2008 Abarth 500 technical specifications

114
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
IF AN INTERIOR LIGHT
BURNS OUT
For the type of bulb and power rating, see
“When needing to change a bulb”.
INSIDE CEILING LIGHT
To change the bulb, proceed as follows:
❒using the screwdriver provided, extract
the ceiling light A-fig. 32working in the
point indicated by the arrow;
NUMBER PLATE LIGHTS fig. 31
To replace the bulbs proceed as follows:
❒work in the point shown by the arrow
and remove lens A;
❒change the bulb releasing it from the
side contacts and making sure the new
bulb is correctly fastened between the
contacts;
❒reinstall the lens. THIRD BRAKE LIGHT fig. 29-30
To change the bulb proceed as follows:
❒remove the two guard caps and un-
screw the two fastening screws A;
❒withdraw the assembly;
❒disconnect the electric connector B;
❒press the retaining device Cand open
the bulb holder;
❒remove the snap-fitted bulb to be re-
placed and replace it;
❒close back the cap locking it properly.
❒screw in the two fastening screws and
reinstall the guard caps;
fig. 30F0S103Abfig. 29F0S102Ab
fig. 31F0S104Ab
095-122 ABARTH 500 GB 29-04-2009 9:43 Pagina 114

115
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
❒open the cap B-fig. 33as indicated;BOOT LIGHT
To change the bulb, proceed as follows:
❒open the tailgate;
❒using the screwdriver provided, extract
the ceiling light A-fig. 35working in the
specified point;
❒replace bulb C-fig. 34releasing it from
the side contacts, then insert the new
bulb making sure it is correctly clamped
between the contacts;
❒close the cap back and reinstall the lens.
fig. 32F0S105Ab
fig. 33F0S106Ab
fig. 34F0S107Abfig. 35F0S108Ab
095-122 ABARTH 500 GB 29-04-2009 9:43 Pagina 115

116
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
IF A FUSE BLOWS
GENERALITIES fig. 37
The fuse is a protective device for the
electric system: it comes into action (i.e.
it cuts off) mainly due to a fault or im-
proper action on the system.
Check the efficiency of the corresponding
fuse when a device does not work: the
conducting element Amust not be inter-
rupted. If it is, replace the blown fuse with
another with the same amperage (same
colour).
Bintact fuse.
Cfuse with damaged filament.
To identify the protection fuse, see the
tables in the following pages.
❒open the bulb cover B-fig. 36and re-
place the snap-fitted bulb C;
❒re-close the bulb cover Bon the lens;
❒reinstall the ceiling light properly in-
serting it into its seat on one side first,
and then pressing the other side until it
clicks into position.Never replace a blown fuse
with metal wires or other ma-
terials.
Never replace a fuse with
another having higher am-
perage; FIRE HAZARD.
In case of general protection fuse in-
tervention (MEGA-FUSE, MIDI-FUSE,
MAXI-FUSE) contact Abarth Dealer-
ship.
Remove the key from the ignition
switch and switch off all loads before
replacing a fuse.
WARNING
Should the fuse blow again,
contact Abarth Dealership.
WARNING
fig. 36F0S109Abfig. 37F0S110Ab
095-122 ABARTH 500 GB 29-04-2009 9:43 Pagina 116

117
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
FUSE LOCATION
Dashboard fuses
To access the fuses you must remove the
snap-fitted cover E.
The 5A fuse for door mirror demisting is
located in the diagnostic socket area, as
shown in fig. 38.
In the bottom area, near the pedals, you
can find the control unit shown in fig. 39.
fig. 38
E
F0S111Ab
fig. 39F0S112Ab
095-122 ABARTH 500 GB 29-04-2009 9:43 Pagina 117

118
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
Engine compartment control unit
fig. 40 e 41
A second control unit is located on the
right side of the engine compartment, next
to the battery; to access it press device I,
release tabs Mand remove cover L.
The ID number of the electrical compo-
nent corresponding to each fuse can be
found on the back of the cover.
If you need to wash the en-
gine compartment, take care
not to directly hit the engine
compartment control unit
with the water jet.
fig. 40
fig. 41F0S113Ab
F0S114Ab
095-122 ABARTH 500 GB 29-04-2009 9:43 Pagina 118

