2007 RAM CHASSIS CAB power steering

WARNING!• Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer
to Section 3 of the Warranty Information book for
further warranty information.
• The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced repairman. Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluorocar-
bon (HFC) that is endorsed by the Environmental Pro-
tection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by dealers or other service facilities
using recovery and recycling equipment.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
DaimlerChrysler Dealership.  MAINTAINING YOUR VEHICLE 421
7

WARNING!Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Fluids, Lubricants, and Genuine Parts
for correct fluid type.
Front Suspension Ball Joints
The ball joints originally supplied with the vehicle are
permanently lubricated at the factory and do not require
service. The ball joints and seals should be inspected
whenever the vehicle is serviced for other reasons. Steering Linkage — Inspection
Whenever the vehicle is hoisted, all steering linkage
joints should be inspected for evidence of damage. If
seals are damaged, parts should be replaced to prevent
leakage or contamination of the grease.
Front Prop Shaft Lubrication
Lubricate the front driveshaft grease fitting at each oil
change listed in the appropriate Maintenance Schedule
for your vehicle (Schedule “A” and “B”). Use Mopar 
type MS-6560 (lithium based grease), or equivalent.422 MAINTAINING YOUR VEHICLE

Brake System
Power Disc Brakes (Front and Rear)
Disc brakes do not require adjustment; however, several
hard stops during the break-in period are recommended
to seat the linings and wear off any foreign material.
Brake And Power Steering Hoses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, tears, cuts, abrasion, and excessive swelling
indicate deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
Insure nylon tubing in these areas has not melted or
collapsed. Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE: Often, fluid such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to facilitate the assembly of hoses to couplings.
Therefore, oil wetness at the hose-coupling area is not
necessarily an indication of leakage. Actual dripping of
hot fluid when systems are under pressure (during
vehicle operation), should be noted before hose is re-
placed based on leakage.
NOTE: Inspection of brake hoses should be performed
whenever the brake system is serviced and every engine
oil change. Inspect hydraulic brake hoses for surface
cracking, scuffing, or worn spots. If there is any evidence
of cracking, scuffing, or worn spots, the hose should be
replaced immediately! Eventual deterioration of the hose
can take place resulting in a possibility of a burst failure.434 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission (5 Speed
545RFE) Mopar  ATF+4, Automatic Transmission Fluid.
Automatic Transmission (6 Speed
AS68RC) Mopar  AS68RC™ Automatic Transmission Fluid
Transfer Case Mopar  ATF+4, Automatic Transmission Fluid.
Manual Transmission Fluid G-56 Mopar  ATF+4, Automatic Transmission Fluid.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P. or equivalent.
Front and Rear Axle Fluid GL-5 SAE 75W-90 Synthetic or equivalent. 3500 axles do not require lim-
ited slip additive.
Brake Master Cylinder Mopar  DOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir Mopar  ATF+4, Automatic Transmission Fluid. MAINTAINING YOUR VEHICLE 471
7

Automatic Transmission (Gas Engine Only) ..... 441
AxleFluid .......................... 437,471
Axle Lubrication (Axle Fluid) ............... 437
BallJoints ............................. 422
Battery ............................ 418,419
Blanket .......................... 260,420
Emergency Starting ..................... 382
Keyless Transmitter Replacement (RKE) ....... 24
Saving Feature (Protection) ............... 123
Bearings .............................. 444
Belts,Drive ............................ 406
Belts, Seat .............................. 35
Body Mechanism Lubrication ............... 423
B-Pillar Location ........................ 310
Brake Fluid ............................ 471
Brake System ........................ 301,434
Anti-Lock (ABS) ....................... 302
Disc Brakes .......................... 434 Fluid Check .......................... 435
Hoses .............................. 434
Master Cylinder ....................... 435
Parking ............................. 299
Warning Light ........................ 177
Bulb Replacement ....................... 462
Bulbs,Light ............................ 461
Cab Top Clearance Lights .................. 466
Calibration, Compass .................. 138,148
Capacities, Antifreeze (Engine Coolant) ........ 468
Capacities, Fluid ........................ 468
Caps, Filler
Oil (Engine) ....................... 401,403
Power Steering ........................ 421
Radiator (Coolant Pressure) ............... 429
Car Washes ............................ 452
Carbon Monoxide Warning ............... 75,330
Cassette Tape and Player Maintenance ......... 228 INDEX 515
10

