................... 97
Ceiling lights
– front ................................................ 54
– puddle/door .................................. 55
Central console oddment
compartment ..................................... 58
Child restraint systems
– “Universal Isofix” ......................... 102
Cigar lighter .......................................... 60
Clutch ................................................... 185
CO
2emissions...................................... 196
Code Card ........................................... 8
Consumption
– engine oil ........................................ 167
– fuel ................................................... 195
Control buttons .................................. 55
Correct use of the car ...................... 127
Cruise Control ..................................... 52
Digital display ..................................... 16
Dimensions .......................................... 190
ABS ...................................................... 76
Accessories purchased
by the owner .................................... 88
Air bag
– front ................................................. 103
– side .................................................. 106
Air filter ................................................ 170
Air vents ............................................... 34
Alarm...................................................... 11
Armrest................................................. 59
Ashtray................................................... 60
ASR ......................................................... 81
– activation/deactivation ................. 82
Automatic two-zone climate
control system .................................. 40
Battery
– checking the charge ..................... 171
– jump starting ................................. 134
– recharging ...................................... 157
Bodywork
– maintenance .................................. 176
I I
N N
D D
E E
X X

198
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Fiat CODE system............................. 7
Fix & Go automatic ............................ 135
Fluid levels ............................................ 166
Fluids and lubricants ........................... 193
Front ceiling lights
– bulb replacement ........................... 146
– control ............................................ 54
Front fog lights
– bulb replacement .......................... 143
– control button .............................. 55
Fuel
– consumption................................... 195
– cut-off system................................. 57
– level gauge ....................................... 15
Fuel cut-off system.............................. 88
Fuel filler cap ....................................... 89
Fuel level gauge ................................... 15
Fuses (replacement) ........................... 148
Gearbox
– using manual gearbox .................. 113
Glove box/oddment compartment .. 59
Handbrake .......................................... 112Hazard lights ........................................ 55
Head restraints..................................... 30
Headlights.............................................. 74
Heated rear window .......................38-46
Identification data .............................. 182
Ignition switch ..................................... 13
In an emergency .................................. 134
Instrument panel ................................. 13
Instruments .......................................... 14
Interior fittings .................................... 179
Interiors ................................................ 179
Isofix (child restraint system) .......... 102
Jacking the car .................................... 158
Key with remote control ................ 8
Key without remote control ........... 10
Keys ........................................................ 8
Load limiters ...................................... 94
Manual climate control system ...... 34
Number plate light ............................ 145 Dipped beam headlights
– bulb replacement ........................... 142
– control ............................................ 47
Direction indicators
– control ............................................ 48
– front bulb replacement ............... 142
– rear bulb replacement ................. 143
– side bulb replacement ................. 143
Doors ..................................................... 64
Electrical socket ................................ 60
Engine
– identification code ........................ 184
– marking ........................................... 182
– technical data ................................ 184
Engine coolant temperature gauge .. 15
Engine oil
– consumption .................................. 167
– level check....................................... 167
– specifications ................................. 193
EOBD system ...................................... 83
ESP system............................................ 78
External lights ...................................... 47