2007 VOLVO C70 CONVERTIBLE engine

2007 Volvo C70
l wearing neoprene gloves while handling a fuel filler nozzle.
WARNING
Carbon monoxide is a poisonous, colorless, and odorless gas. It is prese\
nt in all exhaust gases. If you
ever smell exhaust fumes inside the vehicle, make sure the passenger com\
partment is ventilated, and
immediately return the vehicle to your retailer for correction.
Use of Additives
With the exception of fuel line antifreeze during winter months, do not \
add solvents, thickeners, or other
store-bought additives to your vehicle's fuel, cooling, or lubricating s\
ystems. Overuse may damage your
engine, and some of these additives contain organically volatile chemica\
ls. Do not needlessly expose
yourself to these chemicals.
Fuel filler door
Press the button on the light switch panel (see the illustration on
page 55) with the ignition switched off
to unlock the fuel filler door. Please note that the fuel filler door wi\
ll remain unlocked until the vehicle
begins to move forward. An audible click will be heard when the fuel fil\
ler door relocks.
127 06 Starting and driving
Fuel requirements
If you intend to leave your vehicle while it is being refueled, this fea\
ture enables you to lock the doors/
trunk while leaving the fuel filler door unlocked.
You can also keep the vehicle locked if you remain inside it during refu\
eling. The central locking button
does not lock the fuel filler door.
Be sure the fuel filler door is not obstructed and is completely closed \
after refueling. Open the fuel filler
cap slowly during hot weather.
Refueling
The fuel tank is designed to hold approximately 15.9 US gallons (60 lit\
ers)1 with sufficient volume left
over to accommodate possible expansion of the fuel in hot weather. Be aw\
are that the "usable" tank
capacity will be somewhat less than the specified maximum. When the fuel\
level is low, such factors as
ambient temperature, the fuel's "Reid vapor pressure" characteristics, a\
nd terrain can affect the fuel
file:///K|/delme/2007_C70/07c70_06.htm (9 of 18)12/22/2006 9:15:48 PM

2007 Volvo C70
pump's ability to supply the engine with an adequate supply of fuel.
Therefore, it is advisable to refuel as soon as possible when the needle\
nears the red zone, or when the
fuel warning light comes on.
1Models with All Wheel Drive have a tank volume of 15 US gallons (57 lit\
ers). Models with engine code 39 have
a fuel tank capacity of 14 US gallons (53 liters). This code is the 6t\
h and 7th digits from the left in your vehicle's
VIN number. See
page 235 for the location of the VIN plate.
CAUTION
l Do not refuel with the engine running1. Turn the ignition off or to position I. If the ignition is on, an
incorrect reading could occur in the fuel gauge
l After refueling, close the fuel filler cap by turning it clockwise until\
it clicks into place.
l Avoid overfilling the fuel tank. Do not press the handle on the filler n\
ozzle more than one extra time.
Too much fuel in the tank in hot weather conditions can cause the fuel t\
o overflow. Overfilling could
also cause damage to the emission control systems.
l Avoid spilling gasoline during refueling. In addition to causing damage \
to the environment, gasolines
containing alcohol can cause damage to painted surfaces, which may not b\
e covered under the New
Vehicle Limited Warranty.
l Do not use gasolines containing methanol (methyl alcohol, wood alcohol)\
. This practice can result in
vehicle performance deterioration and can damage critical parts in the f\
uel system. Such damage may
not be covered under the New Vehicle Limited Warranty.
1If the fuel filler cap is not closed tightly or if the engine is running\
when the vehicle is refueled, the Check Engine
Light (malfunction indicator lamp) may indicate a fault. However, your\
vehicle's performance will not be affected.
Use only Volvo original or approved fuel filler caps.
128 06 Starting and driving
Ignition switch, Steering wheel lock
Ignition switch and steering wheel lock
0 - Locked position
Remove the key to lock the steering wheel. Never turn the key to positi\
on 0 while driving
file:///K|/delme/2007_C70/07c70_06.htm (10 of 18)12/22/2006 9:15:48 PM\

2007 Volvo C70
unlock.
If so, the key will turn in the ignition switch but the car will not sta\
rt.
At the same time, a message "Steering locked turn wheel" will appear in \
the information display.
If this happens:
1. Remove the key from the ignition.
2. Turn the steering wheel slightly and hold it to release pressure on t\
he lock mechanism.
3. Reinsert the key and start the vehicle. The steering should immediate\
ly unlock. If not, try again.
NOTE
In order to help reduce vehicle theft, make sure the steering wheel lock\
is engaged before leaving the
vehicle.
WARNING
Never switch off the ignition (turn the ignition key to position 0) or\
remove the key from the ignition
switch while the vehicle is in motion. This could cause the steering whe\
el to lock, which would make
the vehicle impossible to steer.
129 06 Starting and driving
Starting the vehicle
To start the engine
1. Fasten the seat belt.
WARNING
Before starting, check that the seat, steering wheel and mirrors are adj\
usted properly. Make sure the
brake pedal can be depressed completely. Adjust the seat if necessary.
2. Apply the parking brake if not already set. The gear selector should \
be locked in the Park (P) position
file:///K|/delme/2007_C70/07c70_06.htm (12 of 18)12/22/2006 9:15:48 PM\

