2007 YAMAHA YD110 recommended oil

CAUTION :
•Make sure the air filter is
properly seated in the air filter
case.
• The engine should never be run
without the air filter installed.
Excessive piston and/or
cylinder wear may result.
• Dirty Element Air Cleaner
causes excessive fuel
consumption and loss of
power.
• Clean Element Air Cleaner after
every 2000 kms.
• The Element Air Cleaner should
be cleaned and lubricated more
frequently (every 1000 km,s), if
Motorcycle is operated in very
dusty (e.g. unpaved, dust laden
roads) conditions. lko/kkuh %•
;g lqfufpr djsa fd ,;j&fQYVj
lgh tk,A
excess oil. They should be wet
but not dripping.çR;sd ewy Hkkx dh van#uh lrg ij
çLrkfod rsy gh yxk, v©j Qkyrw
rsy ds fupksM+ ysA os ¼ewy Hkkx½ xhys
gksus pkfg, u fd rsy esa Mwcs gq,A
6.15
PERIODIC MAINTENANCE AND MINOR REPAIR
lkef;d j[kj[kko rFkk ekewyh ejEer
Recommended oil
çLrkfod rsy :
20W40 type SG
7. Pull the air filter elements over
the frame and install the air filter
in the case.
,;j&fQYVj ds ,yhesaV ¼ewy&fgLlksa½
dks Ýse ds Åij ls [khap ys rFkk
,;j&fQYVj dks dsl ds vanj yxk nsaA
8. Install the Spring Wire.
¯Lçx okW;j Hkh yxk,¡A
9. Install the air filter case cover and
panel
,;j&fQYVj dsl ds doj v©j iSuy
dks yxk nsaA
CAUTION :

Do not twist Element Air Cleaner.lko/kkuh
:
,;j&fQYVj ,fyesaV dks u ?kqek;saA WARNINGEnsure no distortion/proper
positioning of felt seal 1 if damaged
contact YMIS dealer.
psrkouh
QsYV lhy
1 lgh rjg ls yx;sa vxj [kjkc
gks rks okbZñ ,eñ vkbZñ ,lñ ds Mhyj ls laidZ
djsaA1
PG1_55.pmd10/17/2006, 8:31 AM 53

Throttle cable and grip
lubricationFkzkWVy dscy v©j fxzi Y;wczhdsV
djukAThe throttle twist grip assembly
should be greased at the time that
the cable is lubricated, since the
grip must be removed to get at the
end of the throttle cable. After
removing the screws, hold the end
of the cable up in the air and put in
several drops of lubricant. With the
throttle grip disassembled, coat the
metal surface of the grip assembly
with a suitable all purpose grease.ftl le; dscy dks Y;wczhdsaV fd;k tkrk
gS mlh le; ^FkzkWVy V~foLV fxzi vlsEcyh*rkj¨a d¨ tax&çfrj¨/kh rsy rFkk dscy ds
fdukj¨a ls yqczhdsV djsaA ;fn dscy lgh rjhds
ls dke ugh dj jgh g¨ r¨ okbZñ,eñvkbZñ,lñ
Mhyj ls bls cnyrs d¨ dgsaA
dh fxzlhax Hkh dh tkuh pkfg,A FkzkWVy dh
dscy ds fljs ds fy, FkzkWVy fxzi dks
[kksysaA isp gVkus ds ckn rkj ¼dscy½ ds
,d fljs ¼fdukjs½ dks gok esa idM+s jgsa
vkSj ml ij Y;wczhdsaV dh cgqr lh cwansa
MkysaA FkzkWVy fxzi dks [kksyus ¼vyx&vyx
djus½ ds lkFk fxzi vlsEcyh dks /kkrq ds
ry ij ;Fkk;ksX;] cgqmís'kh; ¼vkWy ijit+½
xzhl dh dks¯Vx dj nsaA
Cable inspection and
lubricationdscy dk fujh{k.k ,oa Y;wczhds'ku WARNINGDamage to the outer housing of
cables may lead to internal
rusting and interfere with the
cable movement. Replace
damaged cables as soon as
possible to prevent unsafe
conditions. psrkouhdscy ¼rkj¨a½ dh ckgjh gkůlx ds
{kfrxzLr g¨us ls ;g vanj ls tax idM+
ldrh gS v©j blls dscy d¨ Åij uhps
ewoesaV djus esa eqf'dy vk ldrh gSA
vlqjf{kr fLFkfr;¨a ¼gkykr¨aa½ ls cpus ds
fy, {kfrxzLr rkj¨a ¼dscy½ d¨ ftruh
tYnh g¨ lds cny nsaALubricate the cables and cable
ends with anticorrosive oil . If a
cable does not operate smoothly,
ask a YMIS dealer to replace it.Recommended lubricant
çLrkfod yqczhdsVj %20W40 Type SG
6.29
PERIODIC MAINTENANCE AND MINOR REPAIR
lkef;d j[kj[kko rFkk ekewyh ejEer
pg56_96.pmd10/15/2006, 8:53 AM 65

