2007 MAZDA MODEL B3000 TRUCK warning

1. Start the engine and let it run until it reaches normal operatingtemperature (the engine coolant temperature gauge indicator will be
near the center of the normal area between H and C).
2. While the engine idles, turn the steering wheel left and right several times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN and MAX lines. Do not add fluid if the level is within this range.
5. If the fluid is low, add fluid in small amounts, continuously checking the level until it reaches the FULL HOT range. Be sure to put the
dipstick back in the reservoir.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels below the “MAX” line
that do not trigger the brake system
warning lamp are within the normal
operating range, there is no need to
add fluid. If the fluid levels are outside of the normal operating range,
the performance of your brake system could be compromised, seek
service from your authorized dealer immediately. WARNING: Brake fluid is toxic. If brake fluid contacts the
eyes, flush eyes with running water for 15 minutes. Seek
medical attention if irritation persists. If taken internally, drink
water and induce vomiting. Seek medical attention immediately.
WARNING: If you use a brake fluid that is not DOT 3, you will
cause permanent damage to your brakes.
WARNING: Do not let the reservoir for the master cylinder run
dry. This may cause the brakes to fail.
MAX
2007 B-Series (mbs)
Owners Guide (post-2002-fmt)
USA (fus)
Maintenance and Specifications
254

CLUTCH FLUID (IF EQUIPPED)
Check the fluid level. Refer toscheduled maintenancefor the service
interval schedules.
During normal operation, the fluid level in the clutch reservoir should
remain constant. If the fluid level drops, refill the fluid level to the step
in the reservoir.
Use only a DOT 3 brake fluid designed to meet Mazda specification.
Refer to Maintenance product specifications and capacities in this
chapter.
WARNING: Carefully read cautionary information on product
label. For MEDICAL EMERGENCY INFORMATION contact a
physician or Poison Control Center immediately. Failure to
follow these instructions may result in personal injury.
1. Clean the reservoir cap before removal to prevent dirt and
water from entering the
reservoir.
2. Remove cap and rubber diaphragm from reservoir.
3. Add fluid until the level reaches the step in the reservoir.
4. Reinstall rubber diaphragm and cap onto reservoir.
TRANSMISSION FLUID
Checking automatic transmission fluid
• Refer to scheduled maintenance information for scheduled check
and change intervals.
• Transmission does not consume fluid.
• Check fluid when transmission is not operating properly or if you see
a leak.
• Fluid level must be checked at normal operating temperature, 20 miles
(30 km) of driving.
To check and add fluid: 1. Drive the vehicle 20 miles (30 km) to reach normal operating temperatures.
2007 B-Series (mbs)
Owners Guide (post-2002-fmt)
USA (fus)
Maintenance and Specifications
255

ItemApplicationMazda part name or
equivalent Capacity
Fuel tank Regular cab
(Short wheel base) —17 gallons (64.4L)
Cab Plus 4 19.5 gallons (73.8L)
1Brake fluid will drop slowly as the brakes wear and will rise when brake components are replaced.
Fluid levels below the MAX line that do not trigger the brake warning light are within the normal
operating range, there is no need to add fluid. If the levels are outside the normal operating range,
the performance of your brake system could be compromised, seek service from your authorized
dealer immediately.2Add the coolant type originally equipped in your vehicle. Do not mix different colors or types of
coolant. Do not use Mazda Extended Life Engine Coolant (orange in color). Refer to Adding
engine coolant, in this chapter.3Service refill capacity is determined by filling the transmission to the bottom of the filler hole with
the vehicle on a level surface.4Ensure the correct automatic transmission fluid is used. Transmission fluid requirements are
indicated on the dipstick or on the dipstick handle. MERCON
and MERCON
V are not
interchangeable. DO NOT mix MERCON
and MERCON
V. Refer toscheduled maintenance to
determine the correct service interval.5Indicates only approximate dry-fill capacity. Some applications may vary based on cooler size and
if equipped with an in-tank cooler. The amount of transmission fluid and fluid level should be set
by the indication on the dipstick’s normal operating range.6Traction-Lok axles use 4.75–5.0 pints (2.2–2.4L) of rear axle lubricant. Add 4 oz. (118 ml) of
Additive Friction Modifier meeting Mazda specifications for complete refill of Traction-Lok axles.
Service refill capacities are determined by filling the rear axle 1/4 inch to 9/16 inch (6 mm to 14
mm) below the bottom of the filler hole.
If submerged in water, the rear axle lubricant should be changed.
2007 B-Series (mbs)
Owners Guide (post-2002-fmt)
USA (fus)
Maintenance and Specifications
263

