2007 SKODA OCTAVIA TOUR oil level

59
CONTROLS AND EQUIPMENT
Engine oilWarning light shows red
(engine oil level too low)
The warning light comes on for a few se-
conds when the ignition is switched on.
On vehicles with information display, the
warning light does not come on after switch-
ing on the ignition, only if a fault exists or a
shortage of oil.
If the warning light does not go out after a
few seconds or comes on when driving,
stop the car and switch off the engine,
check oil level and top up oil if necessary –
see page 136.
Text in the information display*: STOP! OIL
PRESSURE STOP ENGINE! SERVICE
MANUAL.
An audible warning signal sounds (peep
signal 3 times).
If the warning light comes on although the
oil is at the correct level, do not continue
driving . The engine must also not be run
at idling speed in this case. Contact a
Škoda Dealership for professional advice. Warning
The oil pressure light is not an oil
level indicator! One should therefore
check the oil level at regular inter-
vals, preferably after every refuelling
stop.
Warning light lights up yellow*
(oil in the engine is too low)
If the warning light lights up yellow, the
quantity of oil in the engine is probably too
low.
Check as soon as possible the oil level or
top up with engine oil - see page 140.
An audible warning signal sounds (3x
beeps).
Text in the information display*: CHECK OIL
LEVEL.
Models fitted with LongLife Service: The
oil level warning is reset when the bonnet
is opened. If the engine oil is not replenis-
hed, the warning appears once again after
driving about 100 km.
Yellow warning light flashes*
(engine oil level gauge faulty)
If a fault occurs at the engine oil level gau-
ge, this is indicated by an audible signal and
by the warning light flashing several times.
Text in the information display*: OIL SEN-
SOR WORKSHOP.
Have the engine inspected without de-
lay by a Škoda Dealership.

119
DRIVING TIPS
The technical prerequisites
for low fuel consumption and efficiency we-
re „built in“ at the factory. Particular impor-
tance was placed on the lowest possible
effect on the environment. To retain and
make the best possible use of these char-
acteristics attention should be paid to the
following points:
The prescribed maintenance opera-tions should be carried out exactly
as specified in the Service Schedule.
Having your car serviced by a Škoda Dealer
at the specified intervals not only ensures
that it is always in proper roadworthy con-
dition but that it operates economically, with
minimal environmental impact and provides
you with many years of motoring.
Check the tyre pressures every 4 weeks.
Low tyre pressures increase the rolling re-
sistance. This not only increases the fuel
consumption and tyre wear, but the han-
dling is also impaired.
Do not carry any unnecessary loadsin the luggage compartment.
The weight of the car has a major effect on
fuel consumption, particularly when driving
in towns where you frequently have to ac-
celerate. The rule of thumb which applies
is that every 100 kilograms of weight in-
creases fuel consumption by about 1 litre/
100 km (1 litre/62 miles).
Do not fit the roof rack unless it is
really needed.
Particularly at high speeds the increased
air resistance makes itself felt in higher fuel
consumption.
Electrical consumers should onlybe switched on when they are ac-
tually required.
Heated rear window, fog lights etc. have a
considerable energy demand. The higher
alternator load also increases the fuel con-
sumption. For instance, over a period of 10
hours, the heated rear window will increase
fuel consumption by approximately 1 litre.
Keep a frequent check on your fuel consumption.
The fuel consumption should be checked
each time the tank is filled up. By doing this
inconsistencies on the vehicle which lead
to increased fuel consumption can be de-
tected sooner. Check the oil level each time you refuel.
The oil consumption depends to a great
extent on the engine load and speed. De-
pending on the style of driving the con-
sumption can be as much as 0.5 litre/
1000 km.
It is normal for the oil consumption of a new
engine to reach its lowest level after a cer-
tain mileage has been covered. The con-
sumption cannot be properly assessed until
the vehicle has run approx. 5000 km.
This also applies to the fuel consumption
and the engine output.

138GENERAL MAINTENANCE
LongLife Service*The LongLife Service ensures that your
vehicle is always in proper roadworthy con-
dition while requiring only minimal effort on
your part.
The LongLife Service is determined on the
basis of:
- Oil level and pressure sensor - see page 59
- Brake wear indicator - see page 58
- Engine oils complying with the standard VW 503 00 (petrol engines), VW 506 00
(diesel engines, except PDi engines)
and VW 506 01 (diesel engines) - see
page 138
- Variable service interval display - see page 49
- Battery with so-called „magic eye“ - see page 148.
Further information - refer to Service Sche-
dule. More detailed information is also
available from your Škoda Dealer.
SpecificationThe engine is factory-filled with a brand-
name multigrade oil which can be used as
an all-seasons oil - except in extremely cold
climatic zones. Oils may also be intermixed
when topping up (does not apply to mod-
els with LongLife Service*).
We recommend using oils from the selec-
tion of original oils available at Škoda.
Note
Engine oils naturally also undergo continu-
ous further development. That is why the
information contained in this Owner’s
Manual reflects the technical status at the
time of publication.Engine oil
Škoda Dealers are kept up-to-date by the
factory regarding any changes. It is there-
fore good practice to have the oil change
carried out at a Škoda Dealer.