If the owner of the Vehicle does not comply with above legal requirement, the Vehicle may be
deregistered or penalty may be imposed by the authorities.;fn okgu&ekfyd mij¨Dr dkuwuh ek¡x d¨ Lohdkj ugh djrk gS r¨ okgu dk iathdj.k jí g¨ ldrk gS vFkok
ml ij tqekZuk yxk;k tk ldrk gSAThe following points may be checked and suitable corrective action if required, to ensure emission levels to remain
within acceptable limits.,eh'ku Lrjksa dks Lohdkjh; lhekvksa ds varxZr cuk;s j[kus ds fy, fuEufyf[kr rF;ksa dj tk¡p djsa o vko';d gks rks la'kks/ku
ds yh, dk;Zokgh djsaA1. Clean and oil Air Filter Element periodically and replace it when required.
le;≤ ij ,;j fQYVj ds ,syhesaV d¨ lkQ djsa v©j blesa rsy Mkyrs jgsa rFkk tc vko';drk iMs+ r¨ bls cny nsaA
2. Clean, inspect and adjust spark Plug Gap periodically.
le;≤ ij LikdZ Iyx dh tk¡p djsa] bls lkQ djsa v©j blds xSi ¼varj½ d¨ ,MtLV djsaA
3. Use only recommended Spark Plug. Replace it as per recommendations.
dsoy çLrkfor LikdZ Iyx dk gh ç;¨x djsaA çLrkfod ekin.M¨ ds vuq:i gh u;k Iyx yxk;saA
4. Use only recommended grade (SG) of genuine engine oil of superior quality.
dsoy mPp DokfyVh dk çLrkfor xzsM ¼
SG
½ dk vlyh batu rsy gh ç;¨x djsaA
5. Get your Vehicle serviced and tuned periodically as per recommended schedule.
çLrkfor f'kM~;wy ds eqrkfcd le;≤ ij vius okgu dh l£ol v©j V~;w¯ux djkrs jgsaA
6. Use unadulterated Petrol.
feykoV jfgr iSVª¨y dk ç;¨x djsaaA SAFETY NORMS
9.3
lqj{kk&flðk¡r
pg97_103.pmd10/17/2006, 8:35 AM 97

3. Part(s) of the Motorcycle that have been subjected to misuse, accident, negligent treatment or which have
been used in conjunction with parts and equipment not manufactured or recommended for use by YAMAHA
such use prematurely affects the performance and reliability of the motorcycle.
eksVjlkbZfdy ds ikV~Zl ftudk nq:i;ksx fd;k x;k gks] nq?kZVuk ls [kjkc gq, gks ;k ykijokgh&NsM+ NkM+ dh xbZ gks vFkok ftUgs nwljs
ikVZ~l rFkk midj.kks ds lkFk tksM+ dj ç;ksx fd;k x;k gks ftUgsa ;kekgk }kjk çLrkfor vFkok fu£er ugh fd;k x;k gks] bl rjg ls bu
ikVZl dk vlkef;d nqji;ksx eksVjlkbZfdy dh dk;Zdq
'kyrk v©j fo
'oluh;rk dks çHkkfor djrk gSA
4. Use of non-genuine parts, non-genuine oil and lubricants.
udyh Y;qczhdsaVl] rsy rFkk udyh ikVZl dk ç;ksxA
5. Parts of the Motorcycle getting rusty due to atmospheric effects because of Industrial Pollution.
eksVjlkbZfdy ds os ikVZ~l tks fd v©|ksfxd çnw
"k.k ds dkj.k gksus okys okrkoj.k ds çHkkoksa dh otg ls tax idM+ ysrs gSA
6. Parts of Motorcycle that have been altered and modified or replaced in unauthorised manner and which in
the sole judgement of YAMAHA affects its performance and reliability.
eksVjlkbZfdy ds os ikVZ~l ftUgs vuf/kÑr :i ls ifjo£rr fd;k x;k gks] lq/kkjk x;k gks vFkok cnyk x;k gks v©j tks ;kekgk ds fu.kZ;
ds varxZr eksVjlkbZfdy dh dk;Zdq
'kyrk rFkk fo
'oluh;rk ij çHkko Mkyrs gksaA
7. Motorcycle that has not been got serviced by YAMAHA’S Authorised Dealers as per the service schedule
described in this Owner’s Manual vide the 6 Free Services, 2 Bonus Services and 7 Paid Service Coupons
(attached in this book) or which has not been operated or maintained in accordance with the instructions
mentioned in this Manual (especially during Running in Period).
xzkgd iqfLrdk esa fn, x,
6 Ýh l£ol dwiuksa]
2 cksul Ýh l£ol dwiuks v©j
7 Hkqxrku l£ol dwiuks ¼tks bl iqfLrdk ds lkFk layXu gS½
vFkok bl eSuqvy ¼fo'ks"k :i ls Þj¯ux&buß ihfj;M+ esa½ esa fn, lfoZl ds fu/kkZfjr le; ds vuqlkj lkekU; ,oa ejEer ds dk;Z ds fy,
;fn eksVjlkbZfdy dks ;kekgk ds vf/kÑr Mhyj ls *l£ol^ ugh djk;k x;k gksA
WARRANTY
okjaVh
9.8
pg97_103.pmd10/17/2006, 8:35 AM 102

