2007 MERCEDES-BENZ ML350 automatic transmission

516 Practical hintsJump startingThe jump-start contacts are located in the
engine compartment.1Negative (-) terminal
2Positive (+) terminal

Make sure the two vehicles do not
touch.

Turn off all electrical consumers.

Apply parking brake.

Set automatic transmission to
positionP.

Open the hood (
page 356).

Open cover of positive terminal2.1Positive terminal of charged battery
2Positive terminal of discharged battery
3Negative terminal of charged battery
4Negative terminal of discharged
battery
Warning!
G
Keep flames or sparks away from battery.
Do not smoke.
Observe all safety instructions and precau-
tions when handling automotive batteries
(page 507).

518 Practical hintsTowing the vehicleMercedes-Benz recommends that the
vehicle be transported with all wheels off
the ground using flatbed or appropriate
wheel lift/dolly equipment. This method is
preferable to other types of towing.When circumstances do not permit the
recommended towing methods, the
vehicle may be towed with all wheels on
the ground only so far as necessary to have
the vehicle moved to a safe location where
the recommended towing methods can be
employed.!
Use flatbed or wheel lift/dolly equipment,
with the SmartKey in starter switch turned to
position0.
Do not tow with sling-type equipment. Towing
with sling-type equipment over bumpy roads will
damage radiator and supports.
To prevent damage during transport, do not tie
down vehicle by its chassis or suspension parts.
Use the towing eyes.
Switch off the ESP
® (page 99) and the auto-
matic central locking (page 126).
!
Do not tow-start the vehicle.
!
Do not tow with one axle raised. Doing so
could damage the transfer case, which is not
covered by the Mercedes-Benz Limited
Warranty.
All wheels must be on or off the ground. Observe
instructions for towing the vehicle with all
wheels on the ground.
!
When towing the vehicle with all wheels on
the ground, the automatic transmission must be
in positionN and the starter switch must be in
position2 (
page 40).
When towing the vehicle with all wheels on the
ground, the vehicle may be towed only for
distances up to 30 miles (50 km) and at a speed
not to exceed 30 mph (50 km/h).
Keep in mind that it is important for the
SmartKey to be in the respective starter switch
positions as described above. As soon as the
SmartKey is removed from the starter switch or
the SmartKey with KEYLESS-GO* is removed
from the vehicle, the automatic transmission will
shift to park positionP see “Starter switch posi-
tions” (
page 39).

519 Practical hints
Towing the vehicle
Warning!
G
If circumstances require towing the vehicle
with all wheels on the ground, always tow
with a tow bar if:

the engine will not run


there is a malfunction in the power
supply or in the vehicle’s electrical sys-
tem
Prior to towing the vehicle with all wheels on
the ground, make sure the starter switch is
in position2 (
page 40).
Warning!
G
With the engine not running, there is no
power assistance for the brake and steering
systems. In this case, it is important to keep
in mind that a considerably higher degree of
effort is necessary to brake and steer the
vehicle. Adapt your driving accordingly.
i
To signal turns while being towed with
hazard warning flasher in use, set the starter
switch to position2 and activate combination
switch for left or right turn signal in usual manner
– only the selected turn signal will operate.
Upon canceling the turn signal, the hazard
warning flasher will operate again.
i
If the battery is disconnected or discharged,
the automatic transmission will remain locked in
positionP and the SmartKey will not turn in the
starter switch. For more information, see “Bat-
tery” (page 507) and “Jump starting”
(
page 515).
!
When towing the vehicle with all wheels on
the ground, note the following:
With the automatic central locking activated and
the ignition in position2 (
page 40), the vehicle
doors lock if the left front wheel is turning at a
speed of approximately 9 mph (15 km/h) or
above.
To prevent the vehicle doors from locking,
deactivate the automatic central locking
(
page 126).
Towing of the vehicle should only be done using
the towing eye bolt. Never attach tow cable, tow
rope or tow rod to vehicle chassis, frame or sus-
pension parts.

522 Practical hintsFusesThe electrical fuses in your vehicle serve to
switch off malfunctioning power circuits.
If a fuse is blown, the components and sys-
tems secured by that fuse will stop operat-
ing.If a newly inserted fuse blows again, have
the cause determined and rectified by an
authorized Mercedes-Benz Light Truck
Center.
The following aids are available to help you
replace fuses. They are included with the
vehicle tool kit (
page 469):


Fuse chart
The fuse chart explains the fuse alloca-
tion and fuse amperages.