CELL PHONES
Use of cell phones and other devices by driver:WARNING: Use of any electrical devices such as cell phones,
computers, portable radios, vehicle navigation or other devices
by the driver while the vehicle is moving is dangerous. Dialing a
number on a cell phone while driving also ties-up the driver’s
hands. Use of these devices will cause the driver to be
distracted and could lead to a serious accident. If a passenger is
unable to use the device, pull off the right-of-way to a safe area
before use. If use of a cell phone is necessary despite this
warning, use a hands-free system to at least allow the hands
free to drive the vehicle. Never use a cell phone or other
electrical device while the vehicle is moving and, instead,
concentrate on the full-time job of driving.
In addition, the gasoline distributors are warning against using
cell phones during refueling procedures, due to their increased
concern about static electricity fires in the self-service pump
environment.
2007 B-Series (mbs)
Owners Guide (post-2002-fmt)
USA (fus)
Accessories
268

A
ABS (see Brakes) .....................153
Airbag supplemental restraint
system ..........................................90and child safety seats ..............93
description ................................90
disposal ......................................95
driver airbag ........................90, 93
indicator light ...........................94
operation .............................90, 93
passenger airbag .................90, 93
Ambulance packages ....................7
Antifreeze
(see Engine coolant) ................237
Anti-lock brake system
(see Brakes) ......................153–154
Anti-theft system ........................69
Audio system Single CD ..................................21
Audio system (see Radio) ..19, 21, 24, 29, 32
Automatic transmission ............157 driving an automatic
overdrive .................................159
fluid, specification ..................260
Auxiliary Input Jack ...................37
Auxiliary power point .................57
Axle lubricant specifications ..........260
traction lok ..............................156
B
Battery .......................................235 acid, treating emergencies .....235
jumping a disabled battery ....191
maintenance-free ....................235 servicing ..................................235
Bed extender ..............................63
BeltMinder
.................................85
Brakes ........................................153 anti-lock ...........................153–154
anti-lock brake system (ABS)
warning light ...........................154
fluid, checking and adding ....254
fluid, specifications .................260
lubricant specifications ..........260
parking ....................................154
shift interlock ..........................157
Break-in period .............................5
Bulbs ............................................49
C
Cell phone warning ...................268
Changing a tire .........................181
Child safety restraints ................99 child safety belts ......................99
Child safety seats ......................103 attaching with tether straps ..106
in front seat ............................104
in rear seat ..............................104
tether anchorage hardware ...106
Chimes (warning) .......................17
Cleaning your vehicle engine compartment ..............210
instrument panel ....................213
interior .....................................214
interior trim ............................213
Mazda car care products .......214
plastic parts ............................212
washing ....................................209
waxing .....................................209
wheels ......................................210
wiper blades ............................212
2007 B-Series (mbs)
Owners Guide (post-2002-fmt)
USA (fus)
Index
269

running out of fuel .................247
safety information relating to
automotive fuels .....................243
Fuel pump shut-off switch .......170
Fuses ..................................171–172
G
Gas cap (see Fuel cap) ............245
Gas mileage
(see Fuel economy) .................247
Gauges .........................................17
H
Hazard flashers .........................170
Headlamps ...................................45 aiming ........................................47
bulb specifications ....................49
daytime running lights .............46
flash to pass ..............................46
high beam .................................45
replacing bulbs .........................50
turning on and off ....................45
Heating heating and air conditioning
system .................................42–43
Hood ..........................................224
I
Ignition ...............................149, 264
Infant seats
(see Safety seats) .....................103
Inspection/maintenance (I/M)
testing ........................................252
Instrument panel cleaning ...................................213 cluster ........................................12
lighting up panel and
interior .......................................46
location of components ............12
J
Jack ............................................181 positioning ...............................181
storage .....................181, 184–185
Jump-starting your vehicle ......191
K
Keys .......................................65, 70 positions of the ignition .........149
L
Lamps bulb replacement
specifications chart ..................49
daytime running light ...............46
fog lamps ...................................45
headlamps .................................45
headlamps, flash to pass ..........46
instrument panel, dimming .....46
interior lamps .....................49–50
replacing bulbs .........................50
Lane change indicator
(see Turn signal) ........................48
Lights, warning and indicator ....12 anti-lock brakes (ABS) ..........154
Load limits .................................132
Loading instructions .................138
Locks doors ..........................................65
Lubricant specifications ...........260
Lug nuts ....................................190
2007 B-Series (mbs)
Owners Guide (post-2002-fmt)
USA (fus)
Index
271

