2007 MERCEDES-BENZ G500 transmission

273 Operation
Engine compartment
Adding engine oil
G500
1Filler cap
G55AMG
1Filler cap
Unscrew filler cap1 from filler neck.
Add engine oil as required. Never over-
fill with oil.
Be careful not to spill any oil when adding.
Avoid environmental damage caused by oil
entering the ground or water.
Screw filler cap1 back on filler neck.
For more information on engine oil, see the
“Technical data” section (
page 423) and
(
page 425).
Transmission fluid level
The transmission fluid level does not need
to be checked. If you notice transmission
fluid loss or gear shifting malfunctions,
have an authorized Mercedes-Benz Light
Truck Center check the automatic trans-
mission.
!Only use approved engine oils and oil filters
required for vehicles with Maintenance System
(U.S. vehicles) or FSS (Canada vehicles). For a
listing of approved engine oils and oil filters,
refer to the Factory Approved Service Products
pamphlet (USA only) in your vehicle literature
portfolio, or contact an authorized
Mercedes-Benz Light Truck Center.
Using engine oils and oil filters of specification
other than those expressly required for the
Maintenance System (U.S. vehicles) or FSS
(Canada vehicles), or changing of oil and oil filter
at change intervals longer than those called for
by the Maintenance System (U.S. vehicles) or
FSS (Canada vehicles) will result in engine or
emission control system damage not covered by
the Mercedes-Benz Limited Warranty.
!Excess oil must be siphoned or drained off.
It could cause damage to the engine and/or
catalytic converter not covered by the
Mercedes-Benz Limited Warranty.

292 Operation
Tires and wheels
Tire inflation pressure warnings
If the system detects a significant loss of
tire inflation pressure in one or more than
one tire, a message appears in the multi-
function display.
Example illustration
The respective tire is indicated by a red
rectangle. In addition, a warning signal
sounds.Restarting Advanced TPMS
The TPMS usually recognizes new refer-
ence values automatically, for example
when you have

adjusted the tire inflation pressure

changed wheels or tires

mounted new wheels or tires
USA only: When the malfunction indicator is
illuminated, the system may not be able to
detect or signal low tire pressure as
intended.
USA only: Advanced TPMS malfunctions
may occur for a variety of reasons, including
the installation of replacement or alternate
tires or wheels on the vehicle that prevent
the Advanced TPMS from functioning prop-
erly. Always check the Advanced TPMS mal-
function telltale after replacing one or more
tires or wheels on your vehicle to ensure
that the replacement or alternate tires and
wheels allow the Advanced TPMS to contin-
ue to function properly.
iOperating radio transmission equipment
(e.g. wireless headsets, two-way radios) in or
near the vehicle could cause the Advanced
TPMS to malfunction.
Warning!G
It is the driver’s responsibility to calibrate
the TPMS on the recommended cold infla-
tion pressure. Underinflated tires affect the
ability to steer or brake the vehicle. You
might lose control over the vehicle.


304 Operation
Tires and wheels
Tire ply material
1Plies in sidewall
2Plies under tread
This marking tells you about the type of
cord and number of plies in the sidewall
and under the tread.Tire and loading terminology
Accessory weight
The combined weight (in excess of those
standard items which may be replaced) of
automatic transmission, power steering,
power brakes, power windows, power
seats, radio, and heater, to the extent that
these items are available as
factory-installed equipment (whether
installed or not).
Air pressure
The amount of air inside the tire pressing
outward on each square inch of the tire.
Air pressure is expressed in pounds per
square inch (psi), or kilopascal (kPa) or
bars.
Aspect ratio
Dimensional relationship between tire
section height and section width
expressed in percentage.Bar
Another metric unit for air pressure. There
are 14.5038 pounds per square inch (psi)
to 1 bar; there are 100 kilopascals (kPa)
to 1 bar.
Bead
The tire bead contains steel wires wrapped
by steel cords that hold the tire onto the
rim.
Cold tire inflation pressure
Tire inflation pressure when your vehicle
has been sitting for at least 3 hours or
driven no more than 1 mile (1.6 km).
Curb weight
The weight of a motor vehicle with stan-
dard equipment including the maximum
capacity of fuel, oil, and coolant, and, if so
equipped, air conditioning and additional
optional equipment, but without passen-
gers and cargo.
iFor illustration purposes only. Actual data
on tires are specific to each vehicle and may vary
from data shown in above illustration.

363 Practical hints
What to do if …
Display symbolDisplay messagePossible cause/consequencePossible solution
§Transfer
case
Visit
workshopThe transfer case is malfunctioning.Do not switch the transfer case on.
Contact an authorized Mercedes-Benz
Light Truck Center as soon as
possible.
TC
shift
procedure
canceledThe shift process in the transfer case was
canceled because of a malfunction.Repeat the shift process (page 170).
TC
shift
conditions
not fulfilledYou have not met the shift conditions for
a selection process in the transfer case.Repeat the shift process (page 170).
TC
in neutralNo gear has been selected in the transfer
case, it is in NEUTRAL.Engage transfer case to gear position
HIGH or LOW (
page 170).
Warning!G
If the transfer case is in NEUTRAL,
thePposition of the transmission will not
hold the vehicle. The parking brake must be
applied to hold vehicle in place.