Spare fuses


Fuse extractor
The electrical fuses are located in different
fuse boxes:


Fuse box in engine compartment
(page 523)


Fuse box in cargo compartment
(page 523)


Fuse box in passenger compartment
(page 524)Before replacing fuses:

Apply parking brake (
page 65).

Make sure the automatic transmission
is set toP (
page 187).
The gear position indicator in the multi-
function display should be on
P.

Turn off all electrical consumers.

Turn off the engine (
page 40).

Remove the SmartKey from the starter
switch.
Vehicles with KEYLESS-GO*:
Open the driver’s door (this puts
the starter switch in position0,
same as with the SmartKey re-
moved from the starter switch). The
driver’s door then can be closed
again.
Warning!
G
Only use fuses approved by Mercedes-Benz
with the specified amperage for the system
in question and do not attempt to repair or
bridge a blown fuse. Using other than ap-
proved fuses or using repaired or bridged
fuses may cause an overload leading to a
fire, and/or cause damage to electrical
components and/or systems. Have the
cause determined and remedied by an au-
thorized Mercedes-Benz Light Truck Center.i
A blown fuse must be replaced by an appro-
priate spare fuse (recognizable by its color or the
fuse rating given on the fuse) of the amperage
recommended in the fuse chart. Any
Mercedes-Light Truck Center will be glad to
advise you on this subject.

543 Technical data
Fuels, coolants, lubricants
Fuels, coolants, lubricants
Capacities
Vehicle components and their respective
lubricants must match. Therefore only use
products tested and approved by
Mercerdes-Benz.
Please refer to the Factory Approved
Service Products pamphlet, or inquire at
your Mercedes-Benz Light Truck Center.
Warning!
G
Comply with all valid regulations with re-
spect to handling, storing and disposing of
service fluids. Otherwise you could
endanger persons or the environment.
Keep service fluids out of the reach of
children.
If a service fluid is swallowed, contact a
physician immediately.
Model
Capacity
Fuels, coolants, lubricants, etc.
Engine with oil filter
ML 320 CDI
9.5 US qt (9.0 l)
Approved engine oils
ML 350
8.5 US qt (8.0 l)
Approved engine oils
ML 500
9.0 US qt (8.5 l)
Approved engine oils
ML 63 AMG
10.3 US qt (9.7 l)
Approved engine oils
Automatic transmission
All models
9.5 US qt (9.0 l)
MB Automatic Transmission Fluid
Transfer case single speed
All models
0.53 US qt (0.5 l)
MB Automatic Transmission Fluid

553 Index
A
ABS 96
Indicator lamp 414
Messages in the multifunction
display 430
Off-road - ABS 97
Accelerator position, automatic
transmission 191
Accessory weight 394
Accident 64
Active head restraint 80, 128, 479
Adaptive Damping System (ADS)* 269
Air bags 71
Children 73, 82
Front passenger front air bag off
indicator lamp 31, 89, 426
Front, Driver 75
Front, Passenger 75
Occupant Classification System
(OCS) 85
Safety guidelines 73
Side impact (front and rear*) 76
Window curtain 76Air conditioning refrigerant 546
Air conditioning system see
Climate control or Automatic climate
control (3-zone)*
Air conditioning, Cooling 216, 230
Air distribution, Front 212, 226
Air distribution, Rear 219, 234
Air pressure see Tire inflation pressure
Air pump, electric (ML 63 AMG) 502
Air recirculation mode 214, 228
Air suspension package* 269
Adaptive Damping System
(ADS)* 269
Messages in the multifunction
display 467
Vehicle level control* 270
Air vents 219
Air vents, Front 212, 226
Air vents, Rear 235
Air volume 212, 227Alarm system see Anti-theft systems
Alignment bolt (vehicle tool kit) 470, 500
Anticorrosion/antifreeze 550
Antiglare, Interior rear view mirror 200
Antiglare, Rear view mirrors* 201
Antilock Brake System see ABS
Anti-theft systems 104
Anti-theft alarm system 103, 104
Immobilizer 103
Aquaplaning see Hydroplaning
Armrest storage compartments
Front 296
Ashtrays* 300
Aspect ratio 394
ATF 362
Attaching a trailer 344
Audio menu 159
CD operation 161
Radio operation 160
Satellite radio* operation
(USA only) 160
Auto-dimming*, Rear view mirrors 201
Automatic central locking,
Control system 176