M
Manual transmission .................161lubricant specifications ..........260
reverse .....................................162
Mirrors .........................................59 fold away ...................................59
side view mirrors (power) .......59
Motorcraft parts ........................242
O
Octane rating ............................246
Oil (see Engine oil) ..................229
Overdrive .....................................62
Overheating ...............................190
P
Parking brake ............................154
Passenger Occupant
Classification Sensor ...................76
Power distribution box
(see Fuses) ...............................175
Power door locks ........................65
Power mirrors .............................59
Power point .................................57
Power steering ..........................155 fluid, checking and adding ....253
fluid, specifications .................260
Power Windows ...........................58
Preparing to drive your
vehicle ........................................156
R
Radio ....................19, 21, 24, 29, 32 Single CD ..................................21 Relays ........................................171
Remote entry system .................66
illuminated entry ......................69
locking/unlocking doors ...........66
panic alarm ...............................66
replacing the batteries .............67
S
Safety Belt Maintenance ............84
Safety belts (see Safety
restraints) ........................74, 78–83
Safety restraints ..............74, 78–83 BeltMinder
..............................85
extension assembly ..................84
for adults .............................79–82
for children .........................98–99
Occupant Classification
Sensor ........................................76
safety belt maintenance ...........84
warning light and chime ..........85
Safety restraints - tether
anchors ......................................106
Safety seats for children ..........103
Safety Compliance
Certification Label ....................266
Satellite Radio Information ........38
Seat belts
(see Safety restraints) ...............74
Seats ............................................72 child safety seats ....................103
SecuriLock passive anti-theft
system ..........................................69
Servicing your vehicle ..............223
Setting the clock AM/FM stereo ...........................19
AM/FM stereo CD ...............21, 24
2007 B-Series (mbs)
Owners Guide (post-2002-fmt)
USA (fus)
Index
272

Premium AM/FM stereo
CD6/MP3 .............................29, 33
Snowplowing .................................7
Spark plugs, specifications .......264
Special notice ambulance conversions ..............7
utility-type vehicles ....................6
Specification chart,
lubricants ...................................260
Speed control ..............................59
Starting your vehicle ........149–151 jump starting ..........................191
Steering wheel tilting .........................................57
Stereo Single CD ..................................21
T
Tether anchors ..........................106
Tilt steering wheel ......................57
Tire Pressure Monitoring
System (TPMS) Roadside Emergencies ...........181
Tires, Wheels and Loading ....128
Tires ...........................112–114, 181 alignment ................................120
care ..........................................117
changing ..........................181, 186
checking the pressure ............117
inflating ...................................115
label .........................................127
replacing ..................................118
rotating ....................................121
safety practices .......................119
sidewall information ...............123
snow tires and chains ............132 spare tire .........................182, 184
terminology .............................114
tire grades ...............................113
treadwear ........................113, 117
Towing .......................................138 recreational towing .................147
trailer towing ..........................138
wrecker ....................................197
Traction-lok rear axle ...............156
Transfer case fluid checking .........................258
Transmission automatic operation ...............157
brake-shift interlock (BSI) ....157
fluid, checking and adding
(manual) .................................257
lubricant specifications ..........260
manual operation ....................161
Turn signal ..................................48
V
Vehicle Identification Number
(VIN) ..........................................266
Vehicle loading ..........................132 camper bodies ........................148
Ventilating your vehicle ...........152
W
Warning chimes ...........................17
Warning lights (see Lights) .......12
Washer fluid ..............................228
Water, Driving through .............169
Windows power .........................................58
2007 B-Series (mbs)
Owners Guide (post-2002-fmt)
USA (fus)
Index
273