8. Motorcycle used for any competition or race and/or for attempting to set up any kind of record. YAMAHA
undertakes no liability in the matter of any consequential loss or damage caused due to failure of the
part(s).
eksVjlkbZfdy ls ;fn fdlh çfr;ksfxrk vFkok n©M+ vFkok blls fdlh rjg dk dksbZ fjdkMZ dk;e djus dk ç;Ru fd;k x;k gks rks ;kekgk
bl ekeys esa ikVZl@daiksusaV ds [kjkc gksus ds dkj.k fdlh rjg ds uqDlku
vFkok {kfr ds fy, mÙkjnk;h ugh gksxhA
9. For motorcycles which have been used for any commercial purposes & Loading such as taxi etc.
eksVjlkbZfdy dk ;fn O;kolkf;d dk;ks± ;k VSDlh bR;kfn esa iz;ksx fd;k x;k gks
10. For normal phenomenon like noise, vibration, oil seepage, which do not affect the performance of the
Motorcycle?
lkekU; ?kVuk;sa tSls vkokt+] daiu] rsy dk fjlko bR;kfn ftuls eksVjlkbZfdy dh dk;Zdq'kyrk eas dksbZ izHkko ugh iM+rkA
11. For maintenance repairs required due to misuse while driving or due to adulteration of oil, petrol or due to
bad road conditions.
,slh ejEer ftudks dkj.k pykrs le; bldk lgh bLrseky u djuk] rsy] iSVªksy esa feykoV ;k lM+dksa dh [kLrk gkyr gksA
12. If any part of the vehicle is tampered / repaired by unauthorised persons/workshops etc.
;fn xkM+h ds dksbZ Hkh IkkVZ ds lkFk NsM+ NkM+ dh xbZ gks ;k bldh ejEer fdlh vuf/kÑr odZ'kkWi ;k vkneh }kjk dh xbZ gksA
13. For consumables like oil, grease etc. used during free services or used during warranty repairs.
okjaVh ;k eq¶r lfoZl esa iz;ksx dh x;s vkW;y ;k xzht+ bR;kfnA
14. If there is any damage due to modification or fitting of accessories other than the ones recommended by
YAMAHA.
;fn dksbZ ifjoZru ;k ,slh vLlsjht+ tks ;kekgk }kjk funsZf'kr ugha gSa ftuds }kjk dksbZ [kjkch vkbZ gksA
WARRANTYokjaVh
9.9
pg97_103.pmd10/17/2006, 8:35 AM 103

JOBS TO BE CARRIED OUT DURING FIFTEENTH PAID SERVICE 1. Note down the customer’s observations.
2. Wash Motorcycle and blow it dry with compressed air.
3. Clean Spark Plug and reset the gap if necessary.
4. Check Valve clearance, adjust if necessary.
5. Clean and tune Carburettor, set the idle RPM, as recommended. Check for the easy operation of Choke Lever.
6. Open and clean Fuel Cock and Fuel Filter. Check for any cracks or damage on Fuel Hose.
7. Clean Air Filter Element and lubricate it with (4T) oil.
8. Replace Engine Oil and check for any leakages.
9. Wash Engine Oil Filter Screen with petrol.
10. Check operation of Front & Rear Brakes, adjust if necessary. Grease the Brake Cam.
11. For proper Clutch functioning, check alignment marks on Crank Case L.H., Adjust if necessary.
12. Check for Wheel Runout/Spokes looseness, repair if necessary.
13. Check Wheel Bearings (Front & Rear) for looseness, damage.
14. Check for Steering looseness / tightness, adjust if required.
15. Check Front Fork operation / oil leakages, repair if reqrired.
16. Check for Rear Shock Absorber operation.
17. Check Chain Slackness, alignment. Adjust if necessary. Clean and lubricate.
18. Clean Battery, check electrolyte level and proper routing of Breather Pipe.
19. Tighten all Nuts and Bolts. Specially, Cylinder Head, Engine Mounting, Rear Swing Fork, Front & Rear Wheel
Axles & Rear Shock Absorber Mountings to the specified torque.
20. Check all electrical operations.
21. Check and correct air pressure in Front and Rear Tyres.
22. Lubricate all the pivot points.
23. Check exhaust emission for ‘CO’ level at idling, correct if required.
24. Clean and polish Motorcycle after taking ROAD TEST.
10-2
DETGREEN.pmd10/15/2006, 8:50 AM 2