403 Practical hints
Towing the vehicle
Transporting the vehicle
When transporting the vehicle, you can use
the towing eyes for pulling the vehicle onto
a trailer or transporter.
Move the gear selector lever to neutral
positionN.
Shift the transfer case to neutral
positionN.
To avoid damaging the vehicle, it
should only be tied down on the
wheels/wheel rims, not on chassis
components such as the transverse
link or trailing arm.Towing the vehicle - various problem
scenarios
Comply with all towing information
(
page 401).
In case of engine damage, transmission
damage or malfunctions in electrical
equipment
Move the gear selector lever to neutral
positionN.
Shift the transfer case to neutral
positionN.In case of transfer case damage or for
towing vehicle distances exceeding
30 miles (50 km)
The propeller shafts to the drive axles must
be removed.
In case of front axle damage
Raise the front axle when towing. The
propeller shaft between the rear axle and
the transfer case must be removed.
In case of rear axle damage
When the rear axle is raised, the vehicle
can only be towed with a wheel lift or a
dolly placed under its front wheels.
!When removing drive shaft, place M10 nuts
on bolts as distance sleeves and tighten
using M8 nuts.
Always install new self-locking nuts when
reinstalling the drive shaft.

423 Technical data
Fuels, coolants, lubricants, etc.
ModelCapacityFuels, coolants, lubricants, etc.
Engine with oil filterG 500
G55AMG8.5 US qt (8.0 l)
9.0 US qt (8.5 l)Approved engine oils
Automatic transmission9.0 US qt (8.5 l)MB Automatic Transmission Fluid
Transfer case2.96 US qt (2.8 l)MB part no. A 001 989 28 03 10
Differential lock mechanism0.47 - 0.63 US qt (0.45 - 0.6 l)Brake fluid DOT 3+4, SAE J 1703
Front axleG 500
G55AMG1.5 US qt (1.4 l)
1.5 US qt (1.4 l)Hypoid gear oil SAE 85W-90
Hypoid gear oil Castrol SAF-XJ
Rear axleG 500
G55AMG1.9 US qt (1.8 l)
1.9 US qt (1.8 l)Hypoid gear oil SAE 85W-90
Hypoid gear oil Castrol SAF-XJ
Power steeringapprox. 1.06 US qt (1.0 l)MB Power Steering Fluid, or
approved Dexron III ATF
Front wheel hubsapprox. 1.5oz (43g) eachHigh temperature roller bearing grease
Brake system0.86 US qt (0.81 l)MB Brake Fluid (DOT 4+)

431 Index
A
ABS 27, 88
Indicator lamp 324–325, 327
LOW RANGE mode 90
Messages in display 340
Accelerator position (Automatic
transmission) 166
Accessory weight 304
Accident
In case of 61
Activating
Air conditioning (cooling) 190
Air recirculation mode 188
Anti-theft alarm system 97
Central locking (control system) 155
Defrost 187
Easy-entry/exit feature 156
ESP
®95
Exterior headlamps 56
Exterior lamps 118
Exterior rear view mirror parking
position 178Headlamps 56
Immobilizer 96
Rear window defroster 181
Windshield defroster 181
Windshield wipers 58
Adding
Coolant 275
Engine oil 273
Additional turn signals 378
Adjusting 41
Air distribution 186
Air volume 186
Exterior rear view mirrors 46
Head restraint fore and aft
adjustment 43
Head restraint height 43
Head restraint height, rear seats 110
Instrument cluster illumination 130
Interior rear view mirror 46
Mirrors 46
Multicontour seat* 109Seat backrest tilt 43
Seat cushion depth 109
Seat cushion tilt 43
Seat fore and aft adjustment 43
Seat height 43
Seats 41
Steering column in/out 45
Steering column up/down 45
Steering wheel 44
Advanced TPMS
Messages in display 342–343,
361–362
Air bags 70
BabySmart
TM air bag deactivation
system 81
Front 73
Safety guidelines 72
Window curtain air bags 74
Air conditioning 189
Air conditioning refrigerant 425
Air distribution
Adjusting 186

432 Index
Air pressure 304
Air pressure see Tire inflation pressure
Air recirculation mode 188
Activating 188
Deactivating 189
Air vents, Rear
Climate control 191
Air volume
Adjusting 186
Alarm
Audible 87, 96
Canceling 97, 98
Visual 96
Alarm system
Anti-theft 96
Anticorrosion/antifreeze 428
Anti-theft alarm system
Arming 97
Canceling alarm 97
Disarming 97
Anti-theft systems 96
Anti-theft alarm system 96
Tow-away alarm 98
Aquaplaning see HydroplaningArmrest
Storage box in front of 217
Storage compartments below 216
Telephone* tray below 216
Ashtrays 220
In center console 220
In rear passenger compartment 221
Aspect ratio 304
At the gas station 264
ATF (automatic transmission fluid) 273
Audio menu 141
Selecting radio station 141
Audio search function 155
Auto-dimming for rear view mirror 177
Automatic central locking
Activating/deactivating (control
system) 155
Automatic headlamp mode 118
Automatic locking when driving 106
Automatic operation
Interior lighting control 125Automatic transmission 162
Accelerator position 166
Emergency operation (Limp Home
Mode) 169
Fluid level 273
Gear ranges 167
Gear selector lever 162
Gear selector lever position 163, 164
Gear shifting malfunctions 169
Kickdown 166
One-touch gearshifting 168
Shifting procedure 163
Transmission fluid 273
B
BabySmart
TM
Air bag deactivation system 81
Compatible child seats 81
Self-test 82
Backup lamp
Message in display 357
Backup lamps
Bulbs 378
Replacing bulbs 386
Bar 304
BAS 88, 90