2007 SATURN RELAY power steering

(B) Tire Width:The three-digit number indicates
the tire section width in millimeters from sidewall
to sidewall.
(C) Aspect Ratio:A two-digit number that
indicates the tire height-to-width measurements.
For example, if the tire size aspect ratio is
60, as shown in item C of the illustration, it would
mean that the tire’s sidewall is 60 percent as
high as it is wide.
(D) Construction Code:A letter code is used
to indicate the type of ply construction in the tire.
The letter R means radial ply construction; the
letter D means diagonal or bias ply construction;
and the letter B means belted-bias ply
construction.
(E) Rim Diameter:Diameter of the wheel in
inches.
(F) Service Description:These characters
represent the load range and speed rating of the
tire. The load index represents the load carry
capacity a tire is certied to carry. The load index
can range from 1 to 279. The speed rating is
the maximum speed a tire is certied to carry
a load. Speed ratings range from A to Z.Tire Terminology and Denitions
Air Pressure:The amount of air inside the tire
pressing outward on each square inch of the
tire. Air pressure is expressed in pounds
per square inch (psi) or kilopascal (kPa).
Accessory Weight:This means the combined
weight of optional accessories. Some examples of
optional accessories are, automatic transmission/
transaxle, power steering, power brakes, power
windows, power seats, and air conditioning.
Aspect Ratio:The relationship of a tire’s height
to its width.
Belt:A rubber coated layer of cords that is
located between the plies and the tread. Cords
may be made from steel or other reinforcing
materials.
Bead:The tire bead contains steel wires wrapped
by steel cords that hold the tire onto the rim.
Bias Ply Tire:A pneumatic tire in which the plies
are laid at alternate angles less than 90 degrees
to the centerline of the tread.
466
ProCarManuals.com

Fuses Usage
1 Trunk, Door Locks
2 Electronic Level Control
3 Rear Wiper
4 Radio, DVD Player
5 Interior Lamps
6 OnStar
®
7 Keyless Entry Module
8Cluster, Heating, Ventilation,
Air Conditioning
9 Cruise Switch
10 Steering Wheel Illumination
11 Power Mirror
12 Stoplamp, Turn Lamps
13 Heated Seats
14 Blank
15 Electronic Level Control
513
ProCarManuals.com

Maintenance Footnotes
#Lubricate the suspension, steering linkage,
transaxle shift linkage, and the underbody contact
points and linkage.
(a)Visually inspect brake lines and hoses for
proper hook-up, binding, leaks, cracks, chang,
etc. Inspect disc brake pads for wear and rotors
for surface condition. Inspect other brake
parts, including calipers, parking brake, etc. Check
parking brake adjustment.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose, or missing
parts, signs of wear, or lack of lubrication. Inspect
power steering lines and hoses for proper
hook-up, binding, leaks, cracks, chang, etc.
(c)Visually inspect hoses and have them replaced
if they are cracked, swollen, or deteriorated.
Inspect all pipes, ttings, and clamps; replace with
genuine Saturn parts as needed. To help ensure
proper operation, a pressure test of the cooling
system and pressure cap and cleaning the outside
of the radiator and air conditioning condenser is
recommended at least once a year.(d)Visually inspect wiper blades for wear or
cracking. Replace wiper blades that appear worn
or damaged or that streak or miss areas of
the windshield.
(e)Make sure the safety belt reminder light and all
your belts, buckles, latch plates, retractors, and
anchorages are working properly. Look for
any other loose or damaged safety belt system
parts. If you see anything that might keep a safety
belt system from doing its job, have it repaired.
Have any torn or frayed safety belts replaced. Also
look for any opened or broken airbag coverings,
and have them repaired or replaced. The
airbag system does not need regular maintenance.
(f)Lubricate all key lock cylinders, hood latch
assemblies, secondary latches, pivots, spring
anchor and release pawl, hood and door hinges,
rear folding seats, liftgate hinges, fuel door
hinge, power sliding door cable, and sliding door
track(s). More frequent lubrication may be required
when exposed to a corrosive environment.
Applying silicone grease on weatherstrips with a
clean cloth will make them last longer, seal better,
and not stick or squeak.
525
ProCarManuals.com

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name,
part number, or specication may be obtained
from your retailer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. GM Goodwrench
®
oil meets all the requirements for
your vehicle. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on page 423.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant
on page 432.
Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
WasherGM Optikleen
®Washer Solvent.
Power Steering
SystemPower Steering Fluid
(Saturn Part No. 21007583 or
GM Part No. U.S. 89021184,
in Canada 89021186).
Automatic
TransaxleDEXRON
®-VI Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474.
Chassis
LubricationChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
530
ProCarManuals.com

Appearance Care (cont.)
Washing Your Vehicle.............................. 505
Weatherstrips........................................... 504
Windshield, Backglass, and
Wiper Blades........................................ 506
Audio System(s).......................................... 270
Audio Steering Wheel Controls................. 353
Care of Your CD and DVD Player............ 355
Care of Your CDs and DVDs................... 355
Chime Level Adjustment........................... 356
Fixed Mast Antenna................................. 355
Mobile Digital Media System.................... 330
Navigation/Radio System, see
Navigation Manual................................ 294
Radio with CD......................................... 272
Rear Seat Audio (RSA)...................325, 328
Setting the Time...................................... 272
Theft-Deterrent Feature............................ 352
Understanding Radio Reception............... 354
XM™ Satellite Radio Antenna System...... 356
Automatic Door Lock................................... 117
Automatic Transaxle
Fluid........................................................ 430
Operation................................................. 143B
Battery........................................................ 449
Electric Power Management..................... 198
Run-Down Protection............................... 199
Before Leaving on a Long Trip.................... 382
Brake
Anti-Lock Brake System (ABS)................. 363
Emergencies............................................ 365
Parking.................................................... 147
System Warning Light.............................. 226
Brakes........................................................ 445
Braking....................................................... 362
Braking in Emergencies............................... 365
Break-In, New Vehicle................................. 138
Bucket Seats, Rear....................................... 14
Bulb Replacement....................................... 455
Front Turn Signal, Parking and Daytime
Running Lamps.................................... 457
Halogen Bulbs......................................... 455
License Plate Lamps................................ 459
Replacement Bulbs.................................. 460
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps..................................... 458
Buying New Tires........................................ 474
556
ProCarManuals.com