JOBS TO BE CARRIED OUT DURING FOURTEENTH PAID SERVICE 1. Note down the customer’s observations.
2. Wash Motorcycle and blow it dry with compressed air.
3. Clean Spark Plug and reset the gap if necessary.
4. Check Valve clearance, adjust if necessary.
5. Clean and tune Carburettor, set the idle RPM, as recommended. Check for the easy operation of Choke Lever.
6. Open and clean Fuel Cock and Fuel Filter. Check for any cracks or damage on Fuel Hose.
7. Clean Air Filter Element and lubricate it with (4T) oil.
8. Replace Engine Oil and check for any leakages.
9. Wash Engine Oil Filter Screen with petrol.
10. Check operation of Front & Rear Brakes, adjust if necessary. Grease the Brake Cam.
11. For proper Clutch functioning, check alignment marks on Crank Case L.H., Adjust if necessary.
12. Check for Wheel Runout/Spokes looseness, repair if necessary.
13. Check Wheel Bearings (Front & Rear) for looseness, damage.
14. Check for Steering looseness / tightness, adjust if required.
15. Check Front Fork operation / oil leakages, repair if reqrired.
16. Check for Rear Shock Absorber operation.
17. Check Chain Slackness, alignment. Adjust if necessary. Clean and lubricate.
18. Clean Battery, check electrolyte level and proper routing of Breather Pipe.
19. Tighten all Nuts and Bolts. Specially, Cylinder Head, Engine Mounting, Rear Swing Fork, Front & Rear Wheel
Axles & Rear Shock Absorber Mountings to the specified torque.
20. Check all electrical operations.
21. Check and correct air pressure in Front and Rear Tyres.
22. Lubricate all the pivot points.
23. Check exhaust emission for ‘CO’ level at idling, correct if required.
24. Clean and polish Motorcycle after taking ROAD TEST.
10-4
DETGREEN.pmd10/15/2006, 8:50 AM 4

JOBS TO BE CARRIED OUT DURING THIRTEENTH PAID SERVICE 1. Note down the customer’s observations.
2. Wash Motorcycle and blow it dry with compressed air.
3. Clean Spark Plug and reset the gap if necessary.
4. Check Valve clearance, adjust if necessary.
5. Clean and tune Carburettor, set the idle RPM, as recommended. Check for the easy operation of Choke Lever.
6. Open and clean Fuel Cock and Fuel Filter. Check for any cracks or damage on Fuel Hose.
7. Clean Air Filter Element and lubricate it with (4T) oil.
8. Replace Engine Oil and check for any leakages.
9. Wash Engine Oil Filter Screen with petrol.
10. Check operation of Front & Rear Brakes, adjust if necessary. Grease the Brake Cam.
11. For proper Clutch functioning, check alignment marks on Crank Case L.H., Adjust if necessary.
12. Check for Wheel Runout/Spokes looseness, repair if necessary.
13. Check Wheel Bearings (Front & Rear) for looseness, damage.
14. Check for Steering looseness / tightness, adjust if required.
15. Check Front Fork operation / oil leakages, repair if reqrired.
16. Check for Rear Shock Absorber operation.
17. Check Chain Slackness, alignment. Adjust if necessary. Clean and lubricate.
18. Clean Battery, check electrolyte level and proper routing of Breather Pipe.
19. Tighten all Nuts and Bolts. Specially, Cylinder Head, Engine Mounting, Rear Swing Fork, Front & Rear Wheel
Axles & Rear Shock Absorber Mountings to the specified torque.
20. Check all electrical operations.
21. Check and correct air pressure in Front and Rear Tyres.
22. Lubricate all the pivot points.
23. Check exhaust emission for ‘CO’ level at idling, correct if required.
24. Clean and polish Motorcycle after taking ROAD TEST.
10-6
DETGREEN.pmd10/15/2006, 8:50 AM 6