2007 RAM CHASSIS CAB jacking

WHAT TO DO IN EMERGENCIESCONTENTS
Hazard Warning Flasher ..................370

Jacking And Tire Changing ................371
▫ All Models ..........................371

Jacking Instructions .....................372
▫ Tire Changing Procedure ................372

Hoisting .............................381

Jump-Starting .........................382 ▫ With Portable Starting Unit ..............385

Freeing A Stuck Vehicle ..................385

Emergency Tow Hooks — If Equipped ........386

Towing A Disabled Vehicle ................387
▫ 4-Wheel- Drive Vehicles .................387
▫ 2–Wheel- Drive Vehicles ................388
6

JACKING AND TIRE CHANGING
WARNING!• Being under a jacked-up vehicle is dangerous.
The vehicle could slip off the jack and fall on you.
You could be crushed. Never put any part of your
body under a vehicle that is on a jack. Never start
or run the engine while the vehicle is on a jack. If
you need to get under a raised vehicle, take it to a
service center where it can be raised on a lift.
• The jack is designed to use as a tool for changing
tires only. The jack should not be used to lift the
vehicle for service purposes. The vehicle should
be jacked on a firm level surface only. Avoid ice or
slippery areas. All Models
The jack and jack tools are stored under the front
passenger seat. Lift the flap on the side of the seat for
access.
Remove the jack and tools by removing the wing bolt and
sliding the assembly from under the seat. WHAT TO DO IN EMERGENCIES 371
6

WARNING!After using the jack and tools, always reinstall them
in the original carrier and location. While driving
you may experience, abrupt stopping, rapid accelera-
tion, or sharp turns. A loose jack, tools, bracket or
other objects in the vehicle may move around with
force, resulting in serious injury. JACKING INSTRUCTIONS
Tire Changing Procedure
WARNING!Getting under a jacked-up vehicle is dangerous. The
vehicle could slip off the jack and fall on you. You
could be crushed. Never get any part of your body
under a vehicle that is on a jack. Never start or run
the engine while the vehicle is on a jack. If you need
to get under a raised vehicle, take it to a service
center where it can be raised on a lift.
Do not raise this vehicle using a bumper jack. The jack is
designed as a tool for changing tires on this vehicle only.
It is not recommended that the jack be used for service
purposes or to lift more than one wheel at a time.372 WHAT TO DO IN EMERGENCIES

Preparations
Park the vehicle on a firm level surface, avoiding ice or
slippery areas. Set the parking brake and place the gear
selector in PARK (automatic transmission) or REVERSE
(manual transmission). On four-wheel drive vehicles,
shift the transfer case to the “4L” position.
WARNING!Do not attempt to change a tire on the side of the
vehicle close to moving traffic. Pull far enough off
the road to avoid the danger of being hit when
operating the jack or changing the wheel. • Turn on the Hazard Warning Flasher.
• Block both the front and rear
of the wheel diagonally oppo-
site the jacking position. For
example, if the right front
wheel is being changed, block
the left rear wheel.
• Passengers should not remain in the vehicle when the
vehicle is being jacked. WHAT TO DO IN EMERGENCIES 373
6

Instructions
WARNING!Carefully follow these tire changing warnings to help
prevent personal injury or damage to your vehicle:
• Always park on a firm, level surface as far from the
edge of the roadway as possible before raising the
vehicle.
• Block the wheel diagonally opposite the wheel to be
raised.
• Apply the parking brake firmly before jacking.
• Never start the engine with the vehicle on a jack.
• Do not let anyone sit in the vehicle when it is on a jack.
• Do not get under the vehicle when it is on a jack.
• Only use the jack in the positions indicated.
• If working on or near a roadway, be extremely careful
of motor traffic. 1. Remove the spare wheel, jack, and tools from storage.
2. Using the wheel wrench, loosen, but do not remove,
the wheel nuts by turning them counterclockwise one
turn while the wheel is still on the ground.
3. When changing the front wheel, assemble the jack
drive tube to the jack and connect the drive tube to the
extension tube. Place the jack under the axle as close to
the tire as possible with the drive tubes extending to the
front. Connect the jack tube extension and wheel wrench.374 WHAT TO DO IN EMERGENCIES