Selection of Coolant (Antifreeze) ......... 428,469
Temperature Gauge ..................... 174
Cruise Control (Speed Control) .............. 132
CupHolder ............................ 152
Customer Assistance ..................... 504
Data Recorder, Event ...................... 57
Daytime Running Lights ................... 124
Dealer Service .......................... 395
Defroster, Rear Window ................. 86,160
Defroster, Windshield ................ 76, 232,234
Delay (Intermittent) Wipers ................. 128
Diesel Exhaust Brake ..................... 265
Diesel Fuel ............................ 331
Diesel Fuel Requirements .................. 331
Bulk Storage of ........................ 336
Differential, Limited-Slip .................. 295
Dipsticks .............................. 398
Power Steering ........................ 421 Disc Brakes ............................ 434
Disposal .............................. 405
Engine Oil ........................... 405
Used Coolant (Antifreeze) ................ 430
Door Ajar ............................. 180
Door Locks ............................. 26
Door Locks, Automatic .................... 145
Downshifting ........................ 281,282
Draining Fuel/Water Separator Filter .......... 410
DriveBelts ............................ 406
Dual Rear Wheels ..................... 326,378
DVD Player (Video Entertainment System) ...... 222
Electric Rear Window Defrost ............. 86,160
Electrical Power Outlets ................... 149
Electronic Speed Control (Cruise Control) ...... 132
Electronic Vehicle Information Center (EVIC) .... 142
Electronically Shifted Transfer Case ........... 288
Emergency Brake ........................ 299 INDEX 517
10

Filters
Air Cleaner .......................... 406
Engine Fuel ..................... 410,413,469
Engine Oil ..................... 398,403,469
Flashers
Turn Signal .......................... 125
Flat Tire Stowage ........................ 381
Flooded Engine Starting ................... 249
Fluid, Brake ........................... 471
Fluid Capacities ......................... 468
Fluid Level Checks
Brake ............................... 435
Manual Transmission ................. 437,438
Power Steering ........................ 421
Transfer Case ......................... 437
Fluids, Lubricants and Genuine Parts .......... 469
Fog Lights ....................... 125,178,465
Fold Flat Load Floor ..................... 161
Four Wheel Drive ....................... 283 Four-Way Hazard Flasher .................. 370
Freeing A Stuck Vehicle ................... 385
FrontAxle(Differential) ................ 423,436
Front Wheel Bearings ..................... 444
Fuel ............................ 327,331,335
Adding .......................... 333,335
Diesel ......................... 331,335,469
Filter ......................... 410,413,469
Gauge .............................. 179
Hoses .............................. 433
Light ............................... 180
Octane Rating ........................ 327
Requirements ...................... 327,331
Specifications ......................... 332
System Hoses ......................... 433
Tank Capacity ........................ 468
Fuses ................................ 457
Gas Cap (Fuel Filler Cap) ............... 334,394 INDEX 519
10

Brake Warning ........................ 177
Bulb Replacement ................... 461,462
Cap Top Clearance ..................... 466
Check Engine (Malfunction Indicator) ........ 176
Cruise .............................. 180
Daytime Running ...................... 124
Dome .............................. 141
Fog .......................... 125,178,465
Four-Wheel Drive Indicator ............... 287
Hazard Warning Flasher ................. 370
Headlights ........................... 124
High Beam ........................ 127,173
High Beam Indicator .................... 173
High Beam/Low Beam Select ............. 127
Illuminated Entry ....................... 19
Instrument Cluster ..................... 172
Intensity Control ....................... 122
Interior ............................. 122
Lights On Reminder .................... 125 Passing ............................. 126
Reading ............................. 141
Seat Belt Reminder ..................... 173
Service ........................... 461,462
Transfer Case ......................... 287
Transmission Warning ................... 179
Turn Signal ..................... 125,173,462
Warning (Instrument Cluster Description) ..... 172
Limited-Slip Differential ................ 295,437
Loading Vehicle ......................... 338
Tires ............................... 310
Locks ................................. 26
Child Protection ........................ 30
Door ................................ 26
Keys ................................ 12
Power Door ........................... 27
Steering Wheel ......................... 15
Lower Anchors and Tether for CHildren (LATCH) . 64
Lubrication, Body ....................... 423522 INDEX