2007 MERCEDES-BENZ CLK350 COUPE spare wheel

416 Practical hints
Flat tire
Mounting the Minispare wheel
Preparing the vehicle
Prepare the vehicle as described
(
page 415).
Take the wheel wrench, alignment bolt,
collapsible wheel chock, and the jack
out of the trunk (
page 394).
Take the Minispare wheel and wheel
bolts out of the trunk (
page 397).Lifting the vehicle
Prevent the vehicle from rolling away
by blocking wheels with wheel chocks
or other sizeable objects.
One wheel chock is included with the
vehicle tool kit (
page 394).
When changing wheel on a level surface:
Place the wheel chock in front of and
another sizeable object behind the
wheel that is diagonally opposite to the
wheel being changed.
Always try lifting the vehicle using the jack
on a level surface. However, should
circumstances require you to do so on a
hill, place the wheel chock and the other
sizeable object as follows:
Place the wheel chock and another
sizeable object on the downhill side
blocking both wheels of the axle not
being worked on.
Warning!G
The jack is designed exclusively for jacking
up the vehicle at the jack take-up brackets
built into both sides of the vehicle. To help
avoid personal injury, use the jack only to lift
the vehicle during a wheel change. Never
get beneath the vehicle while it is supported
by the jack. Keep hands and feet away from
the area under the lifted vehicle. Always
firmly set parking brake and block wheels
before raising vehicle with jack.
Do not disengage parking brake while the
vehicle is raised. Be certain that the jack is
always vertical (plumb line) when in use,
especially on hills. Always try to use the jack
on level surface. Make sure the jack arm is
fully seated in the jack take-up bracket.
Always lower the vehicle onto sufficient
capacity jackstands before working under
the vehicle.

418 Practical hints
Flat tire
Removing the wheel
1Alignment bolt
Unscrew upper-most wheel bolt and
remove.
Replace this wheel bolt with alignment
bolt1 supplied in the tool kit.
Remove the remaining bolts.
Remove the wheel.Mounting the spare wheel
1Wheel bolt for light alloy rims
2Wheel bolt for Minispare wheel,
(located in trunk with Minispare wheel)
Clean contact surfaces of wheel and
wheel hub.
!Do not place wheel bolts in sand or dirt. This
could result in damage to the bolts and wheel
hub threads.
!Wheel bolts2 must be used when mount-
ing the Minispare wheel. The use of any wheel
bolts other than wheel bolts2 for the Minispare
wheel will physically damage the vehicle’s
brakes.
!To avoid paint damage, place wheel flat
against hub and hold it there while installing first
wheel bolt.
Warning!G
Always replace wheel bolts that are
damaged or rusted.
Never apply oil or grease to wheel bolts.
Damaged wheel hub threads should be
repaired immediately. Do not continue to
drive under these circumstances! Contact
an authorized Mercedes-Benz Center or call
Roadside Assistance.
Incorrect wheel bolts or improperly tight-
ened wheel bolts can cause the wheel to
come off. This could cause an accident.
Make sure to use the correct wheel bolts.

419 Practical hints
Flat tire
1Alignment bolt
Guide spare wheel onto the alignment
bolt and push it on.
Insert wheel bolts and tighten them
slightly.
Unscrew the alignment bolt, install last
wheel bolt and tighten slightly.
Lowering the vehicle
Lower vehicle by turning crank
counterclockwise until vehicle is
resting fully on its own weight.
Remove the jack.1 - 5Wheel bolts
Tighten the five wheel bolts evenly,
following the diagonal sequence
illustrated (1to5), until all bolts are
tight. Observe a tightening torque
of 80 lb-ft (110 Nm).
Warning!G
Only use Genuine equipment
Mercedes-Benz wheel bolts. Other wheel
bolts may come loose.
Do not tighten the wheel bolts when the
vehicle is raised. Otherwise the vehicle
could fall off the jack.
Warning!G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque
of 80 lb-ft (110 Nm).

431 Practical hints
Fuses
Fuses
The electrical fuses in your vehicle serve to
switch off malfunctioning power circuits.
If a fuse is blown, the components and sys-
tems secured by that fuse will stop operat-
ing.If a newly inserted fuse blows again, have
the cause determined and rectified by an
authorized Mercedes-Benz Center.
The following aids are available to help you
replace fuses.

Fuse chart
The fuse chart is located in the main
fuse box in the passenger compart-
ment (
page 432). The fuse chart ex-
plains the fuse allocation and fuse
amperages.

Spare fuses
Spare fuses are located in the vehicle
tool kit in the spare wheel well
(
page 395).

Fuse extractor
The fuse extractor is located in the cov-
er of the auxiliary fuse box in the trunk
(
page 434).The electrical fuses are located in different
fuse boxes:

in the passenger compartment on the
driver’s side (
page 432)

on the driver’s side of the engine com-
partment (
page 433)

in the trunk (page 434)
Before replacing fuses:
Apply the parking brake (page 59).
Make sure the gear selector lever is set
to position P (
page 170).
Turn off all electrical consumers.
Turn off the engine (page 60).
Remove the SmartKey from the starter
switch.
Vehicles with KEYLESS-GO*:
Open the driver’s door.
Warning!G
Only use fuses approved by Mercedes-Benz
with the specified amperage for the system
in question and do not attempt to repair or
bridge a blown fuse. Using other than ap-
proved fuses or using repaired or bridged
fuses may cause an overload leading to a
fire, and/or cause damage to electrical
components and/or systems. Have the
cause determined and remedied by an
authorized Mercedes-Benz Center
iA blown fuse must be replaced by an appro-
priate spare fuse (recognizable by its color or the
fuse rating given on the fuse) of the amperage
recommended in the fuse chart.
Any Mercedes-Benz Center will be glad to advise
you on this subject.