wheel. The nuts should then be tightened to recom-
mended torque. Tighten the nuts to final torque in
increments. Progress around the bolt circle, tightening
the nut opposite to the nut just previously tightened until
final torque is achieved. Recommended torques are
shown in the following chart.
Disc
Wheels Type Nut Stud Size Torque
Ft. Lbs. Torque
Newton
Meters
Cone 9/16-18 120-150 160-200
Flanged 9/16-18 130-160 190-220
To Stow The Flat Or Spare (If equipped)
Refer to Upfitters Body Builders Guide for information
on stowing your spare tire (If equipped). HOISTING
A conventional floor jack may be used at the jacking
locations, refer to the graphics that show jacking loca-
tions. However, a floor jack or frame hoist must never be
used on any other parts or the underbody.
CAUTION!Never use a floor jack directly under the differential
housing of a loaded truck or damage to your vehicle
may result. WHAT TO DO IN EMERGENCIES 381
6

Emergency, In Case of
Freeing Vehicle When Stuck ............... 385
Hazard Warning Flasher ................. 370
Jacking ............................. 372
Jump Starting ......................... 382
Tow Hooks .......................... 386
Towing ............................. 387
Emission Control System Maintenance ......... 474
Emission Related Components .............. 418
Engine ............................ 392,393
Air Cleaner ........................ 406,407
Block Heater .................... 252,259,265
Break-In Recommendations ................ 72
Compartment ......................... 392
Compartment Identification ............... 393
Coolant (Antifreeze) .................... 469
Cooling ............................. 426
Data Plate ........................... 395
Exhaust Gas Caution .................... 330 Flooded, Starting ...................... 249
Identification ......................... 392
Idling .............................. 261
Jump Starting ......................... 382
Oil .............................. 398,469
Oil Filler Cap ...................... 401,403
Oil Selection .......................... 401
Oil Synthetic ....................... 260,403
Runaway ............................ 327
Temperature Gauge ..................... 174
Event Data Recorder ...................... 57
Exhaust Brake .......................... 265
Exhaust Gas Caution ................ 75, 330,425
Exhaust System .................... 75, 425,446
ExteriorLighting ........................ 124
Fabric Care ............................ 454
Fan .................................. 432518 INDEX

Steering Wheel Mounted Sound System Controls . 226
Storage, Behind the Seat ................... 155
Storage Compartment, Center Seat ......... 155,157
Storage, Vehicle ......................... 461
Storing Your Vehicle ...................... 461
Supplemental Tire Pressure Information ........ 323
Synthetic Engine Oil ................... 260,403
System, Navigation ...................... 218
System, Remote Starting .................... 25
Tachometer ............................ 173
Tether Anchor, Child Restraint ............. 64,67
Tilt Steering Column ..................... 129
Tip Start .............................. 249
Tire and Loading Information Placard ...... 310,323
Tire Identification Number (TIN) ............. 308
Tire Markings .......................... 305
Tire Safety Information .................... 305
Tires ............................ 76, 314,509 Aging(LifeofTires) .................... 321
Air Pressure .......................... 314
Alignment ........................... 322
Chains .............................. 323
Changing ............................ 372
Compact Spare ........................ 318
Dual ............................ 326,378
General Information .................... 314
High Speed .......................... 317
Inflation Pressures ..................... 315
Jacking ............................. 372
LifeofTires .......................... 321
Load Capacity ...................... 310,311
Quality Grading ....................... 509
Radial .............................. 317
Replacement ......................... 321
Rotation ............................. 325
Safety ........................... 305,314
Sizes ............................... 306528 INDEX