Engine (cont.)
Oil Life System........................................ 426
Overheated Protection Operating Mode.... 437
Overheating............................................. 435
Starting.................................................... 140
Entry Lighting.............................................. 196
Event Data Recorders (EDR)...................... 547
Exit Lighting................................................ 197
Extender, Safety Belt..................................... 55
Exterior Lamps............................................ 192
F
Filter
Engine Air Cleaner................................... 428
Finish Damage............................................ 508
Fixed Mast Antenna.................................... 355
Flashers, Hazard Warning........................... 182
Flash-to-Pass.............................................. 185
Flat Tire...................................................... 483
Flat Tire, Changing...................................... 484
Flat Tire, Storing......................................... 497Fluid
Automatic Transaxle................................. 430
Power Steering........................................ 443
Windshield Washer.................................. 444
Folding Tray................................................ 170
Front Console Storage Area........................ 170
Front Reading Lamps.................................. 197
Front Turn Signal, Parking and Daytime
Running Lamps........................................ 457
Fuel............................................................ 414
Additives.................................................. 415
California Fuel.......................................... 415
Filling a Portable Fuel Container.............. 419
Filling Your Tank...................................... 417
Fuels in Foreign Countries....................... 416
Gage....................................................... 233
Gasoline Octane...................................... 414
Gasoline Specications............................ 414
Low Warning Light................................... 234
Fuses
Fuses and Circuit Breakers...................... 512
Instrument Panel Fuse Block................... 512
Underhood Fuse Block............................. 514
Windshield Wiper..................................... 511
560
ProCarManuals.com

P
Paint, Damage............................................ 508
Park Aid...................................................... 200
Park (P)
Shifting Into............................................. 148
Shifting Out of......................................... 149
Parking
Assist....................................................... 200
Brake....................................................... 147
Over Things That Burn............................ 150
Passenger Airbag Status Indicator............... 224
Passenger Compartment Air Filter............... 217
Passenger Sensing System........................... 93
Passing....................................................... 372
PASS-Key
®III ............................................. 135
PASS-Key®III Operation............................. 136
Power
Accessory Outlet(s).................................. 203
Door Locks.............................................. 116
Electrical System..................................... 511
Outlet 115 Volt Alternating Current........... 204
Rear Quarter Windows............................. 132
Retained Accessory (RAP)....................... 139
Seat.......................................................... 10Power (cont.)
Sliding Door............................................. 121
Steering Fluid.......................................... 443
Windows.................................................. 131
Pretensioners, Safety Belt............................. 55
Programmable Automatic Door Unlock......... 118
Q
Questions and Answers About Safety Belts ... 37
R
Radiator Pressure Cap................................ 435
Radios........................................................ 270
Care of Your CD and DVD Player............ 355
Care of Your CDs and DVDs................... 355
Navigation/Radio System, see
Navigation Manual................................ 294
Radio with CD......................................... 272
Rear Seat Audio.............................325, 328
Setting the Time...................................... 272
Theft-Deterrent......................................... 352
Understanding Reception......................... 354
Rear Climate Control System.............212, 215
565
ProCarManuals.com

Safety Belts (cont.)
Safety Belts Are for Everyone.................... 32
Shoulder Belt Height Adjuster.................... 47
Safety Warnings and Symbols......................... 4
Scheduled Maintenance............................... 522
Seats
Bucket Seats, Rear.................................... 14
Captain Chairs........................................... 22
Head Restraints......................................... 13
Heated Seats............................................. 10
Manual........................................................ 9
Power Seats.............................................. 10
Rear Seat Operation.................................. 14
Reclining Seatbacks................................... 11
Third Row Seat......................................... 27
Second Row Center Console...................... 171
Secondary Latch System............................. 495
Securing a Child Restraint
Rear Seat Position..................................... 77
Right Front Seat Position........................... 79
Security Light.............................................. 232
Service........................................................ 412
Accessories and Modications.................. 412
Adding Equipment to the Outside of
Your Vehicle......................................... 414
California Proposition 65 Warning............. 413Service (cont.)
Doing Your Own Work............................. 413
Engine Soon Light................................... 229
Publications Ordering Information............. 553
Servicing Your Airbag-Equipped Vehicle......... 99
Setting the Time.......................................... 272
Sheet Metal Damage................................... 508
Shifting Into Park (P)................................... 148
Shifting Out of Park (P)............................... 149
Shoulder Belt Height Adjuster........................ 47
Signals, Turn and Lane-Change.................. 184
Sliding Door, Power..................................... 121
Sliding Doors, Dual..................................... 118
Spare Tire
Accessory Inator..................................... 480
Compact.................................................. 500
Installing.................................................. 488
Removing................................................ 485
Storing..................................................... 497
Specications, Capacities............................ 518
Speedometer............................................... 221
StabiliTrak
®System..................................... 367
Starting Your Engine................................... 140
Steering...................................................... 369
Steering Wheel Controls, Audio................... 353
Steering Wheel, Tilt Wheel.......................... 182
567
ProCarManuals.com