445 Technical data
Rims and tires
Minispare wheel
ModelAll Models
Rim3.5 B x 17 H2
Wheel offset0.67 in (17 mm)
Tire1
1Must not be used with snow chains.
T 125/80 R 17 99M
!Please compare the recommended tire in-
flation pressure for your vehicle with the tire in-
flation pressure on the yellow label located on
the spare wheel rim.
If the tire inflation pressure on the yellow label
on the spare wheel rim differs from the values
given in this Operator’s Manual, inflate the spare
wheel tire to the recommended tire inflation
pressure given on the yellow label on the spare
wheel rim.
iPlease note that the tire inflation pressure of
the Minispare tire differs from the tire inflation
pressure of the road tires.
Make sure the Minispare tire is inflated to ap-
proximately 61 psi (4.2 bar).

458 Index
Automatic transmission
Accelerator position 172
Automatic shift program 174
Emergency operation
(limp-home mode) 178
Gear ranges 173
Gear selector lever 50, 168
Gear selector lever control
one-touch gearshifting 175
Gear selector lever positions 170
Gear shifting malfunctions 178
Kickdown 172
Program mode selector switch 174
Shifting procedure 169
Starting engine 50
Steering wheel gearshift control
one-touch gearshifting* 177
Transmission fluid level 309
Automatic Transmission Fluid see ATFB
Backrest 264
Seat, Multicontour* 123
Seat, Power 40
Backup lamps
Messages in display 389
Replacing bulbs 406, 407
Bar 337
BAS 90
Batteries, SmartKey
Changing 404
Checking battery condition 107
Battery, Vehicle 311, 421
Charging 423
Connecting 424
Disconnecting 422
Installing 423
Jump starting 425
Messages in display 378
Removing 423Bead 337
Beverage holder see Cup holder
Block heater (Canada only) 342
Bolts, Spare wheel 398
Brake fluid 450
Checking 305
Message in display 379
Brake lamp
Cleaning lenses 350
High mounted 407
Replacing bulbs 407, 411
Brake pads
Message in display 379
Brakes 294
Warning lamp 358
Break-in period 292
Bulbs, replacing see Replacing bulbs

462 Index
Emergency tensioning device see ETD
Emergency, In case of
Battery, Jump starting 425
First aid kit 394
Flat tire, Changing 415
Fuses 431
Hazard warning flasher 135
Roadside Assistance 12, 282
Towing the vehicle 427
Emission control 302
Emission control information label 439
Emission control vacuum line
routing diagram label 439
Emission system warranties 10
Engine
Belt layout 440
Block heater (Canada only) 342
Break-in recommendations 292
Cleaning 348
Compartment 306
Malfunction indicator lamp 27, 359
Maximum engine speed 441
Message in display 380
Number 439
Starting 50
Starting difficulties 52Starting with KEYLESS-GO* 51
Starting with SmartKey 51
Technical data 441
Turning off 60
Turning off with KEYLESS-GO* 61
Turning off with SmartKey 61
Engine coolant see Coolant
Engine oil 308, 450
Adding 309, 450
Additives 450
Changing 309, 450
Checking level 305, 308
Consumption 308
Filler cap 309
Filler neck 309
Engine oil level 305
ESP
®91
Messages in display 370–371
Warning lamp 362
ETD 78
Safety guidelines 68
Exterior rear view mirrors 45, 180
Exterior view 22F
Filler cap, Engine oil 309
Filler neck, Engine oil 309
First aid kit 394
Flat tire 415
Jacking up the vehicle 416
Lowering the vehicle 419
Minispare wheel 397
Mounting the spare wheel 416
Preparing the vehicle 415
Flexible Service System
see FSS (Canada vehicles)
Floormats* 275
Fluids
Brake fluid 305, 450
Engine coolant 305
Engine oil 305, 450
Windshield washer and headlamp
cleaning* system 305, 449
Fog lamps 132, 407
Messages in display 387
Replacing bulbs 407, 408, 411
Front air bags 69
Front lamps see Headlamps

467 Index
Lock buttons
Door handle (KEYLESS-GO*) 62, 105
Trunk lid (KEYLESS-GO*) 106
Loss of keys 107
Loss of Service and
Warranty Information Booklet 437
Low beam headlamps
Indicator lamp 27
Messages in display 388
Replacing bulbs (Bi-Xenon*) 407
Replacing bulbs (Halogen) 407, 409
Switching on 27, 55
Lubricants 448M
Maintenance 12, 343
Calling up service indicator 345
Clearing service indicator 344
FSS (Canada vehicles) 343
Maintenance System
(U.S. vehicles) 343
Resetting service indicator 345
Service indicator 343
Service term exceeded 344
Maintenance system (U.S. vehicles) 343
Manual headlamp mode see Headlamps
MAXCOOL maximum cooling 201
Maximum load rating, Tires 338
Maximum loaded vehicle weight,
Tire inflation pressure 338
Maximum tire inflation pressure 338
Mechanical key 399
Memory function see Seats, Power
Menus see Control system menus
Microphone, Hands-free 31
Minispare wheel see Spare wheelMirrors
Adjusting 45
Antiglare position 179
Auto-dimming 180
Exterior rear view mirrors 45
Interior rear view mirror 45
Mobile phone see Telephone*
MOE tires* see MOExtended system*
MOE* see MOExtended system*
MOExtended system* 420
MOExtended tires* 442
MON 304
Motor Octane Number see MON
MP3 224
Multicontour seat*
see Seats, Multicontour*
Multifunction display 141
Changing settings
see Control system menus and
Control system submenus
Selecting language 154
Symbol messages 378–393
Text messages 370–376