2007 Volvo C70
(Shiftlock). Manual transmission: the clutch must be fully depressed.
3. The vehicle is equipped with an autostart feature. Without touching t\
he throttle pedal, turn the key to
position III and release it. The starter motor will then operate automat\
ically (for up to ten seconds) until
the engine starts. If the engine fails to start, repeat this step.
NOTE
After a cold start, idle speed may be noticeably higher than normal for \
a short period. This is done to
help bring components in the emission control system to their normal ope\
rating temperature as quickly
as possible, which enables them to control emissions and help reduce the\
vehicle's impact on the
environment.
4. To release the gear selector from the Park (P) position, the engine must be running (or the ignition key
must be in position II) and the brake pedal must be depressed.
5. Select the desired gear. On models with an automatic transmission, th\
e gear engages after a very slight
delay which is especially noticeable when selecting R.
NOTE
l Immobilizer: If two of the keys to your vehicle are close together, e.g., on the sa\
me key ring when
you try to start the vehicle, this could cause interference in the immob\
ilizer system and result in the
vehicle not starting. If this should occur, remove one of the keys from \
the key ring before trying to start
the vehicle again.
l Keylock: Models equipped an automatic transmission have a keylock system. When \
the engine is
switched off, the gear selector must be in the Park (P) position before the key can be removed from the
ignition switch.
l When starting in cold weather, the transmission may shift up at slightly\
higher engine speeds than
normal until the automatic transmission fluid reaches normal operating t\
emperature.
l Do not race a cold engine immediately after starting. Oil flow may not r\
each some lubrication points
fast enough to prevent engine damage.
WARNING
Volvo's floor mats are specially manufactured for your car. They must be\
firmly secured in the clips on
the floor so that they cannot slide and become trapped under the pedals \
on the driver's side.
130 06 Starting and driving
file:///K|/delme/2007_C70/07c70_06.htm (13 of 18)12/22/2006 9:15:48 PM\

2007 Volvo C70
Starting the vehicle
CAUTION
Automatic transmission: The engine should be idling when you move the gear selector. Never
accelerate until after you feel the transmission engage! Accelerating im\
mediately after selecting a gear
will cause harsh engagement and premature transmission wear. Selecting P\
or N when idling at a
standstill for prolonged periods of time will help prevent overheating o\
f the automatic transmission
fluid.
WARNING
l Always place the gear selector in Park (manual transmission: first or r\
everse gear) and apply the
parking brake before leaving the vehicle.and apply the parking brake bef\
ore leaving the vehicle. Never
leave the vehicle unattended with the engine running.
l Always open garage doors fully before starting the engine inside a garag\
e to ensure adequate
ventilation. The exhaust gases contain carbon monoxide, which is invisib\
le and odorless but very
poisonous.
131 06 Starting and driving
Manual transmission
6-speed manual transmission (option on certain models)
Depress the clutch pedal completely when changing gears1.
file:///K|/delme/2007_C70/07c70_06.htm (14 of 18)12/22/2006 9:15:48 PM\

2007 Volvo C70
Remove your foot from the clutch pedal while driving. The shift pattern \
should be followed.
Overdrive (5th and 6th gears) should be used as often as possible to h\
elp improve fuel economy.
1 Clutch interlock
The clutch must be fully depressed before you can start your car. If the\
clutch is not depressed, it will not be
possible to start the engine.
Engaging reverse gear, 6-speed transmission
Reverse gear should only be engaged from a complete stop.
NOTE
Reverse gear is electronically blocked and cannot be selected if the veh\
icle is moving at a speed of
approximately 13 mph (20 km/h).
CAUTION
Never shift into reverse while moving
forward.
WARNING
An extra mat on the driver's floor can cause the accelerator, brake, and\
/or clutch pedal to catch. Check
that the movement of these pedals is not impeded. Not more than one prot\
ective floor covering may be
used at one time.
file:///K|/delme/2007_C70/07c70_06.htm (15 of 18)12/22/2006 9:15:48 PM\

2007 Volvo C70
R - Reverse
The car must be stationary when shifting to position R.
N - Neutral
N is the neutral position. The engine can be started, but no gear is sele\
cted. Apply the parking brake when
the car is stationary with the gear selector in N.
133 06 Starting and driving
Automatic transmission
NOTE
If the gear selector is in the Neutral position and the car has been at \
a standstill for at least 3 seconds
(regardless of whether the engine is running or not), the gear selecto\
r will be locked in Neutral.
In order to move the gear selector to another position:
1. Turn the ignition key to position II (if the engine is not already r\
unning).
2. Depress the brake pedal.
3. Move the gear selector to the desired position.
D - Drive
D is the normal driving position. The Drive position offers 6 forward gea\
rs.The car automatically shifts
between the various forward gears, based on the level of acceleration an\
d speed. The car must be at a
file:///K|/delme/2007_C70/07c70_06.htm (17 of 18)12/22/2006 9:15:48 PM\

2007 Volvo C70
Temporarily repairing a flat tire
Before using the tire sealing system, observe the following:
WARNING
l Never leave the tire sealing system unattended when it is operating.
l Keep the tire sealing system kit away from children.
l The vehicle's engine should be running when the tire sealing system is u\
sed to avoid battery drain.
Therefore, be sure the vehicle is parked in a well ventilated place befo\
re using the system.
l Be sure the vehicle is parked safely off the road and away from moving t\
raffic.
l Apply the parking brake.
l Do not remove any foreign objects (nails, etc.) from the tire.
172 07 Wheels and tires
Tire sealing system
Temporarily repairing a flat tire is done in two stages
l In the first stage, the hole is sealed by pumping sealing compound into \
the tire. The car is then driven a
short distance to distribute the sealing compound in the tire.
l In the second stage, the tire's inflation pressure is checked and adjust\
ed if necessary.
Stage 1 - Sealing the hole
Peel off the speed limit sticker (1) and affix it to the steering whee\
l hub where it will be clearly visible to
the driver.
file:///K|/delme/2007_C70/07c70_07.htm (24 of 30)12/22/2006 9:15:51 PM\