2007 SATURN RELAY headlamp

Replacement Bulbs
Exterior Lamp Bulb Number
Back-up 3057KX
Front Turn Signal, DRL
and Parking3157NAK
High-Beam and Low-Beam
HeadlampsH11
License Plate Lamp 168
Sidemarker 194
Stoplamp, Taillamp and
Turn Signal3057KX
For replacement bulbs not listed here, contact
your retailer.
Windshield Wiper Blade
Replacement
Windshield wiper blades should be inspected for
wear and cracking. SeeScheduled Maintenance
on page 522for more information.
Replacement blades come in different types and
are removed in different ways. For proper type and
length, seeNormal Maintenance Replacement
Parts on page 532.
460
ProCarManuals.com

Each new wheel should have the same
load-carrying capacity, diameter, width, offset
and be mounted the same way as the one
it replaces.
If you need to replace any of your wheels,
wheel bolts or wheel nuts, replace them only
with new Saturn original equipment parts. This
way, you will be sure to have the right wheel,
wheel bolts and wheel nuts for your vehicle.
{CAUTION:
Using the wrong replacement wheels,
wheel bolts, or wheel nuts on your vehicle
can be dangerous. It could affect the
braking and handling of your vehicle,
make your tires lose air and make you
lose control. You could have a collision
in which you or others could be injured.
Always use the correct wheel, wheel bolts,
and wheel nuts for replacement.Notice:The wrong wheel can also cause
problems with bearing life, brake cooling,
speedometer or odometer calibration,
headlamp aim, bumper height, vehicle ground
clearance, and tire or tire chain clearance
to the body and chassis.
SeeChanging a Flat Tire on page 484for more
information.
Used Replacement Wheels
{CAUTION:
Putting a used wheel on your vehicle is
dangerous. You cannot know how it has
been used or how far it has been driven.
It could fail suddenly and cause a crash.
If you have to replace a wheel, use a new
Saturn original equipment wheel.
479
ProCarManuals.com

Electrical System
Add-On Electrical Equipment
Notice:Do not add anything electrical to your
vehicle unless you check with your retailer
rst. Some electrical equipment can damage
your vehicle and the damage would not
be covered by your warranty. Some add-on
electrical equipment can keep other
components from working as they should.
Your vehicle has an airbag system. Before
attempting to add anything electrical to your
vehicle, seeServicing Your Airbag-Equipped
Vehicle on page 99.
Headlamp Wiring
The headlamp wiring is protected by four internal
fuses in the underhood fuse block. An electrical
overload will cause the lamps to go on and off, or
in some cases to remain off. If this happens,
have your headlamp wiring checked right away.
Windshield Wiper Fuses
The windshield wiper motor is protected by
an internal fuse in the underhood fuse block.
If the motor overheats due to heavy snow, etc.,
the wiper will stop until the motor cools. If the
overload is caused by some electrical problem,
be sure to get it xed.
The rear washer pump is controlled by a relay
located in the engine compartment, behind
the windshield washer uid reservoir. The rear
wiper motor is protected by a fuse located in the
instrument panel fuse block.
Power Windows and Other Power
Options
Circuit breakers in the instrument panel fuse panel
protect the power windows and other power
accessories. When the current load is too heavy,
the circuit breaker opens and closes, protecting
the circuit until the problem is xed.
511
ProCarManuals.com

Climate Control System............................... 205
Air Filter, Passenger Compartment........... 217
Dual......................................................... 209
Outlet Adjustment..................................... 212
Rear...............................................212, 215
Collision Damage Repair............................. 548
Comfort Guides, Rear Safety Belt................. 52
Compact Spare Tire.................................... 500
Compass..................................................... 240
Content Theft-Deterrent............................... 133
Control of a Vehicle..................................... 362
Convenience Net......................................... 173
Coolant
Engine Temperature Gage........................ 228
Heater, Engine......................................... 141
Cooling System........................................... 438
Cruise Control............................................. 188
Cruise Control Light.................................... 233
Cupholder(s)................................................ 167
Customer Assistance Information
Customer Assistance for Text
Telephone (TTY) Users......................... 542
Customer Assistance Offices.................... 542
Customer Satisfaction Procedure.............. 538
GM Mobility Reimbursement Program...... 543
Reporting Safety Defects to Saturn.......... 552Customer Assistance Information (cont.)
Reporting Safety Defects to the
Canadian Government.......................... 552
Reporting Safety Defects to the
United States Government.................... 552
Roadside Assistance Program.................. 543
Service Publications Ordering
Information........................................... 553
D
Daytime Running Lamps/Automatic
Headlamp System.................................... 193
Defensive Driving........................................ 358
Delayed Lighting.......................................... 196
Delayed Locking.......................................... 116
DIC Compass.............................................. 240
Disc, MP3................................................... 287
Doing Your Own Service Work.................... 413
Dome Lamp................................................ 196
Door
Automatic Door Lock................................ 117
Delayed Locking...................................... 116
Dual Sliding Doors................................... 118
Locks....................................................... 114
558
ProCarManuals.com