140GENERAL MAINTENANCE
The car should be standing horizontally
when checking the oil level. Wait a few min-
utes after switching off the engine to allow
the oil to flow back into the sump.
Then, withdraw the dipstick, wipe it off with
a clean cloth and re-insert it fully.
After this, once again withdraw the dipstick
and read off the oil level:
a- Oil must be topped up.
After topping up, it is sufficient if the oil
level is somewhere in the range b.
b - Oil may be topped up.
After topping up, the oil level may then
be in the range c.
c - Oil must not be topped up.
If the engine is driven particularly hard, as
for example during long trips on motorways
in summer, when towing a trailer or driving
over mountain passes, the oil level should
be kept within the range c if possible - not
above .Topping up engine oilUnscrew the cap 2 of the oil filler opening
in the cylinder head cover and pour in the
quantity of oil needed. Check the oil level
with the dipstick. The oil level must on no account be hig-
her than the range „c“.
Otherwise, oil may
be drawn into the combustion chamber and
passed through the exhaust system to at-
mosphere. This can have a detrimental ef-
fect on combustion and on the operating
life of the catalytic converter.
Warning
When topping up the oil, do not spill
it onto hot engine components - dan-
ger of fire.
Carefully close the cap of the filler opening
and fully insert the dipstick into the inspec-
tion hole. Otherwise, oil might flow out when
the engine is running.
In the event that you do not have enough
fuel, do not drive any further. Switch off
the engine and contact a Škoda Dealer for
professional assistance, otherwise there is
a risk of serious engine damage.
The illustration shows part of an engine
compartment with the 2.0-ltr./85 kW engine.
For further information regarding the ar-
rangement in the engine compartment - see
page 136.
Checking oil levelIt is normal that the engine consumes a cer-
tain
quantity of oil . The oil consumption
may be as much as 0.5 ltr/1000 km if oper-
ating conditions are disadvantageous (e.g.
when driving in town) - see also page 119.
The engine oil level should therefore be
checked at regular intervals. This is best
done each time you refuel and before a long
journey.
The position of the dipstick 1 is shown in
the illustration.

141
GENERAL MAINTENANCE
Changing engine oilThe engine oil should be changed at the
intervals stated in the Service Schedule or
in the service interval display.Warning

Only carry out the engine oil chan-
ge, if you have the required profes-
sional knowledge!

Read and observe the warning
notes before working in the engine
compartment - see page 137.

Let the engine cool down - risk of
burning from hot oil.

Wear an eye protection - risk of
caustic burns due to oil splashes.

Oil is toxic! Store old oil in a safe
place out of the reach of children and
unauthorised persons until you dis-
pose of it properly.

You must not pour any additives
into the engine oil - risk of engine
damage! Damage, which results from
such product, is excluded from the
warranty.
Power steeringInspecting hydraulic fluid level
The reservoir for the hydraulic fluid of the
power steering is located in the right of the
engine compartment.
The hydraulic power steering system is
filled with hydraulic fluid G 002 000.
The hydraulic fluid level is checked when
the engine is at operating temperature and
switched off.
After your skin has come in contact with the
oil, you must thoroughly wash your skin.
On no account dispose of oil in the sewage system or into the ground.
Because of the disposal problem, the special tools and the specialist knowl-edge required, it is best to have the en-gine oil and filter change carried out by
a Škoda Dealer.