554 IndexAutomatic climate control (3-zone)* 220
Air conditioning, Cooling 230, 231
Air distribution, Front 226
Air distribution, Rear 234
Air recirculation mode 228
Air vents, Front 226
Air volume 227
Control panel, Front 222
Control panel, Rear 232
Deactivating system 224
Defogging 227
Defrosting 227
Maximum cooling, MAX COOL 228
Rear passenger compartment 232
Rear window defroster 205
Residual engine heat (REST) 232
Using driver-side settings for
all temperature zones 231
Automatic headlamp mode 137
Automatic lighting control, Interior
lighting 143
Automatic locking when driving 126
Automatic shift program
(ML 63 AMG only) 196Automatic transmission 54
Accelerator position 191
Automatic shift program
(ML 63 AMG only) 196
Emergency operation
(Limp-Home Mode) 198
Gear ranges 193
Gear selector lever 54, 185
Gear shifting malfunctions 198
Hill start assist system 192
Kickdown 191
Kickdown, manual shift program
(ML 63 AMG only) 198
Manual shift progam
(ML 63 AMG only) 196
Program mode selector switch
(ML 63 AMG only) 195
Shift program (ML 63 AMG only) 195
Shifting procedure 188
Starting the engine 54
Steering wheel gearshift control 194
Towing a trailer 192
Transmission fluid level 362
Transmission positions 189
Automatic Transmission Fluid see ATFB
Backrest
Seat 44
Seat, Lumbar support 130
Seat, Multicontour* 130
Backup lamps
Messages in the
multifunction display 458
Replacing bulbs 490
Bar 395
BAS 97
Lamps in instrument cluster 414
Messages in the
multifunction display 430
Basic carrier bars* 281
Batteries, SmartKey
Check lamp 108, 112
Checking battery condition 111
Messages in the
multifunction display 446
Replacing 480
Battery, Vehicle 507
Charging 514
Disconnecting and connecting 509
Jump starting 515
Removing and installing 509

560 IndexETD 80, 423
Safety guidelines 73
Expanding cargo compartment 284
Exterior rear view mirrors 49, 201
Folding 202
Power folding* 202
Synchronizing 202
F
Fastening the seat belts 51
Filler neck, Engine oil
(ML 350, ML 320 CDI) 361
Filler neck, Engine oil
(ML 500, ML 63 AMG) 361
First aid kit 469
Flat tire 497
Collapsible tire
(ML 63 AMG only) 474, 538
Lifting the vehicle 498
Lowering the vehicle 504
Minispare wheel
(except ML 63 AMG) 473
Mounting the spare wheel 498
Preparing the vehicle 498
Spare wheel 538Flexible Service System PLUS see FSS
PLUS
Floormats* 303
Fluids
Automatic transmission fluid 362
Brake fluid 354, 544, 546
Capacities 543
Engine coolant 354, 362, 549
Engine oil 358, 546
Power steering fluid 544
Windshield washer and
headlamp cleaning system* 355,
545, 551
Fog lamps 139
Corner-illuminating front fog
lamps* 140
Messages in the
multifunction display 458
Rear fog lamp 139
Replacing bulbs 488
4-ETS 102
Off-road - 4-ETS 102Front air bags 75
Front defroster 213, 227
Front lamps see Headlamps
Front passenger front air bag 70, 75
Messages in the multifunction
display 440, 441, 442, 443
Front passenger front air bag off indicator
lamp 31, 89, 426, 427
Front seat heat restraints see
Head restraints
Front towing eye 520
FSS PLUS (Canada vehicles) 361, 402
Fuel 353
Additives 547
Capacities, Fuel tank 545
Consumption statistics 180, 181
Diesel fuel 545
Filling the tank 352
Fuel filler flap and cap 352, 477
Fuel gauge 29
Fuel tank reserve warning lamp 29,
420
Premium unleaded gasoline 353,
547, 548
Requirements, Octane rating 548