Door (cont.)
Power Door Locks................................... 116
Power Sliding Door.................................. 121
Programmable Automatic Door Unlock..... 118
Driver
Position, Safety Belt................................... 38
Driver Information Center (DIC)................... 234
DIC Operation and Displays..................... 235
DIC Vehicle Personalization..................... 261
DIC Warnings and Messages................... 241
Driving
At Night................................................... 375
City.......................................................... 380
Defensive................................................. 358
Drunken................................................... 359
Freeway................................................... 381
Hill and Mountain Roads.......................... 384
In Rain and on Wet Roads...................... 376
Rocking Your Vehicle to Get it Out.......... 391
Winter...................................................... 386
Dual Climate Control System....................... 209
DVD
Rear Seat Entertainment System.....294, 309E
Electric Power Management........................ 198
Electrical System
Add-On Equipment................................... 511
Fuses and Circuit Breakers...................... 512
Headlamp Wiring..................................... 511
Instrument Panel Fuse Block................... 512
Power Windows and Other Power
Options................................................. 511
Underhood Fuse Block............................. 514
Windshield Wiper Fuses........................... 511
Engine
Air Cleaner/Filter...................................... 428
Battery..................................................... 449
Check and Service Engine Soon Light..... 229
Coolant.................................................... 432
Coolant Heater......................................... 141
Coolant Temperature Gage...................... 228
Drive Belt Routing.................................... 533
Engine Compartment Overview ................ 422
Exhaust................................................... 151
Oil ........................................................... 423
559
ProCarManuals.com

G
Gage
Engine Coolant Temperature.................... 228
Fuel......................................................... 233
Speedometer........................................... 221
Tachometer.............................................. 221
Garage Door Opener..........................156, 157
Gasoline
Octane..................................................... 414
Specications........................................... 414
Glove Box................................................... 167
GM Mobility Reimbursement Program.......... 543
H
Hazard Warning Flashers............................ 182
Head Restraints............................................ 13
Headlamp Wiring......................................... 511
Headlamps
Bulb Replacement.................................... 455
Daytime Running Lamps/Automatic
Headlamp System................................ 193Headlamps (cont.)
Flash-to-Pass........................................... 185
Halogen Bulbs......................................... 455
Headlamps and Sidemarker Lamps.......... 456
High/Low Beam Changer......................... 185
On Reminder........................................... 193
Wiper Activated........................................ 193
Headlamps and Sidemarker Lamps............. 456
Heated Seats................................................ 10
Heater................................................205, 209
Hideaway Rear Storage Bins....................... 174
Highbeam On Light..................................... 233
High-Speed Operation, Tires........................ 471
Highway Hypnosis....................................... 383
Hill and Mountain Roads............................. 384
Hood
Checking Things Under............................ 420
Release................................................... 421
Horn............................................................ 182
How to Use This Manual ................................ 4
How to Wear Safety Belts Properly............... 38
561
ProCarManuals.com

W
Warning Lights, Gages and Indicators......... 219
Warnings
DIC Warnings and Messages................... 241
Hazard Warning Flashers......................... 182
Other Warning Devices............................ 182
Safety and Symbols..................................... 4
Vehicle Damage.......................................... 5
Wheels
Alignment and Tire Balance..................... 478
Different Size........................................... 476
Replacement............................................ 478
Where to Put the Restraint............................ 67
Windows..................................................... 130
Manual Rear Quarter............................... 131
Power...................................................... 131
Power Rear Quarter................................. 132Windshield
Backglass, and Wiper Blades, Cleaning ... 506
Washer.................................................... 186
Washer Fluid........................................... 444
Wiper Blade Replacement........................ 460
Wiper Fuses............................................ 511
Wipers..................................................... 185
Windshield, Rear Washer/Wiper................... 187
Winter Driving............................................. 386
Wiper Activated Headlamps ......................... 193
X
XM Radio Messages................................... 293
XM™ Satellite Radio Antenna System......... 356
Y
Your Vehicle and the Environment............... 520
570
ProCarManuals.com