142GENERAL MAINTENANCECooling system
In normal operating conditions the cooling
system requires practically no mainte-
nance. The coolant consists of water and
a 40 % concentration of coolant additive.
This mixture not only offers the necessary
antifreeze protection down to -25 °C, but
also protects the cooling and heating sys-
tem from corrosion. In addition, it prevents
the formation of scale and increases the
boiling point of the coolant.
For this reason, the concentration of cool-
ant should also not be reduced during the
summer or in warm countries by topping up
with water. The coolant additive concen-
tration should be at least 40 %.
If greater antifreeze protection is required
for climatic reasons, the concentration of
coolant additive can be increased, but only
up to 60 % (antifreeze protection down to
about -40 °C). A higher concentration re-
duces the antifreeze protection and the
cooling efficiency is also impaired.
Cars for export countries with a cold climate
(e.g. Sweden, Norway, Finland) are factory-
filled for antifreeze protection down to about
-35 °C.
CoolantThe cooling system is factory-filled with the
coolant TL 774-F (G12 PLUS), lilac in col-
our.
We recommend using the same fluid for
topping up the system - G 12 PLUS (lilac
in colour).
In the event that it is necessary to top up
the system with a different coolant or if there
are any unclear aspects, please contact
your Škoda Dealer.
The correct coolant is available from your
Škoda Dealer.
Other coolant additives may consider-
ably impair the corrosion protection pro-
vided.
Any corrosion damage arising from the
use of another additive may result in a
loss of coolant and consequently in
major engine damage.
The fluid level should always be between
the „MAX“ and „MIN“ markings. If the level
has dropped below the „MIN“ marking, the
power steering should be inspected by a
Škoda Dealer. It is not sufficient simply to
top up the hydraulic fluid.
Note
When the engine is not running (e.g. when
the car is being towed or the ribbed belt is
broken) the power steering does not oper-
ate. The car can still be fully steered how-
ever, although greater physical effort is re-
quired for steering.

143
GENERAL MAINTENANCE
Loss of coolantA loss of coolant is first and foremost an
indication of a leak. In this case, the cool-
ing system should be inspected by a Škoda
Dealer. It is not sufficient merely to top up
the coolant.
If there is no leak in the system, losses may
also occur if the coolant boils as a result of
overheating and is forced out of the cool-
ing system.
If it is not possible to find and rectify the
cause of overheating, contact a Škoda
Dealer as soon as possible - otherwise
major engine damage may result.Topping up coolantFirst of all, switch off the engine and allow
it to cool down. Then, place a rag around
the cap of the expansion reservoir and
carefully unscrew the cap.Warning
Do not open the cap of the expansion
reservoir when the engine is hot -
risk of scalding. The cooling system
is pressurized!
Checking coolant levelThe coolant reservoir is located in the right
of the engine compartment.
The coolant level can be correctly checked
only when the engine is not running.
When the engine is cold, the coolant in the
expansion reservoir must be in the area of
the „ MIN“ mark and the crosshatched area.
When the engine is warm, the coolant level
may be slightly above the crosshatched
area. If, in exceptional cases, it is only possible
to top up the system with water, the correct
mixture concentration should be restored
without delay by using the specified cool-
ant additive.
If there is a major loss of coolant, do not
pour in coolant until the engine has cooled
down to avoid any engine damage.
Do not top up beyond the crosshatched
area!
Excess coolant is forced out of the cooling
system by the pressure relief valve in the
cap of the expansion reservoir when the
coolant heats up.
Screw the reservoir cap tight!
If the event that you do not have enough
coolant,
do not drive any further. Switch
off the engine and contact a Škoda Dealer
for professional assistance, otherwise there
is a risk of serious engine damage.

145
GENERAL MAINTENANCE
If the fluid level drops significantly within a
short time, however, or if it drops below the
„MIN“ marking, there may be a leak in the
brake system. Insufficient brake fluid level
in the reservoir is indicated by the brake
warning light coming on, see also page 61.
In such a case, contact a Škoda Dealer
without delay and have the brake sys-
tem inspected.
Warning
Read and observe the warning notes
before working in the engine com-
partment - see page 137.
If the fluid level has dropped below
the MIN marking, do not drive any
further - risk of accident! Contact a
Škoda dealer to obtain professional
assistance.
Replacing brake fluidBrake fluid is hygroscopic and conse-
quently absorbs moisture from the sur-
rounding air over the course of time. An
excessive content of water in the brake fluid
can also in the long term be a cause of
corrosion in the brake system. In addition,
the boiling point of the brake fluid is con-
siderably reduced. For this reason, the
brake fluid must be renewed every two
years.
Warning
When the brake fluid becomes too
old, vapour bubbles may form in the
brake system when the brakes are
used hard. The efficiency of the
brakes and thus the vehicle safety is
then seriously affected.
Use only fresh brake fluid conforming with
Specification FMVSS 116 DOT 4, which is
approved by the factory. Warning
Brake fluid is poisonous!
It must therefore only be stored in the
closed original container and, in par-
ticular, out of the reach of children.
Please also note that brake fluid attacks the
paintwork of the car.
Because of the disposal problem, the special tools and specialist
knowledge required, it is best to have the brake fluid change carried out by aŠkoda Dealer.
It is recommended to have the brake fluid
change carried out as part of an Inspec-
tion Service.