119
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
F12
F13
F31
F32
F36
F37
F38
F43
F47
F48
F49
F50
F51
F537.5
7.5
5
7.5
10
5
20
15
20
20
5
7.5
7.5
5
F08
F09
F10
F11
F14
F15
F16
F17
F18
F1830
15
15
10
15
20
7.5
10
7.5
7.5
FUSE TABLE
Fuse box on dashboard - fig. 39FUSE AMPERE
Supply of right low beam
Supply of left low beam and headlamp direction adjustment control unit
Engine compartment shunt control unit switch
Lights of front and rear ceiling lights, trunk and door courtesy lights
Diagnostic socket, car radio, climate control system, EOBD
Stop lights switch, instrument panel node
Door central locking
Windshield/Rear windshield washer pump
Driver side power window
Passenger side power window
Backlighting switches, electric mirrors
Air bag node
Car radio switch, convergence, climate control system, stop lights, clutch
Instrument panel node
Engine compartment control unit - fig. 41FUSE AMPERE
Climate control system fan
Spare
Buzzers
Engine control system (secondary loads)
Main headlights
Sunroof motor
+15 Engine control unit, relay coil T20
Engine control unit
Spare
Engine control unit, relay T09 coil
095-122 ABARTH 500 GB 29-04-2009 9:43 Pagina 119

120
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
20
20
20
30
50
30
30
20
20
30
30
30
50
30 T02
T03
T05
T06
T07
T08
T09
T10
T14
T17
T19
T20
T30
T31F19
F20
F21
F22
F22
F23
F24
F30
F84
F85
F877.5
30
15
15
20
20
7.5
15
10
15
7.5
Engine compartment control unit - fig. 41FUSE AMPERE
Conditioner compressor
Heated rear window, mirror demisters
Fuel pump
Ignition coil
Engine control unit
Braking system (control unit, valves)
+15 Braking system, electrical driving, yaw sensor
Fog headlights
Spare
Front socket (with or without cigar lighter plug)
+15 for backing lights, T02, T05, T14 and T19 relay coils
Engine compartment control unit - fig. 41RELÉ AMPERE
Main headlights
Buzzers
Conditioner compressor
One-speed engine cooling fan - Low speed engine cooling fan
High-speed engine cooling fan
Climate control system fan
Engine control system (main relay)
Spare
Fog headlights
Fuel pump
Demisting
Spare
Spare
Front socket (with or without cigar lighter plug)
095-122 ABARTH 500 GB 29-04-2009 9:43 Pagina 120

121
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
IF THE BATTERY IS FLAT
IMPORTANT The battery recharging pro-
cedure is provided as an example only.
You are recommended to go to a Abarth
Dealership to have this operation per-
formed.
Low amperage slow recharging for ap-
proximately 24 hour is advised. A pro-
longed recharge might damage the battery.
Charge the battery as follows:
❒disconnect battery negative terminal;
❒connect the charger cables to the bat-
tery terminals, observing the poles;
❒turn on the charger;
❒when you have finished, turn the charg-
er off before disconnecting the battery;
❒reconnect battery negative terminal.
Battery fluid is poisonous
and corrosive: avoid contact
with your skin and eyes. The battery
recharging operation must be per-
formed in a ventilated place, away
from naked flames or possible sources
of sparks to avoid the risk of explo-
sion and fire.
WARNING
Don’t try to recharge a
frozen battery: defrost it first
to prevent the risk of explosion. If a
battery was frozen, have it inspect-
ed by specialised personnel before
recharging to check that the internal
elements are not damaged and that
the casing is not cracked causing the
risk of leakage of poisonous, corrosive
gas.
WARNING
RAISING THE CAR
As a result of its sporty nature, the car is fit-
ted with aerodynamic spoilers at the bot-
tom and miniskirts at the side. If the vehi-
cle needs to be raised, go to an Abarth
Dealership which is equipped with arm lifts
and workshop lifts.
Take special care when posi-
tioning the arm lifts or the
workshop lift in order not to
damage the aerodynamic
spoilers and miniskirts.
fig. 41a
169,5 mm 150,7 mm
F0S139Ab
095-122 ABARTH 500 GB 29-04-2009 9:43 Pagina 121